2020 TOYOTA RAV4 Complaints

On or about 8/21/23, we were driving from Vermont back to our home in New Jersey when the sound system started malfunctioning. First, we lost all sound (safety warnings, as well as radio). The sound returned and then cut out again repeatedly. Then, the speakers emitted loud (full volume) static and popping sounds despite the audio system being "off." At the time, we were driving at approximately 65 mph on a highway with our two young children. The noise was so loud that it was difficult to focus on driving. The static and popping sounds continued until we pulled over and shut the car off. These failures have continued and increased in frequency since that time. Our safety was put at risk in two ways: 1) all of the safety warnings were and are muted and ineffective and 2) a full-volume static/popping sound while driving at highway speeds could have caused an accident. Subsequently, we did the following: -Googled the issue and found a relevant Technical Service Bulletin published by Toyota in September 2020 that applies to our make/model and VIN. It is labeled T-SB-0086-20 and can be found here: [XXX] . This suggests the issue applies to multiple Toyotas. The Bulletin indicates the VIN number where the issued stopped -- suggesting Toyota took steps to fix it. There has been no recall related to this issue and we were never notified of this issue. The issue is apparently related to a defective amplifier. -Brought our vehicle to our local Toyota service center (Paul Miller Toyota of West Caldwell NJ). An employee there was able to reproduce and confirm the issue and recommended replacing the amplifier. -Called Toyota to report the problem and register a complaint given the safety issues, failure to notify us of the problem even though it was known to Toyota, and the cost of repair ($2640). There were no warnings, messages, or other symptoms of the problem prior to the failure on or about 8/21/23. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Toyota engine coolant bypass trouble code. Seems to be wide spread reports amongst customers with newer generation 5 Toyota vehicles. Dealer quotes the 20 minute repair will cost $700-900 USD & the part itself is on back order due to the increasing failure rate of the part. The faulty part seems to affect the cooling system of the car but due to the increasing amount of reports & failures of the same part, the dealer should be recalling & replacing the part for free rather than billing customers $700+ dollars. For reference, my vehicle is a model year 2020 & has 19,000 miles & the part has already failed.

Power steering light is on and possibly due to water penetration from recent heavy rainfall.

High Voltage Warning and Low Power to Steering reading on the dashboard. Service engine warning!

Coolant Bypass Valve on my 2020 RAV4. There needs to be a recall; even Toyota dealerships in the Dallas/Fort Worth metroplex say that there needs to be a recall. Service advisors say this is a big problem they see daily and with all cars and at all mileage. The cost to replace the Coolant Bypass Valve in my car = $855- RIDICULOUS!! In addition, due to the constant “Engine Maintenance Required” message on the screen triggered by the Coolant Bypass Valve needing to be replaced, that can’t be removed, all other car related information and/or service issues, is unable to be seen…which is dangerous!! Toyota used to be one of the best car manufacturers for quality and reliability, but now, their quality has tanked…

Coolant value had to be replaced apparently this happens more than we realize and if it’s a repetitive issue for many I believe it should be looked into. Thanks

Engine stalled on highway, was fortunate other drivers allowed us to get to the inside lane and on the shoulder. It bucked a couple times a few minutes earlier. A host of warning lights came on the dash. car did restart after ignition cycled off and on. Had over 1/2 tank fuel. Dash warnings that remained on CEL yellow. parking assist Radar and lane assist. Power steering seemed weak. No cruise control. Over the next 550 miles with engine shut offs during fuel stops dash warnings went out and car returned to normal. No longer trust this car with 70,000 miles.

Fuel tank fill up only 9-10gal wherein published rating to 14gal tank. There should be a recall on changing fuel pump but my VIN does not show any recall

There is a recall for the roof rails leaking water which can damage the air bags and electrical components. They will not fix the roof with new gaskets unless you actually see the water coming in. My concern is that it is leaking and I'm just not seeing it because the 110 degree weather. I do not want to be in an accident with my wife and kids in the car and have the air bags not work. They should fix the gaskets before it leaks and leads to further potential damage or even life threatening results(air bags being wet and not deploying). They will not fix my roof until it actually starts leaking even tho there is a recall in place. This is ridiculous.

My car is leaking coolant and needs a new coolant bypass valve. It seems like it is happening to every rav4 and camry. They put in faulty parts.