2019 TOYOTA RAV4 Complaints

The engine coolant bypass valve has malfunctioned. this is caused a faulty part that toyota knows malfunctions often in their toyota rav4 for multiple years including the 2019. It can cause problems for the engine cooling component, meaning the vehicle overheats, as well as affects the cars internal A/C. It can only be diagnosed at the dealership, not through a normal diagnostic. There is currently a class action lawsuit, and many others owners of multiple years of the toyota rav4 have the same issue.

The trunk door has been having major issues, where the hatch hinges and power liftgate strut are not operating correctly. The door is unable to close without manual assistance. Ghettel Toyota of Bradenton's service center has inspected and confirmed the malfunction. There were no warning messages or other symptoms of the problem prior to the failure; it first appeared in December 2024, and this car is a 2019 model with 37,000 miles on it. A second opinion was provided by a local body shop, prompting me to report this issue, as they informed me that this has been happening to multiple RAV4 vehicles.

The contact owns a 2019 Toyota Rav4. The contact stated that the liftgate hinge had fractured into two pieces, causing the liftgate to fail to operate as designed. The vehicle was not taken to the dealer to be diagnosed or repaired. The manufacturer was made aware of the failure and confirmed that the repair was not covered under recall or warranty. The failure mileage was approximately 60,000.

Engine coolant bypass valve not working vehicle has 53000 miles was charged 783.00 dollars to replace at the dealership I understand there is pending lawsuit against toyota for not doing a recall in regards to this problem with all 2019 to 2023 rav4

The rear hatch hinges cracked almost all the way through and had to be replaced. We were afraid to drive the vehicle because we didn’t want the hatch back to fall off while driving and create an accident.

The Engine Maintenance Required message is constantly on. The Engine Coolant Bypass Valve needs to be replaced.

The contact owns a 2019 Toyota Rav4 Hybrid. The contact stated while driving 35-40 MPH, the message "Hybrid System Malfunction" was displayed. The contact pulled over to the side of the road and contacted the dealer, and was informed that the vehicle was safe to drive. The vehicle was taken to the dealer, where it was diagnosed with excessive corrosion to the high voltage wiring harness between the high voltage traction motor and the high voltage battery. The dealer informed the contact that the failure could lead to a vehicle occupant being electrocuted. The dealer determined that the wiring harness needed to be replaced. The vehicle was not repaired. The contact related to the failure of the Toyota Campaign Number: 22TE09. The manufacturer was notified of the failure and informed the contact that the vehicle could not be covered because the mileage had been exceeded. The failure mileage was approximately 115,000.

The contact owns a 2019 Toyota Rav4. The contact stated while driving at approximately 35 MPH, the vehicle stalled. The contact pulled over and was able to restart the vehicle. The contact stated that the failure was a recurring failure. The contact stated there was no warning light illuminated. The contact had taken the vehicle to a local dealer. The vehicle was not yet diagnosed and was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 118,000.

After driving for 5-10 minutes, the center console screen stated: “A malfunction in the SRS Airbag System has been detected. Contact your dealer in order to have your vehicle inspected immediately” This continues to happen on subsequent trips. It only happens when somebody is actually sitting in the front passenger seat. There were no warning signs or symptoms prior to this message appearing. It makes me very concerned about passenger and driver safety and that the airbags may not deploy when needed.

Vehicle is displaying Engine Maintenance Required. Dealership stated that it’s a Coolant Bypass Malfunction.