2020 TOYOTA SIENNA Complaints

My car was not shifting gears, and it would go into brief periods of erratic acceleration. I took it to the dealer service dept. The transmission went bad. It had metal pieces broken off inside it. The car is 3 years old and only has approximately 70,900 miles on it. It was dangerous to drive. It put me, my kids, and other drivers at risk due to the erratic shifting it would do while driving. The issues started slowly on 6/23/23. The check engine light was on by 6/24/23.

For a month prior, there were intermittent incidents of the van shuddering and the RPM needle jumping upon ignition. Sometimes the van would have a hard time accelerating before jerking and driving normally. No issues before this started in late July and no indication when/where would occur. •September 15: drove the van all day running errands. It drove normally. Filled up the gas tank (Gulf gas station), then continued errands. About a half hour later, while at a stop sign, a notification appeared that the “Traction Control System has been turned off” and the check engine light came on. Tried to move through the stop sign, but the van would barely go. Applied the gas, but no results. Able to turn onto a side street and had to have it towed to Toyota of Irving. The Service Advisor stated the issue was due due to bad gas and indicated the van needed to be flushed and the fuel injection system cleaned. Paid $725 for these repairs. •September 17: Started van in driveway. Shuddering and RPM needle jumping again. Drove normally. •September 21: Same as above. •September 25: Drove the van all day with no issues. Filled up with Valero Plus gas. As we pulled out of the gas station and sitting at the light, the Traction Control message and check engine light again appeared. The van would barely go to get us through the traffic light and into a nearby parking lot. Once we parked, the screen displayed the following message:"A malfunction in the electronic control of the engine, throttle, or automatic transmission has been detected." Had the vehicle towed to Toyota of Irving. The service advisor called 2 days later to say they cannot detect any issues.

The van has been periodically hesitating, rough idles, and when parked the rpm revs. On 9/13/22, the van was shaking, hesitating, and would not accelerate. It was undrivable and had to be towed. We took it to Toyota of Irving where they charged us $725 to flush the gas and clean the fuel injection system. Despite this, it is still hard idling and hesitating.

The contact owns a 2020 Toyota Sienna. The contact stated while driving approximately 60-65 MPH, the vehicle stalled temporarily. Several unknown warning lights were illuminated. The contact depressed the accelerator pedal and was able to continue driving. The contact later received notification of NHTSA Campaign Number: 20V682000 (Fuel System, Gasoline) and the vehicle was taken to the dealer for the recall repair. The contact stated that the fuel pump was replaced; however, the failure recurred a year later. The vehicle was taken to the dealer however, the mechanic was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 10,000. The consumer stated the pump was replaced but the problem still occurs.

Engine stalled in heavy traffic after full stop at red light. No warning lights. Managed to pull off the road. Still no warning lights. Turned engine off then started normally. Drove to destination normally. After about one hour parked started engine but it stumbled on and off for the next few minutes but did not die. Has not reoccurred. Outside temps were in the 60's. It was first trip of the day. Incident occurred about 4 miles from origin. Symptoms occurred again 6/2/22: Starting from full stop (engine was idling normally), gave it partial throttle whereupon engine stumbled (died very briefly), Master Warning Light lit briefly, all power was lost. Consumer applied additional throttle, engine stumbled then began running normally and warning light extinguished. Remainder of trip was normal. Vehicle was taken to local dealer after first incident but dealer reported no issues were found.

Car has about 16,000 miles. When accelerating slowly from a stop, vehicle hesitates, shakes, and runs rough as it slowly progresses thru first, second, & third gears. After transmission gets in fourth gear, hesitation and roughness goes away. This issue is rapidly getting worse.

ON jUNE 3, 2021 I experienced a drastic loss in power and all warning light illuminated on the dash , was able to get of the highway to a safe area and vehicle ceased to function . This happened after the fuel pump recall was performed at Ed Morse Toyota in Delray Beach around February. It had been functioning perfectly up until this massive failure. When tow truck operator arrived and tried to start, is caught fire and was severely damaged.

TL* THE CONTACT OWNS A 2020 TOYOTA SIENNA. THE CONTACT STATED WHILE DRIVING 55 MPH, THE STEERING WHEEL WAS DIFFICULT TO STEER. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A LOCAL DEALER OR AN INDEPENDENT MECHANIC TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 6,200.

THE FUEL PUMP NEEDS REPLACED AND HAS BEEN RECALLED. THE RECALL CAN CAUSE AN INCREASED RISK OF A CRASH. WE STILL HAVEN'T HAD THIS REPLACED IN A TIMELY MANNER AND IT'S NOT SAFE FOR MY SMALL CHILDREN.

THIS VEHICLE IS OWNED BY EMORY UNIVERSITY. EMORY UNIVERSITY WAS NOTIFIED LAST YEAR (OCTOBER) THAT THE LOW PRESSURE FUEL PUMP MAY STOP OPERATING. TO DATE, THERE HAS BEEN NO REPAIR OFFERED BY TOYOTA. 2020 TOYOTA SIENNA AS SUCH EMORY UNIVERSITY WILL NOT LET US OPERATE IT UNTIL IT HAS BEEN REPAIRED. NEARLY SIX MONTHS LATER, NO REPAIR.