2005 TOYOTA TACOMA Complaints

2005 TACOMA RESIDED IN PA FROM PURCHASE IN 2004 UNTIL JULY 2011 & IS NOW EXHIBITING FRAME PERFORATION IN THE AREA OF BOTH EXHAUST RESONATORS AND SPLITTING IN THE C-CHANNEL RAILS NEAR THE REAR WHEELS. *TR

MY TRUCK FRAME HAS AN INORDINATE AMOUNT OF RUST AND A PERFORATING RUST ON THE DRIVERS SIDE FRONT OF THE FRAME APPROXIMATELY 7X6 INCHES OF FRAME THAT HAS JUST CRACKED AWAY WITH RUST, I AM SURE MY TRUCK WILL NOT PASS STATE INSPECTION THIS YEAR. UNDER TOYOTA'S LIMITED SERVICE CAMPAIGN MY TRUCK SHOULD QUALIFY FOR REPAIRS BUT TOYOTA CORPORATE DOES NOT RECOGNIZE MY TRUCK AS NEEDING REPAIR BASED ON THE VIN NUMBER. *TR

THE TAILGATE OF THE VEHICLE LACKS THE REQUIRED AMOUNT OF STRUCTURAL INTEGRITY TO SERVE ITS INTENDED PURPOSE. SINCE THE TAILGATE IS DESIGNED TO BE OPENED TO A FLAT POSITION FOR LOADING OR UNLOADING ITEM(S) PLACED IN THE BED OF THE TRUCK IT WILL CERTAINLY REQUIRE A CERTAIN AMOUNT OF STRENGTH FOR THIS PURPOSE. I NOTICED THAT MY TAIL GATE WAS NO LONGER STRAIGHT ACROSS WHEN IN THE CLOSE POSITION BUT HAD A CONCAVE APPEARANCE. I WORRIED THAT THE TAIL GATE MAY COME UNLATCHED WHILE IN THE UP POSITION OR WORSE BY COLLAPSING BY FOLDING IN THE MIDDLE IF USING IT TO CARRY A PARTIAL LOAD. I LOAD MY 4-WHEELER IN THE BACK OF THE TRUCK AT TIMES AND DUE TO THE SHORT BED HAVE TO LEAVE THE REAR TIRES RESTING ON THE TAIL GATE. THE WEIGHT, ALTHOUGH NOT EXCESSIVE, SEEMED TO POSSIBLY BE THE CAUSE OF THE DISTRESS ON THE TAILGATE. I REMOVED THE INTERIOR COVER AS WELL AS THE TOP TAILGATE COVER FOR INSPECTION. MY INSPECTION DID REVEAL TWO CREASES IN THE TAILGATE TOP SECTION (WHEN IN THE CLOSE POSITION) ABOUT 18" FROM THE RIGHT TOP AND THE SAME DISTANCE FROM THE LEFT TOP SIDE. I CALLED TOYOTA TO SEE IF ANY POSSIBLE RECALL WAS IN PLACE TO ADDRESS THIS SITUATION AND THEY SAID THERE WAS NO SUCH RECALL. I ASKED IF THEY RECOMMENDED ANY REMEDY FOR THE CONDITION THAT I DESCRIBED AND THEY SUGGESTED A COMPANY THAT DOES AFTERMARKET TRUCK MODIFICATIONS. IF THIS TAILGATE ISN'T DESIGNED TO CARRY A LOAD THAN A PERMANENT WARNING SIGN SHOULD BE CLEARLY VIEWED FROM THE TAILGATE POSITION AT OR NEAR THE HANDLE OR THE FLAT SURFACE WHEN THE TAILGATE IS LOWERED. SINCE IT IS APPARENT THAT AT TIMES A LOAD WILL TRAVEL ACROSS THE TAIL GATE MOVING INTO THE BED CAVITY OR BE REQUIRED TO REST ON THE TAILGATE, IT SHOULD MEET ALL LOAD REQUIREMENT THAT COULD BE REASONABLY ANTICIPATED. *TR

THE STEERING SEEMED TO SEIZE UP ALMOST INSTANTLY AS IF THE POWER STEERING WAS GOING OUT. ONCE I REALIZED THAT THE PROBLEM WASN'T A TIRE ISSUE; I.E. UNDER- INFLATION, I BEGAN TO MAKE ARRANGEMENT TO HAVE TOYOTA IDENTIFY AND CORRECT THE PROBLEM. THE TOYOTA DEALERSHIP DID AGREE TO DIAGNOSE THE PROBLEM FOR $100+ BUT THIS DIAGNOSIS CHARGE WOULDN'T BE APPLIED TO THE REPAIR. THIS,METHOD OF SERVICE SEEMED ODD TO ME SO I USED ANOTHER AUTO REPAIR SERVICE CENTER THAT PROMPTLY IDENTIFIED THE PROBLEM AND SCHEDULE THE REPAIR. IT WAS IDENTIFIED AS THE LOWER STEERING COLUMN WITH A NEAR FROZEN U-JOINT. THIS PROBLEM RESULTED IN A VERY ERRATIC STEERING PATTERN. MOST OF THE TIME THE STEERING WHEEL WOULDN'T RETURN TO THE NEUTRAL POSITION AFTER MAKING A TURN AND AT OTHER TIMES IT WOULD RETURN TO THE NEUTRAL POSITION RESULTING IN OVER STEERING. THE ANTICIPATED LACK OF RETURN TO THE NEUTRAL POSITION CAUSED ME ON OCCASION TO ATTEMPT TO STEER TO THE NEUTRAL POSITION RESULTING IN THE OVER STEERING. THIS ISSUE SHOULD BE BROUGHT TO OTHERS ATTENTION AND POSSIBLY HAVE ANY VEHICLES SUSPECT FOR A SIMILAR STEERING ISSUE INSPECTED SO REPAIRS CAN BE MADE BEFORE AN ACCIDENT OCCURS. *TR

2005 TOYOTA TACOMA. CONSUMER WRITES IN REGARDS TO AN UNINTENDED ACCELERATION INCIDENT WITH THE VEHICLE. *TGW THE CONSUMER STATED HE WAS PULLING INTO A PARKING SPACE, VERY SLOWLY WITH HIS FOOT ON THE BRAKE. WHEN HE GOT ABOUT 10 FEET FROM THE CONCRETE PARKING BLOCK, THE VEHICLE ACCELERATED, AND HE STOMPED ON THE BRAKE. HE CAME TO REST AGAINST THE CONCRETE BLOCK, SLAMMED THE GEAR SHIFT INTO PARK, AT WHICH TIME THE ENGINE RACED. HE THEN TURNED OFF THE ENGINE. THE NEXT DAY, THE TOOK THE VEHICLE TO THE DEALER FOR AN INSPECTION. HOWEVER, THERE WAS NO ONBOARD RECORD OF THE INCIDENT. *JB

IN THE SUMMER OF 2013 MY REAR TIRE FEEL OUT FROM BENEATH MY TRUCK WHILE I WAS DRIVING. THE CROSS BARS THAT HELD THE TIRE HAD RUSTED THROUGH. I FILED AN NHTSA COMPLAINT. EARLY THIS SPRING I BROUGHT MY TACOMA TO MY TOYOTA DEALER TO COMPLAIN ABOUT A LARGER PERFORATION THAT APPEARED IN MY FRAME. THERE DEALER PHOTOGRAPHED IT, SENT IT TO TOYOTA, AND INFORMED ME THEY WOULD CALL ME IF TOYOTA WAS GOING TO TAKE ANY ACTION. THE SERVICE MANAGER TOLD ME HE WAS HEARING RUMORS OF A FRAME RECALL AND THAT I SHOULD CHECK IN PERIODICALLY. EARLY IN OCTOBER OF THIS YEAR I READ ON HE INTERNET ABOUT THE TACOMA "LEAF SPRING" RECALL AND BROUGHT MY TRUCK BACK TO TOYOTA. MY TRUCK WAS AGAIN INSPECTED, PHOTOGRAPHED, AND A FEW DAYS LATER I WAS TOLD TO BRING MY TRUCK IN. I WAS TOLD THAT TOYOTA WAS MAILING OUT NOTICES TO QUALIFIED TOYOTA OWNERS AND THAT I SHOULD BE GETTING MY RECALL NOTIFICATION LETTER SOON. I HAVE NEVER YET RECEIVED THAT LETTER. HOWEVER, I BROUGHT MY TRUCK BACK TO THE DEALER ON OCTOBER 10 AND THEY PROMPTLY IMPOUNDED IT, SAYING IT WAS UNSAFE TO DRIVE. THE SERVICE MANAGER TOLD ME THAT ALTHOUGH THE FRAME REPLACEMENT WOULD TAKE JUST A FEW DAYS, THE FRAMES HAD NOT YET ARRIVED AND I SHOULD EXPECT A TWO TO THREE MONTH DELAY. I FILED A COMPLAINT WITH TOYOTA AND A FEW DAYS LATER THE CUSTOMER SERVICE REPRESENTATIVE WHO CALLED ME OFFERED NO FURTHER SOLUTION (I SUGGESTED THAT TOYOTA BUY BACK MY TRUCK AND OFFERED ME A CREDIT TOWARDS THE PURCHASE OF A NEW TOYOTA), BUT DID ADD THAT SHE THOUGHT THE FRAMES WOULD TAKE LONGER STILL TO COME IN AND THAT I SHOULD EXPECT TO BE WITHOUT MY TRUCK FOR FOUR MONTHS. I AM CURRENTLY DRIVING A LOANER PAID FOR BY TOYOTA, BUT ONE THAT DOES NOT WELL MEET THEN NEEDS MET BY MY PERSONAL TRUCK. *TR

TOYOTA ISSUED A LIMITED SERVICE CAMPAIGN NUMBER CSC-10056075-4484 FOR 2005 THRU 2008 TOYOTA TACOMA TRUCK WITH FRAME RUST PROBLEMS, MINE WAS INSPECTED AT THE LOCAL TOYOTA DEALER AND WAS TOLD THAT IT WOULD NOT PASS THE WV STATE INSPECTION YEARLY PROCEDURE. BUT WAS TOLD BY TOYOTA USA THAT MY VIN IS NOT ONE INCLUDED IN THE CAMPAIGN EVEN THOUGH IT FITS THE YEAR AND MODEL. SO I AM STUCK WITH A TRUCK THAT IS UNSAFE TO OPERATE. I HAVE ONLY ONE VEHICLE AND RETIRED AND NEED THE TRUCK. *TR

I HAVE 2005 TACOMA 4X4 WITH A FRAME THAT CRACKED AND COLLAPSED INTO ITS SELF WERE THE LEFT MOTOR MOUNT IS WELDED TO THE FRAME. THE MOTOR CAME TO REST ON THE STEERING SHAFT KNUCKLE @ THE RACK AND PINION MAKING IT DIFFICULT TO STEER. I CALLED TOYOTA SERVICE CENTER THEY TOLD ME IT WAS THE FIRST TIME THEY HAD HEARD ABOUT THIS PROBLEM. UPON RESEARCHING THE PROBLEM ON THE WEB THERE ARE WELL OVER 200 COMPLAINTS SAME PROBLEM. IT IS SUCH A PROBLEM THAT A FABRICATION COMPANY DMZ MAKES A GUSSET REPAIR KIT TO REPAIR AND REINFORCE THE FRAME. IT'S A BOUT A 10 HOUR REPAIR. HTTP://DMZFAB.COM/PRODUCT/TACOMA-MOTOR-MOUNT-GUSSET-KIT/. TOYOTA SHOULD CONTACT THEM FOR THE CURE. *TR

I TOOK MY VEHICLE FOR MAINTENANCE AND WAS TOLD THAT THE FRAME ON MY 2005 TACOMA X-RUNNER IS RUSTED AND SHOWING SIGNS OF CRACKING. I CALLED TOYOTA CORPORATE TO COMPLAIN ABOUT THE ISSUE AND WAS TOLD THERE WAS NOTHING THEY CAN DO ABOUT IT SINCE THERE IS NO RECALL OR TSB. THE RUST IS SO BAD THAT I CAN NO LONGER DRIVE MY VEHICLE. THERE WAS A RECALL NOTICE FOR THE COLD WEATHER STATES TO RECOAT OR REPLACE RUSTED FRAMES SO TOYOTA KNOWS OF THE PROBLEM ESPECIALLY SINCE THEY HAD THE SAME ISSUE WITH 95-04 TACOMAS. *TR

ON THE TOP PART OF MY HOOD ON MY 2005 TOYOTA TACOMA PRE-RUNNER. THE PAINT IS CHIPPING/ FLAKING OFF TO WHERE THE METAL IS BEING SHOWN. THE PAINT EVERYWHERE ELSE ON MY TRUCK IS FINE, EXCEPT ON THE TRIM AROUND THE WHEEL-WELL IS FADING. THE OTHER PROBLEM IS WITH THE REAR CONSOLE LATCH WHICH CLOSES AND OPENS THE CONSOLE BROKE AFTER EIGHT MONTHS OF DRIVING MY TRUCK. THE LATCH DID FEEL LIKE IT WAS STICKY UNTIL I CLOSED THE TOP PART OF THE CONSOLE AND THE LATCH BROKE OFF. I WAS ABLE TO TAKE IT OFF MYSELF BUT I EVENTUALLY FOUND OUT IN ORDER TO REPLACE THAT PART I WOULD HAVE TO BUY AN ENTIRE NEW CONSOLE FOR A PART I TOOK OFF IN LESS THAN THIRTY SECONDS. THOSE ARE THE ONLY ISSUES WITH MY 2005 TOYOTA TACOMA. *TR