2002 TOYOTA TUNDRA Complaints

I AM THE OWNER OF TWO TOYOTA VEHICLES. VEHICLE ONE IS A 1992 TOYOTA PICKUP EXTENDED CAB 4X4 3.0 V6 WITH 220,000 MILES ON IT I BOUGHT IT WITH 124,000 MILES ON IT. VEHICLE TWO IS A 2002 TOYOTA TUNDRA SR5 4.7 V8 WITH 47,000 MILES I BOUGHT IT WITH 39,000 MILES ON IT WITH ONLY ONE PREVIOUS OWNER. THE NEW FRAME IS INSTALLED ON THE TRUCK BUT I HAVE NOTICED NOW THAT MY REAR AXLE HOUSING IS COMPLETELY ROTTED AND RUSTED OUT AND LEAKING ALL OVER THE PLACE. THE STRUCTURE OF THIS IS NOT SAFE AND I TRAVEL AN AVERAGE 6,000 MILES A MONTH FOR WORK. MY 1992 TOYOTA TRUCK WITH 219,000 MILES REAR AXLE IS IN BETTER SHAPE THAN THE 2002 TOYOTA. I HAVE SPOKE WITH TOYOTA DIRECTLY AND THEY REFUSE TO DO ANYTHING ABOUT THE SITUATION. THERE SHOULD BE A LAW SUIT AGAINST TOYOTA FOR NOT REPLACING THESE REAR AXLES BECAUSE THE SAME METAL WAS OBVIOUSLY USED ON THE FRAME THAT WAS REPLACED. I HAVE NOW SEEN MANY OF THE SAME TRUCKS AROUND MY TOWN WITH THE SAME PROBLEM AND HAVE READ MANY COMPLAINTS ON THE INTERNET ABOUT THIS RECURRING SITUATION. IT IS IN TOYOTA'S BEST INTEREST TO TAKE CARE OF THE PROBLEM BEFORE THERE IS A CLASS ACTION AGAINST THEM. *TR

TL* THE CONTACT OWNS A 2002 TOYOTA TUNDRA SR5. THE CONTACT WAS DRIVING 40 MPH WHEN THE POWER STEERING SEIZED. THE CONTACT LATER DISCOVERED THAT THE POWER STEERING FLUID WAS LEAKING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS CONFIRMED THAT THE STEERING RACK WAS CORRODED. THE MANUFACTURER WAS NOT CONTACTED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE 140,000.

REAR BRAKE LINE HAD SEVERE CORROSION WHERE IT ATTACHED TO THE PROPORTIONAL VALVE. CORROSION CAUSED BRAKE FLUID TO LEAK AND BRAKE FAILURE. *TR

SEVERE FRAME RUST CAUSING RUSTING ON BRAKE LINES, RUSTING AND HOLE IN THE GAS TANK, STEERING RACK, AND REAR AXLE IS ALMOST RUSTED THREW. THE FRAME RUST IS VERY SEVERE AND AT THIS POINT I AM SURE IT IS A SAFETY CONCERN. *TR

GAS TANK HAS RUSTED THREW, MAIN CAUSE IS ALL THE RUST FROM THE FRAME DRIPPING ONTO THE TANK AND RUSTING IT OUT. I TOLD THE DEALER IT WAS LEAKING. BUT NO SOLUTION WAS EVER OFFERED. *TR

STEERING RACK ROTTED OUT AND ALL THE POWER STEERING FLUID DRAINED OUT ALMOST INSTANTLY. THANKFULLY I WAS PULLING OUT OF A PARKING SPACE AND NOT ON THE HIGHWAY. I CURRENTLY HAVE EXCESSIVE FRAME RUST, A HOLE IN THE GAS TANK FROM RUST, THE REAR DIFFERENTIAL IS ALMOST ROTTED THREW, THE GAS TANK STRAPS HAVE ALREADY BEEN REPLACED. I AM NOT SURE IF THIS VEHICLE IS EVEN SAFE TO DRIVE ANYMORE. THE DEALER INSPECTS IT REGULARLY FOR THE FRAME RUST BUT THEY HAVE NEVER PROVIDED A FIX. *TR

TL* THE CONTACT OWNS A 2002 TOYOTA TUNDRA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR A REPAIR ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 09V444000 (STRUCTURE: FRAME AND MEMBERS: UNDERBODY SHIELDS). WHILE THE TECHNICIAN PERFORMED THE REPAIR, HE NOTICED BOTH STABILIZER LINKS AND THE PARKING BRAKE REAR WHEEL MECHANISM WERE FRACTURED AS A RESULT OF EXCESSIVE RUST CORROSION. IN ADDITION, THE RACK AND PINION WAS CORRODED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 74,000. UPDATED 4/3/12 *CN THE CONSUMER STATED THE FRONT STABILIZER LINKS BROKE OFF, DUE TO THEM BEING RUSTED. THE DRIVER SIDE EMERGENCY BRAKE SEIZED. THE STEERING SHAFT U-JOINT WAS BADLY RUSTED. UPDATED 05/17/12

TL* THE CONTACT OWNS A 2002 TOYOTA TUNDRA. WHILE PARKED, THE CONTACT NOTICED THE FRAME AND UNDERBODY WAS CORRODED. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 09V444000 (STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS) BUT WAS ADVISED BY THE MANUFACTURER THAT THE RECALL ONLY PERTAINED TO VEHICLES IN CERTAIN STATES AND THAT HIS VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

TL* THE CONTACT OWNS A 2002 TOYOTA TUNDRA. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE FRONT PASSENGER WHEEL DETACHED FRONT THE VEHICLE. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHO DIAGNOSED THAT THE UPPER AND LOWER BOLT JOINTS SEPARATED AND AS A RESULT, THE BOLT JOINTS AND STEERING ASSEMBLY NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 240,000.

THE REAR FRAME AND CROSS MEMBERS ARE SO RUSTY THAT IT IS CAUSING THE BED TO RUST FROM THE FRAME UP. EVERYWHERE THE BED ATTACHES TO THE FRAME IT HAS RUSTED THROUGH. EVENTUALLY THE RUST WILL BE SO BAD THAT THE RUST AROUND THE BOLT HOLES WILL NO LONGER KEEP THE BED ATTACHED TO THE FRAME . THIS IS DEFINITELY A SAFETY ISSUE AND TOYOTA TELLS ME THAT NO RECALL HAS BEEN ISSUED FOR THE BEDS OF THE RUSTY TRUCKS. *KB