2020 TOYOTA RAV4 Complaints

Recall has been available with no fix since 2023 They are not providing a repair time I feel unsafe driving the car

The contact owns a 2020 Toyota Rav4 Hybrid. The contact received notification of NHTSA Campaign Number 23V86500 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer and Northridge Toyota (9550 Nordhoff St., Northridge, CA 91324) were contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Continuous Warning light display : Engine Maintenance Required Visit Your Dealer. The OBD diagnostic scanner lists the faulty system as follows: Code P268115. Engine coolant bypass valve circuit short to battery or open circuit. This appears to be a common fault on certain Toyota RAV4 years.

The contact owns a 2020 Toyota Rav4. The contact stated that upon starting the vehicle, there was an abnormal amount of white smoke and an abnormal odor coming from the vehicle. There was no warning light illuminated. The vehicle was towed to a local dealer where the vehicle was diagnosed, and the contact was informed that the engine needed to be replaced due to coolant intrusion. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 20V064000 (ENGINE AND ENGINE COOLING) as a possible cause for the failure. The manufacturer was notified of the failure. The approximate failure mileage was 100,000.

Liftgate hinges on my 2020 RAV4 hybrid XSE failed, causing misalignment so the liftgate/tailgate does not close properly or completely. Liftgate hinges are made of materials that are not strong enough for consistent and safe operation. Toyota has not issued a recall or provided safety warnings or notifications, nor is the company providing replacement hinges. RAV4 owners are left to pay for the replacement of these hinges when it’s a quality issue that can impact the safe operation of 2020 Toyota RAV4s. Toyota recently settled a lawsuit brought by an individual because of this issue.

at only 55k miles my 2020 toyota rav4 has shown an “engine maintenance required” sign. not to be mistaken with general maintenance. apparently this is a widely common issue where brand new toyotas are having cooling bypass valve issue. however concerningly so, because there are no recalls for this problem yet seemingly every rav4 has this problem? how is there no recall, everyone is paying out of pocket for essentially poor manufacturing, its outrageous, also considering the part itself is under $100 but some dealers are charging anywhere to $600-$1300. it’s predatory and outright wrong.

The coolant bypass valve has been failed prematurely therefor engine heat up and there is a warning on my dashboard that say "engine maintenance required"

Hybrid System Malfunction. The warning lights came on notifying of an issue with the hybrid system. A certified Toyota service center inspected the vehicle and found the hybrid floor wire traction cable/wiring harness corroded. Issue started 3/1/25, car was inspected on 3/3/25. This is a known issue with Toyota. Vehicle will no longer start and could have shut off while driving without warning.

I filed a complaint with Toyota to replace my vehicle and they said they denied my claim. They promised a fix by 2024 and it is already 2025

Power lift gate not opening and shutting then noted that the mount on the passenger side is partially sheared off the car bracket and starting to separate on the drivers side. Was unable to close the hitch all the way, and beeping continuously while driving so brought to a toyota dealer service who ordered replacement pistons, in the mean time battery died due to being unable to close back. Once piston parts were obtained by toyota service center, had to have the car towed due to battery not able to be charged, then they noticed the bolts starting to shear off. Stated they have never seen anything like this but when looked online, found this has been a common problem and a class action suit has been filed for this exact reason