2003 TOYOTA TACOMA Complaints

LEAKY WATER PUMP DISCOVERED UPON ROUTINE CHANGE OF TIMING BELT ON 2003 TOYOTA TACOMA 2WD PRERUNNER. DISCOVERED COMPLETE LACK OF GASKET AND WOEFULLY INADEQUATE AMOUNT OF SEALANT APPARENTLY APPLIED AT FACTORY. (NO MORE THAN 1/8" WIDE AFTER COMPRESSION BETWEEN WATER PUMP HOUSING AND ENGINE BLOCK) ENGINE CONTINUALLY USED A SMALL AMOUNT OF COOLANT/ANTIFREEZE AND OVER TIME HAD BUILT UP A SUBSTANTIAL VOLUME OF SLUDGE/CRUSTY COOLANT AROUND WATER PUMP HOUSING AND TIMING BELT (CRANKSHAFT) PULLEY. ALTHOUGH ABSENT IN THIS INSTANCE, THIS BUILD-UP HAS THE POTENTIAL TO BREAK LOOSE AND FALL BETWEEN THE TIMING BELT AND PULLEY AND ULTIMATELY CAUSE TIMING BELT BREAKAGE. REPLACED BELT AND WATER PUMP. RE-MANUFACTURED WATER PUMP IS EQUIPPED WITH A GASKET. *TR

I AM THE OWNER OF A 2003 TOYOTA TACOMA WITH APPROXIMATELY 29,000 MILES, LIVING IN THE NORTHEAST. THE FRAME AND THE UNDERCARRIAGE OF THE VEHICLE HAVE EXTENSIVE RUST FROM FRONT TO REAR. I BELIEVE THE FRAME IS RUSTING FROM THE INSIDE OUT AND WILL CONTINUE TO DO SO. AT THIS POINT, THE TRANSMISSION SHIELD AND THE FUEL TANK SHIELD ARE IN DANGER OF FALLING OFF OF THE VEHICLE. THE LEAF SPRINGS ARE SO CORRODED THAT THEY NO LONGER FUNCTION PROPERLY. THE EXHAUST SYSTEM AND MUFFLER ARE COMPLETELY RUSTED OUT. *TR

SLOW FILL UP AT THE GAS PUMPS. THE TANK TAKES 10-12 MINUTES TO FILL. IT TAKES THE GAS VERY SLOWLY. PUMP WILL KEEP CLICKING OFF. THE PUMP HOSE HAS TO BE KEPT HALF TO THREE-QUARTERS OUT IN ORDER THAT THE GAS FLOW INTO THE TANK. *TR

TL*THE CONTACT OWNS A 2003 TOYOTA TACOMA. WHILE THE CONTACT WAS HAVING HIS VEHICLE SERVICED, HE WAS INFORMED THAT THE FRAME WAS RUSTING. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 53,000.

TL*THE CONTACT OWNS A 2003 TOYOTA TACOMA. THERE WERE 14 MILES ON THE VEHICLE AT THE TIME OF PURCHASE. THE CONTACT STATED THAT THE PAINT WAS CHIPPING ON THE VEHICLE. HE FILED A COMPLAINT WITH THE MANUFACTURER AND THEY DECLINED ANY LIABILITY FOR THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE LESS THAN 36,461. THE VEHICLE ALSO HAD FRAME RUST. UPDATED 09/09/09.*JB

VERY LOOSE STEERING WHEEL. PROBLEM IS THE SLIP SHAFT IN THE STEERING COLUMN. OVER TIME THE LOVER SHAFT WEARS AND THE STEERING BECOMES LOOSE AND SLOPPY. PROBLEM FIRST SHOWS UP AS LOOSENESS IN THE WHEEL AND EVENTUALLY TURNS INTO A CLUNK WHEN DRIVING OVER MINOR ROUGH ROADS. FROM TALKING TO MECHANICS AND OTHER TACOMA OWNERS THIS IS A VERY COMMON PROBLEM THAT TOYOTA WILL NOT ADDRESS. PROBLEMS INCLUDE DIFFICULTY MAINTAINING CONTROL OVER ROUGH PAVEMENT. WANDERING AT ALL SPEEDS. MAJOR DIRECTION CHANGES WHEN BREAKING ON ALL ROADS. SMOOTH OR ROUGH. OVER ALL THE TRUCK IS VERY DIFFICULT TO DRIVE. I'VE HAD THE TRUCK ACTUALLY CHANGE LANES WHEN I HIT AN UNEXPECTED ROUGH PATCH OF ROAD AT APPOX 30 MPH. THERE WAS NOTHING I COULD DUE BECAUSE OF THE SLOP IN THE STEERING WHEEL. PLEASE NOTE THAT THIS TRUCK IS VERY WELL MAINTAINED AND I HAVE GONE THROUGH THE ENTIRE FRONT SUSPENSION AND STEERING TRYING TO FIX THIS PROBLEM WITH NO LUCK. I'M NOW FACED WITH SPENDING EVEN MORE MONEY TO REPLACE A STEERING COLUMN. *TR

TL*THE CONTACT OWNS A 2003 TOYOTA TACOMA. WHEN ENTERING THE VEHICLE, THE CONTACT NOTICED RUST ON THE FRAME. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY PREDICTED THAT THE FRAME WOULD FAIL WITHIN THE YEAR. THE CONTACT RECEIVED A RECALL NOTICE FROM THE MANUFACTURER REGARDING THE FRAME FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY CONDUCTED A TEST BY TAKING A HAMMER AND STRIKING THE RUST SPOTS TO SEE IF THE HAMMER WOULD GO COMPLETELY THROUGH. THE FAILURE COULD NOT BE DUPLICATED, WHICH MEANT THAT THE VEHICLE WAS NOT COMPLETELY FAILING. THE CONTACT WAS INFORMED TO BRING THE VEHICLE BACK FOR INSPECTION BY A REGIONAL INSPECTOR. THE CONTACT FEELS THAT THE ISSUE NEEDS TO BE REMEDIED BEFORE A CRASH OCCURS. HE CALLED THE MANUFACTURER AND WAS INFORMED THAT A REGIONAL INSPECTOR WOULD CALL HIM TO SCHEDULE AN APPOINTMENT FOR FURTHER INSPECTION. THE FAILURE MILEAGE WAS 45,000 AND CURRENT MILEAGE WAS 61,200.

I WAS DRIVING MY 2003 TACOMA WHEN THE BATTERY AND OIL LIGHTS CAME ON AND THE TRUCK BECAME UNDRIVEABLE. WHEN THE LIGHTS WENT OFF I WAS ABLE TO DRIVE AGAIN. I HAD TRUCK TOWED TO MECHANIC AND FOUND OUT THAT CRANKSHAFT BOLT WAS BROKEN/SHEARED OFF. HAD TRUCK TOWED TO DEALERSHIP FOR CONFIRMATION - THEY CONFIRMED. HAD INSURANCE ADJUSTER LOOK AT IT TO DETERMINE IF RELATED TO ANY ACCIDENTS - NO RELATION. CALLED TOYOTA CORP AND THEY SAID THAT BOLT SHOULD NOT BREAK UNLESS UNDER EXTREME TORQUE OF DEFECT. MECHANIC, DEALERSHIP AND INSURANCE ADJUSTER ALL SAID THE SAME. THE BOLT IS MADE OUT OF CASE-HARDENED STEEL. I HAVE NOT HAD ANY MAJOR WORK DONE TO THE TRUCK THAT WOULD INVOLVE THE CRANKSHAFT BOLT!! DEALERSHIP IS QUOTING COST OF APPROX $4000 FOR SHORT BLOCK REPAIR. IF BOLT IS/WAS DEFECTIVE I SHOULD NOT HAVE TO PAY FOR ANY OF THE REPAIRS THAT SHOULD FALL ON TOYOTA WHETHER OR NOT THE TRUCK IS OUT OF WARRANTY. I NEED THIS FIXED! *TR

2003 TOYOTA TACOMA RECALL NOTICE FOR THE FRONT SUSPENSION LOWER BALL JOINT. CONSUMER STATES THAT THE PARTS FAILED TO REMEDY THE PROBLEM. *NJ

INSTRUMENT PANEL LIGHTS SEQUENTIAL FAILURE. THERE ARE TWO LIGHTS FOR THE INSTRUMENT PANEL. ONE FAILED AND THEN 1 MONTH LATER, THE OTHER LIGHT FAILED. *TR