2012 TOYOTA TACOMA Complaints

TACOMA WENT IN "LIMP MODE" ENGINE LIGHT AND TRAC OFF LIGHT ILLUMINATED; CAUSE THE CAR TO BE EXTREMELY UNDER POWER. VEHICLE EXTREMELY UNDER POWER CAUSING TO BE DANGEROUS IN TRAFFIC. CODE P2442 SECONDARY INJECTION SYSTEM FAILURE; COMMON TO OTHER TOYOTA VEHICLES INCLUDING TUNDRA'S. TOYOTA ACTED RESUMABLE WITH TUNDRA'S WITH EXTENDING WARRANTY REPAIRING BUT AT THIS TIME REFUSES TO REPAIR KNOWN FAILURES IN TACOMA'S.

THE AIR INJECTION PUMP WENT OUT AND HAD TO BE REPLACED, AND THERE IS ONLY 18,200 MILES ON THE VEHICLE. THE CHECK ENGINE LIGHT CAME ON WHILE DRIVING, AND I WAS ABLE TO DRIVE THE VEHICLE TO THE DEALERSHIP BEFORE "SAFE MODE" KICKED IN. TOYOTA WAS ABLE TO REPLACE THE DEFECTIVE PART. I UNDERSTAND FROM READING ON THE INTERNET THAT THIS IS TURNING OUT TO BE A COMMON PROBLEM FOR THIS VEHICLE, AND WISH TO ADD MY EXPERIENCE TO THE LIST.

SECONDARY AIR INJECTION FAILURE AT 58K MILES. DEALER QUOTED $2200 TO REPLACE VALVES AND PUMP. SEVERAL FAILURES WITH 2012 REPORTED

THE SECONDARY AIR INJECTION PUMP'S VALVES WENT BAD WITH THE VEHICLE ONLY HAVING 30K MILES. THIS CAUSED THE TRUCK TO GO INTO LIMP MODE AND DID NOT ALLOW FOR ACCELERATION WHILE DRIVING. THIS IS A VERY DANGEROUS ASPECT WHEN DRIVING ON THE FREEWAY. NOTHING HAPPENED TO THE VEHICLE TO CAUSE THIS FAILURE, IT JUST STARTED UP ONE DAY AND WAS BAD.

SECONDARY AIR INJECTION SWITCHING VALVE FAILURE STUCK IN OPEN POSITION CAUSING LIMP MODE IN THE TRUCK. TRUCK IS NOT ABLE TO GET TO SPEED ABOVE 40 MPH. THIS HAPPENED AS I WAS PULLING OUT OF MY NEIGHBORHOOD ONTO A STATE ROUTE WITH SPEED LIMIT OF 55 MPH AND CARS GOING WAY FASTER THAN THAT. THIS COULD POSE A DANGER IF SITUATIONS WHERE SPEED IT REQUIRED TO GET OUT OF THE WAY OF ANOTHER CAR. TRUCK ONLY HAS 57K MILES ON IT. THIS IS A SUPPLEMENTAL EMISSIONS SYSTEM AND SHOULD NOT CAUSE THE TRUCK TO BE USELESS IF FAIL.

57,000 MILES ON TRUCK WENT INTO LIMP MODE, P2440 AND P2442 CODE SHOWED SECONDARY AIR INJECTION VALVE DEALER QUOTED $2000, SAID THEY WOULDN'T COVER ANYTHING

THE SECONDARY AIR INJECTION PUMP FAILED AT 62,000 MILES. FOR SPECIFICS IT SHOWED THE CODES P2440 AND P2442. THIS WAS KNOWN PROBLEM ON THE PREVIOUS MODEL TUNDRAS, THE SERVICE MGR AT RODLAND TOYOTA SAID THEY HAD ALREADY REPLACED THREE PUMPS ON TRUCKS OF THE SAME YEAR THAT WEEK.

TAKATA RECALL I STOPPED THE AT TRAFFIC LIGHT ION CITY STREET WITHOUT RAIN. I JUST STARTED DRIVING, WHEN LIGHT CHANGED TO GREEN, THERE WAS NO STEERING FEELING AT ALL FOR A FEW SECOND. THE CAR WAVED SIDE BY SIDE TWICE WITHOUT MY CONTROLLING. THEN I DROVE SLOWLY AND CAREFULLY, IT'S OK. I BOUGHT CAR TO TOYOTA DEALER THE NEXT DAY, THEY SAID STEERING SYSTEM IS OK, MAY BE BECAUSE OF WET BELT.

THIS IS A PROBLEM WITH THE SECONDARY AIR INJECTION PUMP AND SOLONOID...IT LEFT ME STRANDED ON THE ROADSIDE...24000 MILES ON A TRUCK IS NOT EVEN BROKE IN..RELIABILITY?..I HANDLED IT..ONLY BECAUSE IVE BEEN A MECHANIC FOR 25 YEARS...WHAT IF IT WAS MY WIFE AND KIDS BROKE DOWN IN GETTO TOWN...THIS IS A HUGE PROBLEM FOR MANY AND IS SO COMMON..IVE CLEARED THE CODES SEVERAL TIMES BUT THEY ALWAYS REAPPEAR...THIS IS A DEFINATE RECALL...MAKE IT SO...24000 9N A TRUCK AND I CANT DRIVE IT...MY LOYALTY IS FADING FAST...TRY TO IMAGINE DRIVING YOUR TRUCK DOWN A ST.LOUIS 6 LANE FREEWAY AND YOUR TRUCK SAYS...NOPE YOU STAYING HERE..ON THE SIDE OF THE ROAD...DONT GET OUT...YOULL GET RAN OVER...MAYBE TOYOTA SHOULD HAVE A DISPLAY ON THE INFO CENTER CONCOLE THAT TELLS YOU THAT...AND THEN WISHES YOU GOOD LUCK...

I WAS DRIVING ON A50MPH HIGHWAY AN CHECK ENGINE LIGHT COMES ON AND TRUCK SLOWS TO 40MPH WONT GO ANY FASTER.