2003 TOYOTA TUNDRA Complaints

TL* THE CONTACT OWNS A 2003 TOYOTA TUNDRA. THE CONTACT RECEIVED A "BXD" RECALL IN 2014 FOR SEVERE FRAME CORROSION INSPECTION. THE NHTSA CAMPAIGN NUMBER WAS NOT PROVIDED. THE VEHICLE WAS TAKEN TO THE HARR TOYOTA DEALER, LOCATED AT 100 GOLD STAR BLVD, WORCESTER MA 01606, WHERE THE TECHNICIAN INSPECTED THE VEHICLE AND SPRAYED A RUST RESISTANT COMPOUND ON THE FRAME. THE CONTACT STATED THAT THE SPRAY STARTED TO FLAKE OFF WITHIN A SHORT TIME. THE VEHICLE WAS TAKEN BACK TO THE DEALER AND THE TECHNICIAN STATED THAT THE FLAKING WAS NORMAL AND TOOK PICTURES OF THE FAILURE. THE CONTACT CALLED NOXUDOL,THE SPRAY MANUFACTURER, AT (301)-972-0860 AND WAS INFORMED THAT THE FLAKING WAS NOT NORMAL. THE VEHICLE WAS TAKEN TO WESTBORO TOYOTA, LOCATED AT 271 TURNPIKE RD, WESTBOROUGH, MA, 01581, WHERE THE TECHNICIAN PERFORMED A THOROUGH INSPECTION OF THE UNDERCARRIAGE AND FOUND HOLES AND RUST IN THE FRONT PASSENGER SIDE AND REAR DRIVER SIDE OF THE FRAME. THE MANUFACTURER (TOYOTA) WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL. THE CONTACT WAS PROVIDED A CASE NUMBER. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 70,833. *TT *TR

TL* THE CONTACT OWNS A 2003 TOYOTA TUNDRA. WHILE DRIVING 2 MPH, THE SPARE TIRE FELL FROM UNDER THE VEHICLE. THE CONTACT NOTICED THAT THE SPARE TIRE RETAINING PLATE WAS RUSTED AND CORRODED, BUT NO OTHER RUST WAS NOTICED ON THE UNDERCARRIAGE OF THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO AN INDEPENDENT MECHANIC OR DEALER FOR DIAGNOSTIC TESTING AND REPAIRS. THE LOCAL DEALER (LEE TOYOTA, 115 MAIN ST, TOPSHAM, ME 04086, (207) 729-3358) WAS CONTACTED ABOUT THE REPAIR COST. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND CONFIRMED THAT THERE WERE NO OPEN RECALLS. THE FAILURE MILEAGE WAS APPROXIMATELY 138,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2003 TOYOTA TUNDRA. WHILE UNDERGOING ROUTINE MAINTENANCE, THE TECHNICIAN STATED THAT THE FRAME WAS SEVERELY RUSTED AND THE VEHICLE WAS UNSAFE TO DRIVE. THE VEHICLE WAS TAKEN TO PEARSON TOYOTA (12978 JEFFERSON AVE, NEWPORT NEWS, VA 23608, (757) 874-6000) WHERE IT WAS DIAGNOSED THAT THE FRAME WAS IN POOR CONDITION AND THE VEHICLE WAS UNSAFE TO DRIVE. THE FRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT MENTIONED THAT THE VEHICLE WAS REPAIRED IN 2012 PER A MANUFACTURER RECALL FOR FRAME RUST IN WHICH AN ANTI-CORROSIVE AGENT WAS SPRAYED ONTO THE FRAME. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 137,430. *BF THE CONSUMER REQUESTED AN UPDATE. *JS *TR

TAKATA RECALL. I RECEIVED A PAPER IN THE MAIL STATING TO FILE A PPIC PROOF OF CLAIM BECAUSE I HAD BEEN IDENTIFIED AS A CURRENT REGISTERED OWNER OF A VEHICLE WITH A TAKATA -MANUFACTURED AIRBAG INFLATORS CONTAINING PSAN. DESPITE NOT HAVING SUFFERED ANY INJURY, LOSS, OR DEATH IT WAS RECOMMENDED THAT I FILE THIS CLAIM.

ENTIRE FRAME HAS SEVERE RUST DESPITE ANTI-RUST/CORROSION INHIBITOR APPLIED IN 2010-2012. SMALL HOLES ARE NOW PRESENT IN FRAME AND THE VEHICLE ONLY HAS 108K MILES. RECENTLY, THE POWER STEERING RACK AND PINION HAD TO BE REPLACED, AS IT RUSTED OUT. THE TECHNICIAN NOTICED RUST ON OTHER SUSPENSION COMPONENTS, INDICATING THAT RUST HAD MADE THE SYSTEM WEAK AND BRITTLE. COPIOUS AMOUNTS OF CORROSION INHIBITOR HAS NOW MADE IT ALMOST IMPOSSIBLE TO OBTAIN A CORRECT ALIGNMENT. THE RUSTED FRAME WILL SOON, IF NOT ALREADY, DIMINISH THE VEHICLE'S SAFETY. TOYOTA INSTITUTED A FRAME RECALL CIRCA 2010 FOR JUST THIS ISSUE. SOMEHOW THIS VIN WAS OMITTED. THE CORROSION INHIBITOR HAS PROVED INEFFECTIVE. I AM REQUESTING THAT NHTSA DEMAND TOYOTA INSTITUTE ANOTHER RECALL FOR THE EXCLUDED VINS. THESE OMITTED TUNDRAS, IN THEIR CURRENT POOR FRAME CONDITION, PRESENT A HAZARD TO DRIVERS AND OTHER MOTORISTS AND MUST BE REPAIRED.

I RECENTLY PURCHASED MY VEHICLE FROM A AUTO DEALER AND A FEW MONTHS AFTER THE PURCHASE I NOTICED THE FRAME WAS ROTTED. I TOOK IT BACK TO THE DEALER AND THEY WOULD NOT REPLACE THE PARTS. I WENT TO TOYOTA WHO STATES THAT THEY WILL NOT DO ANYTHING EITHER MY TRUCK IS NOT SAFE TO DRIVE ON ANY ROAD FOR MYSELF OR OTHER DRIVERS.

AIRBAG LIGHT IS ON INSTRUMENT PANEL. PER TOYOTA DEALER SERVICE DEPT,DRIVERS SIDE AIRBAG NEEDS TO BE REPLACED.

TAKATA RECALL-DATE FOR "WHEN DID THIS HAPPEN?" IS APPROX. DATE VEHICLE WAS MANUFACTURED (ACCORDING TO STICKER ON DRIVER'S DOOR)

MY AIRBAG LIGHT ON AND I WENT TO DEALER THEY SAID IS BEEN REPLACE BEFORE I BOUGHT THE CAR AND THEY I WENT TO MY MECHANIC THEY BEEN REPLACE SOME NEW PART RELATED TO THE AIRBAG IS BEEN OK FOR ONE MONTH NOW THE LIGHTS ON AGAIN.

TL* THE CONTACT OWNS A 2003 TOYOTA TUNDRA. THE CONTACT STATED THAT THE PASSENGER SIDE OF THE DASHBOARD'S AIR BAG COVER MELTED AND WAS STICKY TO THE TOUCH. THE CONTACT STATED THAT, IN THE PAST, THERE WAS AN UNIDENTIFIABLE ODOR COMING FROM THAT AREA. THE VEHICLE WAS TAKEN TO DARCARS TOYOTA FREDERICK (5293 BUCKEYSTOWN PIKE, FREDERICK, MD 21704 (301) 696-6300). BUT THE CAUSE OF THE FAILURE COULD NOT BE DIAGNOSED. THE DEALER TOOK PICTURES AND SENT THEM TO A LOCAL TOYOTA REPRESENTATIVE FOR DARCARS. THE CONTACT MENTIONED HE WAS AFRAID TO DRIVE THE VEHICLE DUE TO SUN GLARE AND WAS UNSURE IF THE PASSENGER SIDE AIR BAG WAS SAFE. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS APPROXIMATELY 65,000.