2019 TOYOTA RAV4 Complaints

Sudden, unexpected, surprise Surging Idle upon placing the vehicle in Park after driving a 15 minute distance at a top speed of 35mph. Loud Surge up to 2.5 (x1000RPM) Sounds like the Engine Shifted Idle Drops down and immediately begins Surging up again. Idle is high while driving. Some chugging upon acceleration. Immediately drove to Auto Parts store for Diagnostic Test. Started vehicle and showed Technicians what was happening. Diagnostic Test provided: Code P0171 Stored and Permanent System is Too Lean Bank 1 Code P0505 Stored and Pending Idle Control System P117B Stored Fuel Performance/Direct Injector Most Likely Solution: Replace Fuel Pump Primary DTC: System Too Lean Bank 1 Suggested Part: Fuel Pump Operating The Vehicle Could Result in Sudden Shut Down, causing a Collision. Could also Cause Compromised Gas Mileage and Engine Damage. Check Engine Light is On Additional Message states that All Wheel Drive Mode has been disengaged and 2 Wheel Drive Mode is active. No Warning or Any indication that there was any issues prior to the Sudden Idle Surging upon placing the vehicle in Park. I have searched existing recalls for 2019 Toyota Rav-4 and found a Fuel Pump listed. I checked my license plate and VIN only to see the result that there are Zero Unrepaired recalls for both searches. This vehicle is clearly having an internal battle between air and fuel. I find it concerning that 2019-2020 Toyota Rav-4 vehicles had a Fuel Pump recall and yet my search has Provided these results.

You get a message that said engine maintenance required contact the dealer, when you do the scan it's shows that there is a problem with engine coolant bypass valve. After checking online it was multiple people with the same problem.

1st: veh purchased Jan 2023 with new set of tires. Within 11k miles, about 9months: Rear tires unable to be aligned properly due to no camber adjustment. Rear tires have excessive inner rear (belts showing) with 11k miles on tires. Took veh to dealership and was told I just need a set of tires and an alignment. When the tech was questioned if it was an accurate alignment, we were told it would be off a couple degrees because the OE rear control arms did not have any adjustment. This was repaired by an independent shop using aftermarket set of rear control arms, a proper alignment and 2 new rear tires ($1200)--because Toyota dealer would not own any accountability of an error nor do the PROPER requested repair since proper repair did not involve OE Toyota parts. This was repaired, case closed and tires have 20k miles on them with beautiful, even wear. 2nd: Rear door hatch will not close electronically. 2 incidences of bent (left) hinge from forcing the tailgate closed and damaged rear taillamp from mis-alignment. Post hinges replaced: re-sets have been done, disabling door and re-enabling, and disconnected battery. Still will not close electronically. This had been occurring over a year and no one knows the fix. I will not be going back to my local stealership and the next one is 30 miles away.

Faulty coolant bypass valve at 115,000 miles. Seems to be a repeat issue for many Toyota owners. Not covered by the powertrain warranty, but a known issue by the manufacturer.

While driving at interstate speed and cruise control set, the cruise control stopped working and Cruise Control Malfunction errors, as well as Hybrid System Malfunction errors appeared. With other cars driving so closely behind me, the quick deceleration caught me off-guard and could have easily been hit from behind. I took the car to Toyota Dealership and appears there's already a known issue for a corroded traction cable and since not under warranty (due to mileage >120,000 miles) will cost $4668 to fix. Why is this not a recall if the problem is known?

The contact owns a 2019 Toyota Rav4. The contact stated while driving 60 MPH, the vehicle started swaying in and out the lane. There was no warning light illuminated. The contact linked the failure to the lane keep assist feature. The contact stated that the failure persisted. The contact continued to drive the vehicle and the vehicle violently jerked, forcing the contact to pull over. In addition, the contact stated that the vehicle was accelerating unintendedly upon releasing the accelerator pedal. The contact immediately pulled over and turned off the vehicle. The contact turned off the lane assist feature and proceeded to drive the vehicle at a slow speed. The contact stated that while accelerating above 35 MPH, the abnormal jerking returned. The vehicle was not repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 62,000.

The Engine Maintenance required light comes on when I use the air conditioner. I suspect the coolant bypass hose is not working properly.

I bought my Rav4 in 2019 brand new. For years, anytime there is a hard rain, the doors fill up with water. Water does not drain properly. I brought my car into Toyota a couple of years back. They told me that there was no fix and that when that happens, just to lift up the weather stripping on all four doors, to let the water drain. They acted like this is completely normal. Just last week, I brought my car in again to Toyota to see if they had a fix for it. They ended up charging me about $700 to replace all of the weather stripping on the doors. This is very clearly a manufacturing default and the customer should not be charged for what is a common issue with this car! If this is a well known issue at this point, why has this not been recalled? Again, the doors have had issue draining the water properly since day one and the car was brand new! Anytime the doors fill with water, you can literally hear the water splashing around in the doors while driving! I am not a happy customer. Toyota never takes responsibility!

There is a water accumulation problem in the doors. This could potentially cause some rot from the inside out causing electrical to fail or metal to rust and cause the affected door(s) to not open correctly. No warning lights came on or anything on the dashboard.

Check engine light came on and code P268115 was shown for coolant bypass valve internal failure. Valve was replaced by dealership and I was told it would not be covered under the Toyota Customer Support Program because that only covers valves that leak externally, not internal failures.