2019 TOYOTA RAV4 Complaints

There is a known TSB out for 2019 toyota rav4 and some select other years. The issue is a slow speed transmission issue. It is due to a programming issue. At slow speeds, if you try to go from the brake pedal to the gas pedal too quickly, there is a serious lag before power is delivered to the wheels. Which is very dangerous when making specific turns. An example is what happened to my wife and myself the other day. We were in a median turning lane, cars were coming, as we were coming to almost a stop, my wife went to apply the gas. There was a serious lag before power was delivered and it almost resulted in a T bone collision. My wife went to apply gas, there was no power for several seconds, which caused her to panic and hit the brakes again. In that process, the power was finally delivered to the wheels and caused the car to pull about halfway into the oncoming traffic before it stopped from her applying the brakes. She then hard to quickly reverse to avoid the collision. The TSB calls for a flash of the TCM and a relearn procedure to be done. Which I am having done today due to the severity of the incident we had. This could have 100% caused a serious or fatal accident. The two dealerships I spoke with severely down played it as an issue. This deserves a investigation and a recall to be sent out. I was never advised of the TSB or anything.

I stopped for gas; my car would not start. The power steering fluid light came on. I went inside to purchase some but when I returned to the car, there was no place to pour it. After a few minutes the car started. About a month later, my husband stopped for gas and the car killed right after he left the gas station, about 10 minutes later, it started. Took it to a mechanic, they couldn't find anything wrong with it because the check engine light wasn't on and the car wasn't giving any problem codes. About two weeks ago, I stopped for gas, the car wouldn't start. Finally got it started, and the check engine light came on. However, it's still not reading any codes.

My check engine light is on due to O2 sensor being dirty. While this light is on some features in the car are disabled like cruise control. It might also be that the ABS braking system is turned off! I am not sure but once when the car in front of me abruptly stopped I was surprised my emergency braking did not kick in.

The car transmission hesitates to accelerate at slow speeds and jerks or lurches forwards in a uncontrollable way. Dangerous at stop signs or on slow or hilly roads. Dealership does not directly acknowledge this issue, despite mechanic mentioning very clearly it is related to T-SB-0107-19 which Toyota dealerships charge to repair. No warning messages. Issue has existed as long as I have owned the vehicle 1.5 years from 61,000 miles to 71,000 miles.

The contact owns a 2019 Toyota Rav4. The contact stated that while driving at 40 MPH, the steering wheel seized, and the contact had to use force to maneuver the steering wheel. A yellow light was illuminated, followed by a red light. The message "Power Steering Malfunction" was displayed. The vehicle was taken to the dealer, where it was diagnosed, and determined that the power steering unit sensor had failed. The vehicle was not repaired due to the cost. The contact retrieved DTCs: C05D604 (Electronic Power Steering (EPS) System Internal Failure); C151287 (Malfunction in the Electric Power Steering (EPS) System Torque Sensor); and C15D11C (Electric Parking Brake Failure). The vehicle was not repaired due to the cost. The contact stated that the failure persisted. The contact related the failure to NHTSA Campaign Number: 20V373000 (STEERING); however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was approximately 45,500.

The contact owns a 2019 Toyota Rav4. The contact stated that while attempting to open the fuel door, the latch failed to unlock as needed. There was no warning light illuminated. The vehicle was taken to a local independent mechanic to be diagnosed, and the contact was informed that the spring in the latch was faulty and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The approximate failure mileage was 54,900.

I was driving to Kansas on a road trip and we stopped for gas when we noticed the rear drivers side tire tilting inwards (top of tire angled towards the car). We then drove it to a mechanic in Kansas to see if it is safe to drive further. She noticed the bolt for the rear suspension loose and almost out entirely. She then told us we could not drive the car any further because a few more bumps and the bolt would fall out and create major safely concerns. She also noted that she could see where the bolt was rubbing on the rear suspension sub-plate and could see the old rusted damage along with the new damage from recent driving. She also noted the uneven wear on the tire with the tread worn significantly more on the inner side of the tire. We towed it to Denver to have it looked at and the said the bolt and nut need to be replaced along with a tire alignment. There were no warning signs other than my car felt more bouncy than normal. The car bolt has been replaced but you can inspect the surrounding damage if needed. Both the safety of the people in my vehicle and those around me would have been at risk if we didn't notice the tilt and continued the road trip.

Vehicle states engine maintenance required. Is a consistent reoccurring problem according to dealer. System failure due to manufacturer always puts the user at risk.

Engine stopped power steering low, notification. When in Reverse. Car shuts off and I coast backwards. Have to put it in park and then restart the car.

Cooling System over Temperature. Message kept displaying and check engine lit up again since the first service was done by Tech at the dealership on July 15, 2025.