2025 TOYOTA TACOMA Complaints

I am reporting a severe safety hazard on my 2025 Toyota Tacoma caused by incorrect alignment specs and an uncorrected extreme toe setting. On a recent service visit, alignment inspection showed a Total Toe of +1.62 degrees (OEM target is approximately +0.10 degrees). The alignment machine database loaded incorrect tolerance specs (+1.37 to +1.87 degrees displayed as acceptable green range), leading technicians to leave the extreme toe-in completely unadjusted. In less than 2,000 miles of normal driving since a prior inspection, both front tires suffered extreme, rapid toe wear down to the internal cord layer. Operating a vehicle with +1.62 degrees total toe causes severe lateral tire drag and creates an imminent threat of a catastrophic tire blowout at highway speeds, presenting a significant vehicle safety defect.

The contact owns a 2025 Toyota Tacoma. The contact stated that while stationary and attempting to exit the vehicle from the driver's side, the interior driver's side door handle fractured, preventing the opening or locking of the door from the inside. The handle remained physically attached to the door panel but was inoperable. The vehicle was taken to the local dealer to be inspected. While at the dealer, it was discovered that another Tacoma at the dealer had a similar interior door handle failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 4,476.

Driver side front and passenger door handle broke internally. The door is unable to be opened from the inside. This puts occupants at risk of not being able to exit the veichle in an emergency or safely from the inside. The problem was fixed for the front after several weeks due to back order of the part. Per my service representative at Toyota, it was a safety concern so they paid for a rental while they waited for the part and repaired the veichle. The mechanism broke without warning and suddenly after normal expected use.

Well, attempting to open the driver side door from the inside to exit the vehicle, door handle, became inoperative and no longer allowed exit from the driver side.

2025 Toyota Tacoma SR5 - 8038 Miles The passenger on the right rear side tried to exit the 2025 SR5 Toyota Tacoma, and the interior door handle would not engage. It was confirmed with the Toyota dealership: PERFORMED INSPECTION AND VERIFIED R/R INNER DOOR HANDLE IS INOPERATIVE. FOUND THE INTERNAL RETURN SPRINGS DISENGAGED FROM THEIR RETENTION POINTS AND HAVE LOST PROPER TENSION DUE TO INSUFFICIENT SPRING RETENTION/IMPROPER FACTORY FITMENT. CONDITION IS CONSISTENT WITH COMPONENT MATERIAL FATIGUE AND RETAINER DESIGN FAILURE, RESULTING IN LOSS OF HANDLE RETURN FUNCTION AND LATCH ACTUATION. RECOMMEND REPLACEMENT OF R/R INNER DOOR HANDLE ASSEMBLY TO RESTORE PROPER OPERATION. The part is on back order due to this being a constant issue. They have informed me that they are not sure when they will have the part. They told me that there are even customers who have been waiting for over a month so far. Driving around with the inability to open the doors from the inside is a trap hazard! Based on multiple complaints and reports, Toyota should issue a recall for these vehicles.

The driver side interior door handle fails to open the door. The only way to exit the vehicle from the driver seat is to roll the window down and use the exterior door handle. This causes and entrapment issue

The driver side inner door handle does not work. This is a huge safety issue because you can only open the door by rolling down the window and pulling the outer driver side door handle. I took the truck to the dealer and the part to fix it is on back order with no known date when they will get it. I am now forced to drive an un safe vehicle for who knows how long. This is a common issue with the 2024-2025 Tacomas and needs addressed.

The interior driver-side door handle/release mechanism on my 2025 SR5 Toyota Tacoma failed without warning. The vehicle has low mileage and was being used normally. When attempting to open the driver door from the inside using ordinary force, an internal component appears to have detached or broken, leaving the interior handle completely inoperative. The handle simply hangs loose. Vehicle and failed component are available for inspection. This defect creates a significant safety risk because I cannot exit the vehicle through the driver door from inside the cabin. The only way to exit is to roll down the window, reach backward, and pull the exterior door handle. This requires an awkward twisting motion and causes shoulder pain. In an emergency such as a crash, fire, or water intrusion event, my ability to quickly exit the vehicle could be compromised. The defect also affects my ability to care for my young son, who has a medical condition and may require immediate assistance or rescue medication. If an emergency occurred while driving, I could be delayed in reaching him because I cannot promptly exit through the driver door as designed. A Toyota dealership inspected the vehicle and confirmed the failed interior door handle mechanism. However, the replacement part is on national backorder and unavailable. I was informed repairs will likely take more than a month and that the waiting list reportedly exceeds 2,000 vehicles. Numerous Tacoma owners have reported the same failure, suggesting a widespread defect. Despite reports of widespread failures and lengthy repair delays, there has been no recall, service campaign, or proactive communication from Toyota warning owners of the defect or providing guidance while awaiting repairs. There were no warning lights, messages, or advance symptoms before the failure. The handle functioned normally until it suddenly stopped working during routine use. The defect occurred without misuse, excessive force, collision, or damage.

Both the front passenger and front driver's side doors will not open from the inside. First, the passenger side door handle became defective (I took it to the Toyota dealer and they said the interior handle assembly broke where the cable connects to the handle). The part is back ordered in the thousands. Then about a month later, the same thing happened to the driver's side door. That part is also back ordered in the thousands. Now, I am unable to open either front door from the inside - an obvious safety concern - being trapped in the car in the event of an accident. And this truck is a 2025 year with 8,800 miles on it. Toyota has provided no ETA for the new parts. A basic search online for the same issue has returned hundreds of similar stories for the same model truck. I have spoken to Toyota Corporate and they have not provided me with any sort of fix or ETA, other than to get in line and wait for the back ordered parts

My father and I both purchased a 2025 Toyota Tacoma SR5 2WD double cab last year brand new from different dealerships, both were in FL. My father was driving his new Tacoma with adaptive cruise control engaged, this was on an interstate, and the vehicle in front of him moved to the left lane next to him and started braking and this caused his vehicle to start braking extremely hard with no vehicles in front of him (he was driving about 55mph when this happened). He said this has happened to him before. I was in the vehicle with him when this happened. When I was driving from his home in GA a few days later, back to my home in FL, I was on the interstate ([XXX]) with the adaptive cruise control engaged and the exact same thing happened with my truck. A semi truck in front of me moved into the lane to the right and started braking. This caused my vehicle to start braking extremely hard with no vehicles in front of me. Had a vehicle been behind me, this could have caused me to be rear-ended going about 70mph. The sudden automatic braking with NO vehicles in front of you is aggressive enough to cause a rear-end collision and possibly cause the driver to make a startled, impulsive, corrective mistake to the sudden aggressive braking. Problem has not been confirmed or reproduced. Neither my father's or my vehicle has been inspected for this issue. Im betting its a software issue. No warning lights or messages before the aggressive braking in either mine or my fathers vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)