2019 TOYOTA RAV4 Complaints

Rear passenger door keeps flooding after rain. Bottom door seal needs to be physically lifted to the side for water to drain out of the door.

While driving or stopped at a light, car will switch drivings modes to “mud and sand” turning off the vehicle stability control and pre-collision system warning light will illuminate. After pressing desired mode, car will switch back to “mud and sand” at varying intervals resulting in me pressing the desired mode constantly while driving.

Faulty coolant valve and Toyota says that it is not covered/part of a recall. However, many vehicles are experiencing this issue so this seems like a widespread problem that Toyota is not taking responsibility for.

The contact owns a 2019 Toyota Rav4. The contact stated that upon starting the vehicle, several unknown warning lights illuminated, and several unknown messages were displayed. The contact stated that the transmission and steering wheel seized during the failure. The vehicle was towed to the dealer; however, no cause for the failure was found. The contact stated that unknown parts were replaced. The contact stated that the failure persisted and worsened during the cold months. The manufacturer was not notified of the failure. The failure mileage was approximately 55,000.

A Hybrid System Malfunction warning appeared about 1 week ago. The car was taken to the Toyota dealer who said that the car was safe to drive and that they would need to order a part and it will probably be weeks before they get it because so many other cars have the same problem. Three days later the car will not start with several errors including Brake Power low, PKSB Malfunction, and Precolllision System Malfunction. Toyota is not providing any coverage for any of our repair, car rental or now the need to tow the car.

Well, making my research it shows that the RAV4 2020 will have a recall with the brake booster that my car the 2019 is having the same issues and it’s a very expensive fix. My car only has 40,000 miles is still brand new and I don’t understand why am I having this issues with the brake booster RAV4 2020 has a recall for that same part so I would like them to honor the 2019 brake booster and fix it as well

An error code titled “Engine Maintenance Required. Visited your dealer” appeared on my dash screen. The error code was unable to be removed. I attempted have the car diagnosed by a private auto shop, however no faulty codes pop up. After research online, the problem was determined to be the engine coolant valve, which are faulty on many Rav4s. I eventually get a letter from Toyota for a Customer Support Program regarding the Engine Coolant Valve. When brought in for maintenance, Toyota pulled the error code “P268115” which is for an internal failure of the engine coolant valve. However, Toyota will not replace the part due to their Customer Support Program (24TE04) only covering the part for “small engine coolant leak[s]”. Essentially, Toyota will replace the part for being faulty if it had small leaks, but not if the part itself is faulty. When I asked the service member I was working with stated that this is a known problem and “[Toyota] should have just replaced the whole part, but they only do it for small leaks.” Currently, litigation is proceeding regarding the engine coolant valve, alleging Toyota knowingly put faulty parts in their Rav4s. I urge you to investigate this claim.

Door lock actuator has failed prematurely on all four doors, this prevents me from entering my vehicle in a quick and timely manner if there were to be an emergency

The contact owns a 2019 Toyota Rav4. The contact stated that when the vehicle was started, the vehicle was shaking abnormally. The contact stated that the overheating, parking brake, cruise control, maintenance required, and check engine warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed that there was a misfire in cylinder #2, and that coolant was leaking into the engine. The contact related the failure to NHTSA Campaign Number: 20V064000 (Engine and Engine Cooling); however, the VIN was not included. The vehicle was not repaired. The manufacturer was informed of the failure and opened a case. The failure mileage was unknown.

Engine Maintenance Required warning came on. Took car to dealership, diagnostic informed the issue was the coolant bypass valve. Repair cost is $781.28 + diagnostic $160.