2025 TOYOTA TACOMA Complaints

Both the inside and outside front door handles on the driver side stopped working. This blocks the driver from exiting from the front door. The dealer has ordered a new part, but it is on back order. The dealer has not inspected the vehicle, but they seem aware of this issue. The vehicle has not been inspected by others and there were no indicators that the part was going to fail. The vehicle is available for inspection upon request.

The front passenger door handle does not open the door. Door must be opened from the outside only. Part is on back order

The driver back passenger door stopped opening from the inside. Upon further inspection the mechanism inside the door is broken. The plastic housing snapped. This results in a safety risk in case of an emergency. The door can be opened fine from the outside.

The driver side inner door handle mechanism has broken. The part is on back order with no E.T.A. (from my local Toyota dealership). I can't easily exit my vehicle in an emergency.

The interior door handle on my vehicle broke, and this creates a safety risk because occupants — including passengers, especially children in rear seats who may not know an alternate way out — may be unable to open the door and exit from inside. This is particularly dangerous in an emergency such as a collision, fire, or submersion, or in a situation where a passenger needs to exit quickly for personal safety, such as during an abduction or assault. This defect could also delay first responders during an extraction. The door broke again immediately after picking up the vehicle.

Unable to open my driver's door from the inside. In order to get out of the vehicle, I need to put the driver's window down and open the door using the outside door handle. I took it to the dealership on July 29, 2026 for a warranty repair. I was informed that this is a known issue and there are currently 1,600 door handle mechanisms on a national back order. Unknown when the part will come in. This could be a very serious safety issue if there is an accident and a driver is unable to open the door to get out, especially in the situation in which getting out of the car is a life or death situation, such as a vehicle fire.

At 10,000 miles the interior door handle has stopped working. I’m not able to open the door anymore having Toyota take a look. The handle itself had busted on the inside. They have ordered the parts for replacement with a backorder for 2 to 3 months because they’re having a lot of reports.

We rented a vehicle consisting of the identified Toyota Tacoma with an installed cab-over camper (Travel Lite 550U-XS, VIN: [XXX]). While driving this rental vehicle on a two-lane highway with our family, including two young children (ages [XXX] and [XXX]), a fire ignited in the vehicle's built-in propane/gas stove system. We were not alerted to the fire by any onboard safety equipment, though the camper was equipped with a smoke alarm. We were alerted only by a passing motorist. The vehicle's smoke alarm did not activate until several minutes after the fire had already been extinguished by us using the vehicle's fire extinguisher, and after the smoke inside the camper had already dissipated. The smoke alarm sustained visible smoke damage and its exterior housing was melted, which we believe indicates the alarm was exposed to significant heat/smoke without triggering, or triggered only very late in that exposure. We believe this represents a serious safety equipment failure: a smoke/fire detection system that did not provide any early warning during an active fire, in a small space. This delay in detection could have resulted in serious injury or death. Additionally, we received no safety briefing regarding the hazards of the propane system at the time of vehicle handover. The vehicle overview video provided to us contained no safety information regarding the gas system, and we later discovered it depicted a different vehicle unit than the one we were actually provided, raising questions about whether this vehicle's specific gas/stove configuration and safety equipment had been properly reviewed or tested prior to rental. We made a best guess at cause in speaking with the responder fire department, but we cannot know for sure. To be clear, there was no issue with the Toyota Tacoma itself. We are submitting this complaint to ensure NHTSA is aware of this potential safety defect in the smoke alarm system and/or propane stove. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(

Front passenger interior door handle is a fragile component. Mine failed with little to no force where the cable disconnects from the handle. It has rendered the ability to exit the vehicle via the handle impossible, and Passenger must roll down window and reach for the exterior handle to exit. I’ve had my vehicle at the dealer, and being sent back with vehicle not fixed due to parts being on backorder. No ETA is able to be provided.

The drivers door handle inside the truck has failed leaving me unable to open the drivers door unless I roll the window down and open the door from the outside. I took the truck to a local dealer and they let me know this is a very common problem on the truck and the parts to fix it are on nationwide back order. Was sent home with the vehicle knowing the door is inoperable unless opened from the outside. This poses a serious safety risk in the event of an accident or emergency where one needs to exit the vehicle quickly.