2019 TOYOTA RAV4 Complaints

MY 2019 TOYOTA RAV4 HYBRID XLE (PURCHASED IN CA) WILL NOT ALLOW A FULL FUEL TANK FILLUP. ONCE THE 'EMPTY' WARNING COMES ON, THE 14.5 GALLON TANK WILL ONLY ACCEPT ABOUT 9 TO 10 GALLONS BEFORE SHUTTING OFF. EVEN IF YOU SLOWLY 'TRICKLE' THE GAS IN, IT SHUTS OFF BEFORE 11 GALLONS ARE IN. CAR IS NOT PROVIDING ANYWHERE NEAR THE AVERAGE ESTIMATED DRIVING RANGE OF APPROXIMATELY 560 MILES, AS ADVERTISED BY TOYOTA. THIS REDUCES CREDIBILITY OF THE TOYOTA FUEL STATUS WARNING, MAKING IT MORE LIKELY DRIVERS MAY RUN OUT OF FUEL ON BUSY FREEWAY OR REMOTE HIGHWAY. I HAVE REPORTED IT TO THE DEALERSHIP, AND TO TOYOTA NATIONAL CUSTOMER SERVICE AND RECEIVED A CASE #.

PURCHASED 2019 TOYOTA RAV4 THIS NOVEMBER AND I HAVE AN ISSUE WITH THE GAS TANK. IT ONLY FILL 80% OF THE TANK NOT COMPLETELY FULL. WHEN TRYING TO FILL MANUALLY TO THE FULL GAUGE THE GAS OVERFLOWS AND SPILLS WHICH CREATES GAS SPILL ON THE SIDE OF THE CAR AND FLOOR. THIS IS AN ISSUE THAT TOYOTA NEEDS TO ADDRESS ASAP.

QWNER OF A 2019 RAV 4 HYBRID, XSE. I'VE OWNED THE VEHICLE SINCE EARLY AUGUST 2019. AND HAVE FELT EXTREMELY FRUSTRATED WITH BEING UNABLE TO 'FILL' THE GAS TANK TO IT'S CAPACITY. IT'S EXASPERATING THAT WITH A 14 GALLON TANK, AT FILL UP IT WILL ACCEPT ONLY 9-9.5 GALLONS OF FUEL AT MOST BEFORE THE FUEL FILL SENSOR WILL NOT ACCEPT FURTHER REFUELING. WHEN I PURCHASED THE CAR IN AUGUST, DRIVING THE CAR OFF THE LOT, THE ESTIMATED MILEAGE ON A FULL TANK WAS 513 MILES. I HAVE NOT BEEN ABLE TO FILL THE TANK TO GET THAT ESTIMATION OF MILEAGE SINCE. THE BEST I'VE BEEN ABLE TO GET IS 443, THE TANK WILL NOT ACCEPT THE FUEL. ADDITIONALLY, WHILE I EXPECTED TO AVG. 40-42 MILES/GAL, I GET APPROXIMATELY 34-35 MPG. THIS TOO IS ALSO RIDICULOUS. I DRIVE THE CAR IN ECONO MODE TO FURTHER ENHANCE BETTER MILEAGE. I WILL REPORT TO TOYOTA...I USE THE CAR MAINLY FOR HIGHWAY DRIVING AND NOT BEING ABLE TO PASS A FEW GAS STATIONS, IS NOT WHY I BOUGHT THIS CAR! I FEEL THAT THE ESTIMATED HEIGHT MPG WAS GROSSLY OVERSTATED BY TOYOTA.

FUEL TANK CAPACITY NOT AS ADVERTISED (14.5 GALLONS). MAXIMUM INPUT IS 9-10 GALLONS AFTER FUEL LIGHT COMES ON. VEHICLE IS AT 16,000 MILES. CAPACITY PROBLEM HAS BEEN CONSISTENT FOR LIFE OF THE VEHICLE.

WHEN THE TANK REGISTERS EMPTY, IT ONLY FILLS ABOUT 9/10 GALLONS BEFORE THE PUMP SHUTS OFF AND I DON'T GET THE FULL MILEAGE RANGE. I HAVE TAKEN IT INTO TOYOTA DEALER AND HAVE BEEN IN CONTACT WITH TOYOTA CUSTOMER SERVICE. I PURCHASED MY VEHICLE NEW '19. WHEN I PICKED UP MY VEHICLE UP THE GAS DISPLAY NEEDLE REGISTER PAST 'F' (A NORMAL SIGNAL ON MOST CARS) AND THE CAR'S RANGE REGISTERED 548 MILES TO EMPTY. THAT WAS THE LAST TIME I EVER SAY THESE HIGH DISPLAYS NUMBERS. AT MY FIRST FILL UP, THE TANK DISPLAYED 3/4 FULL AT SHUTOFF AND RANGER AT 430ISH. THE SUBSEQUENT FUEL FILLS CONTINUED NEAR THESE LOW NUMBER. I CONTACTED THE DEALER ABOUT MY OBSERVATION AND I WAS TOLD THAT THIS IS JUST HOW HYBRIDS WORK. I THEN CONTACTED TOYOTA'S CUSTOMER SERVICE AND BEGAN A CASE FILE. AFTER SEVEN MONTHS OF WORKING WITH THE TOYOTA DEALERSHIP IN SALEM OREGON AND TOYOTA'S CUSTOMER SERVICE DEPARTMENT, THEY FINALLY AGREED TO TESTED MY VEHICLE FOR THE FUELING PROBLEM. AT THAT POINT, THE DEALERSHIP FINALLY ACKNOWLEDGED THAT THERE WAS A PROBLEM. AT THAT POINT, I BEGAN THE PROCESS OF A BUYBACK FOR MY CAR WITH TOYOTA. WITHIN TWO DAYS, I WAS INFORMED THAT THEY WERE GOING TO SWITCH OUT MY GAS TANK FOR A NEW GAS TANK THAT WAS MADE OVERSEAS. I WAS TOLD THAT WOULD SOLVE THE PROBLEM. AFTER RECEIVING MY NEW GAS TANK, THE NEW TANK STARTED TO EXHIBIT THE SAME DIFFICULTIES AS THE LAST TANK. I'M NOW BACK AT SQUARE ONE. I BEGAN COLLECTING DATA AGAIN ABOUT THE FUELING PROBLEM. THIS TIME, THE TANK WAS FEELING A BIT HIGHER THAN 3/4 AND SOMETIMES EVEN NEARING THE'F' LEVEL, BUT THE RANGE NEVER MOVED PAST 460 (TOYOTA ADVERTISED THAT MY CAR WOULD RECEIVE 550+ RANGE MILES ON A FULL TANK). AS I TRACKED MY FUELING PROBLEM, I NOTICE THAT WHEN MY VEHICLE WAS ONLY TAKING IN 9 TO 10 1/2 GALLONS FROM 'EMPTY' TO 'F'. I'M CONCERNED FOR MY SAFETY BY NOT KNOWING HOW MUCH FUEL IN HAVE IN MY VEHICLE.

OUR RAV4 HYBRID WILL RARELY FILL MORE THAN 9-10 GALLONS IN THE TANK. WHEN THE VEHICLE STARTS AFTER A NEW TANK HAS BEEN FILLED THE NEEDLE WILL NOT BE ALL THE WAY AT FULL. ONE OF THE REASONS I WAS SOLD ON THE VEHICLE WAS IT'S RANGE, BUT THIS TANK ISSUE MAKES IT IMPOSSIBLE.

GAS TANK IS SUPPOSEDLY 14 GALLONS BUT VEHICLE WILL NOT TAKE MORE THAN 9 GALLONS.

BOUGHT NEW FROM DEALER IN 10/19. 14.5 GAL FUEL TANK WILL NOT ACCEPT MORE THAN 9.8 GALLONS EVEN AFTER ~20 MILES AFTER IT SHOWS 0 MILES OF RANGE. THIS LEAVES 3-4 GALLONS (>120 MILES OF RANGE) UNAVAILABLE!! NOT AS ADVERTISED. TOYOTA IS AWARE, BUT DOING NOTHING!!!

I HAVE BEEN UNABLE TO FILL THE GAS TANK FULL FOR THE ENTIRE DURATION OF OWNERSHIP. THE PUMP CUTS OFF ABOUT 3 GALLONS SHORT. THE PROBLEM IS GETTING PROGRESSIVELY WORSE AND TOPPING UP DOESN'T HELP EITHER. THE DEALERSHIP WAS UNABLE TO HELP SAYING TOYOTA IS AWARE OF THE PROBLEM BUT THEY DO NOT HAVE ANY SOLUTION FOR IT.

COULD NOT FILL THE GAS TANK FULLY. IT TAKES ONLY 9.834 GAL OF FUEL INSTEAD OF 14.5 GAL. THIS IS WIDELY REPORTED PROBLEM, BUT TOYOTA SEEMS NOT TO ISSUE ANY RECALL.