2012 TOYOTA SIENNA Complaints

The contact owns a 2012 Toyota Sienna. The contact stated that the rear differential was making an abnormal whirling and grinding sound. There were no warning lights illuminated. The contact called the local dealer but the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to NHTSA. The approximate failure mileage was 79,000.

Vehicle began 'whirring' metal noise from underneath. Local mechanic said it was coming from rear differential. I took it to a Toyota dealer, they said rear differential coupler needs replacing ($2159) and drive shaft ($992). It seems the bearing ring inside this sealed unit has failed. Noise is continuous while driving, concern of part failure - we are taking vehicle on family vacation. Researching on - line it appears to be common problem with the Sienna's. Toyota had same issue with RAV 4's and issued recall but have not for the Sienna's. I called Toyota corporate in TX (got up 3 levels) to no avail, and it curt tone, they said they cannot help. Based on other similar stories on line from other Sienna owners, this seems to be a common very expensive design flaw problem with this vehicle.

WE REALIZED THAT OUR VEHICLE HAD A FLAT TIRE. WHEN WE WENT TO ATTEMPT TO PUT ON THE SPARE, WE NOTICED THAT ALL OF THE LUG NUTS HAD "SWOLLEN" AND NONE OF THE LUG NUTS WOULD FIT IN THE CORRESPONDING SOCKET. ULTIMATELY, THE LUG NUT CAPS DELAMINATED, AND IT TOOK OVER AN HOUR TO TEAR THE CAPS FROM THE NUTS. IF THIS HAD HAPPENED ON THE SIDE OF THE HIGHWAY, ADDRESSING THIS ISSUE WOULD HAVE BEEN INCREDIBLY DANGEROUS. IT DOES NOT SEEM TO MAKE SENSE TO CONTINUE USING LUG NUTS WITH DECORATIVE CAPS FOR AESTHETIC REASONS WHILE IMPACTING THE SAFETY OF DRIVERS WITH FLAT TIRES.

FRONT TIRES WEAR OUT TOO FAST ON THIS VEHICLE. I PURCHASED VEHICLE AROUND 60K MILES. NOW AT 130K AND ON 4TH SET OF TIRES. ALL MICHELIN/TOP QUALITY FROM COSTCO. ROTATIONS AT 5-7K RELIGIOUSLY. FRONT END SUSPENSION/STEERING IN GOOD SHAPE/PARTS REPLACED WHEN WEAR IS SEEN. ALIGNMENT GOOD. HORRIBLE. WEAR IS ON OUTER EDGES OF BOTH FRONT TIRES.

SUNROOF SHATTERED WITHOUT WARNING OR KNOWN CAUSE WHILE DRIVING DOWN THE ROAD. IT WAS PRECEEDED BY A LOUD 'BANG' SOUND.

MY 2012 TOYOTA SIENNA RECENTLY BEGAN MAKING A LOUD WHINING NOISE FROM THE REAR AXLE AREA. UPON INSPECTION, WE WERE INFORMED THAT THE DIFFERENTIAL UNIT WAS FAILING AND NEEDED TO BE REPLACED. THIS WOULD COST US BETWEEN $2,500-$3,000. AFTER SOME RESEARCH, I DISCOVERED THAT THIS IS A COMMON PROBLEM WITH THE SIENNA, LIKELY CAUSED BY A DESIGN FLAW. THE SAME UNIT WAS USED ON THE RAV-4, AND AFTER SIMILAR PROBLEMS SURFACED IT WAS RECALLED AND FIXED BY TOYOTA. GIVEN THE DANGER POSED BY FAILURE OF THIS PART TO A FAMILY VEHICLE, AND THE KNOWN EXISTENCE OF THE PROBLEM BY TOYOTA, IT SEEMS OBVIOUS THAT IT SHOULD BE IMMEDIATELY RECALLED AND FIXED BY THE MANUFACTURER.

SERVICE TECH AT THE TOYOTA DEALER SAID MY ELECTROMAGNETIC COUPLER / VISCOUS COUPLER AND DRIVESHAFT UJOINT SEIZED. AFTER FURTHER RESEARCH ONLINE IT SEEMS ITS COMMON. WONDERING IF TOYOTA WOULD PUT OUT A RECALL?

BROUGHT CAR IN FOR AIRBAG SAFETY RECALL. WAS TOLD IT WAS COMPLETED. AFTER THIS RECEIVED ANOTHER RECALL MAILING FOR THE SAME PROBLEM. CALLED THE TOYOTA RECALL RESOLUTION TEAM NUMBER TO VERIFY. WAS TOLD THAT A TEMPORARY AIRBAG WAS INSTALLED AND THAT I NEEDED TO HAVE THE GOOD ONE REINSTALLED WHEN THEY GOT THEM IN. SHE CALLED THE DEALER TO SET UP AN APPOINTMENT THEN TOLD ME THAT IT WAS TAKEN CARE OF AND A NEW AIRBAG WAS NOT NEEDED. AND STATED THAT SHE WAS CONFUSED. AND THAT I NEEDED TO GO BACK TO THE DEALER TO GET A WRITTEN STATEMENT THAT THE WORK WAS DONE. I NOTICED AND EXPLAINED THAT IT LOOKS LIKE A SUBSTITUTE WAS MADE AND THE RECEIPT SAYS : 'BAG 0.8. 2007-2009 YARIS HATCHBACK 2007-2009 YARIS SEDAN'. SO IT LOOKS LIKE A TEMPORARY SUBSTITUTE WAS MADE AND THAT I WAS NOT INFORMED. I SAID THAT IF THEY GIVE WRITTEN DOCUMENTATION THAT THE REPAIR WAS MADE IT MAKES IT LEGALLY THEIR RESPONSIBILITY BUT THIS WOULD BE AFTER THE FACT IF A PROBLEM OR FATALITY WOULD OCCUR AND NOT SOLVE THE ISSUE OF ASSURING THAT A PROPER AIRBAG HAD BEEN INSTALLED. CAN YOU GIVE CLARIFICATION AND SUGGESTED FOLLOW UP (POSSIBLY THIRD PARTY) TO GUARANTEE SAFETY?

WHEN PRESSING THE BRAKE THE ENGINE REVS SUDDENLY AND TO VERY HIGH RPMS AND YOU HAVE TO PRESS DOWN ON THE BRAKE AND/OR THROW CAR INTO NEUTRAL/DRIVE AND THEN EVENTUALLY THE ISSUE RESOLVES. HAPPENED YESTERDAY WHEN REVERSING VERY SLOWLY OUT OF DRIVEWAY--WAS PRESSING BRAKE (NOT ACCELERATOR) AND SUDDENLY THE ENGINE GOT VERY LOUD AND WAS REVVING UP. PRESSED BRAKE HARD AND THRU THE CAR INTO PARK AND PRESSED THE ACCELERATOR AND THE ENGINE WENT BACK TO NORMAL. VERY SCARY. HAS HAPPENED SEVERAL TIMES BEFORE AND FORTUNATELY WE HAVE NOT RUN INTO ANYTHING AND THE CAR HAS NOT TAKEN OFF AT HIGH SPEED.

UNIT IS PRODUCING A SPEED DEPENDENT WHINE FROM THE REAR DIFFERENTIAL CONSISTENT WITH A BEARING FAILURE IN THE VISCOUS COUPLER. ISSUE FIRST OBSERVED WITH APPROXIMATELY 98,000 MILES ON ODOMETER. THIS APPEARS TO BE A COMMON COMPONENT FAILURE ON MANY TOYOTA AWD VEHICLES MANUFACTURED IN THE LAST 15-20 YEARS, AND THE COMPONENT IN QUESTION MAY BE UNDER-ENGINEERED TO PERFORM AS EXPECTED IN NORMAL DRIVING CONDITIONS. REPLACEMENT PART COSTS $1300+ FROM TOYOTA, NOT INCLUDING INSTALLATION. *TR