2019 TOYOTA RAV4 Complaints

The roof of my SUV is leaking and it’s leaking into my two airbags. There’s a sunroof and the roof rack

Was putting the cover back on after washing, putting the lower sitting piece on and the foam headrest just came right off

The water pump failed at 49000 miles left me with a repair of $1500 at Kendall Toyota dealership

I am submitting this complaint regarding a recurring issue in the coolant bypass valve of my 2019 Toyota RAV4 XLE Premium. Although there was no check engine light, the vehicle displayed a persistent warning: “Engine Maintenance Required – Visit Dealership.” This message repeatedly appears on the instrument cluster and blocks critical driving information, including the speedometer, fuel economy, and other key displays. Even when the driver manually cancels the message, it returns within minutes. This creates a constant distraction and obstructs visibility, which poses a safety risk during driving. I took the vehicle to the dealership, where they diagnosed the issue as an internal short circuit in the coolant bypass valve and retrieved diagnostic trouble code P268115. This code relates to a malfunction in the valve’s electrical control system, which affects the engine’s ability to regulate temperature effectively. Toyota currently offers a Customer Support Program (CSP) for the coolant bypass valve, but only if the valve is leaking coolant. However, my vehicle's failure was due to an electrical defect, and Toyota does not cover this under the same program. This creates an unfair burden on owners and fails to address the full scope of the issue, even though the results—loss of proper cooling function—are the same. Many RAV4 owners have reported similar problems online, but no recall or technical service bulletin has been issued for this kind of failure. I believe this defect raises genuine safety concerns, including: Driver distraction due to persistent warning messages Obstruction of critical dashboard information Potential for engine overheating or reduced performance I respectfully request that NHTSA investigate this issue as a potential safety-related defect and determine whether Toyota should be required to expand support or issue a recall for this component, regardless of whether the failure is due to coolant leakage or internal electrical malfunction.

7/16/2025 Engine Maintenance Required Visit Dealer" message on a 2019 Toyota RAV4 LE came on and will not go off. Upon further research and inspection coolant bypass valve is faulty.

My car steering wheel is not responding correctly when I drive". Last week a warning light of faulty steering angle sensor keeps showing on and off. I am afraid that I may crash. I called Toyota to let them know and after verifying my VIN # they want to charge me $185.00 because according to them my car is not on their recall all the information can also be found on the website.

Scan Report done ! odometer 25266.Engine coolant bypass valve "A" control circuit failed test. Engine Control Module Code P2681-15. Message: factory service require !

The vehicle began displaying intermittent warning messages and slipping into "Mud & Sand" mode without cause. Later, multiple dash lights illuminated, including 4WD malfunction, check engine, and coolant system warnings. The vehicle became undrivable due to overheating. Dealership diagnostics indicated a failure in the coolant bypass valve actuator the electronic water pump was receiving a signal but not responding, resulting in loss of coolant circulation and overheating. There may also be a shorted control panel causing related system failures. This problem has been confirmed by a Toyota dealer, and the vehicle remains at the service center pending resolution. The issue appears related to a known Customer Support Program (CSP 24TE04), which covers the coolant bypass valve actuator. There was no prior accident or abuse of the vehicle, and the vehicle only has 52,000 miles. Safety was compromised due to unexpected power loss and overheating while in motion. The issue has not yet been resolved. The vehicle has also experienced prior water intrusion through the roof rails, which may have contributed to electrical damage.

Started normally, but had a message on the screen saying “Check Fuel Cap.” I needed gas anyways, drove about 3 minutes to the gas station, turned engine off, put gas. Turned engine back on and within 3 seconds it shut off. The screen displayed “engine stopped- Power steering low.” I tried a handful of times to start, it did not. After 20 minutes and some rest, it started. With no more messages. Battery and alternator were tested, both were good.

The contact owns a 2019 Toyota Rav4. The contact stated that while stopping the vehicle, the contact heard an abnormal slushing sound coming from the front passenger's side door. The vehicle was taken to the dealer, and it was determined that the door seals had failed and needed to be replaced. The vehicle was not yet repaired and remained with the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 64,000. The VIN was unavailable.