2002 TOYOTA TUNDRA Complaints

on June 9th at about 2pm while driving through my neighborhood, my upper an lower ball joints on my 2002 Toyota Tundra separated from my vehicle causing a catastrophic loss of control of truck and tore my hub with tire from vehicle ripping the brake fuel line and shoving entire components up under my Tundra while losing control with no brakes or steering capability. It also destroyed the drivers side front tire. Needless to say if I was say...going 55 to 60 miles per hour on highway...I would not be writing this. Had truck towed to Checkered Flag Toyota and they quoted me a price of over1300$ in repairs... they are fighting me on fixing my truck damages even though said damages were caused by the ball joint recall on the 2002 tundra...recall I D#05v

2002 Tundra was recalled for the rusty frame. I had mine inspected at the time of the recall. The dealership sprayed the frame of my truck. Now my frame is severely rusted and unsafe to drive. The balance of my vehicle is in good condition with approximately 200,000 miles. Will I be eligible for repair or replacement? Who should I contact? Thank you Bridgette Gartmann

LOUD KNOCK TURNING THE WHEEL TO THE LEFT, RACK AND PINION LEAKAGE, INNER OUTER TIE RODS CAN SNAP CAUSE AN INJURY OR DEATH. HEADLIGHTS ARE VERY DIM EVEN THE BRIGHT LIGHTS ARE DIM. AN ONCOMING CAR IS NOT EVEN PHASED WHEN I HAVE MY BRIGHT LIGHTS ON. IT'S DIFFICULT TO SEE VERY WELL WITH THOSE [XXX] LIGHTS THEY'RE ALMOST IN AMBER COLOR TRIED TO USE LENS RENEW DID NOT WORK. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2002 TOYOTA TUNDRA. THE CONTACT STATED THAT WHILE DRIVING, THE ACCELERATOR PEDAL BECAME STUCK TO THE FLOORBOARD AND THE VEHICLE SPEEDED UP OUT OF CONTROL AND CRASHED INTO A SHED IN HIS YARD AND CRASHED INTO A TREE WHERE IT CAME TO A STOP. THAT COLLISION LOOSENED THE ACCELERATOR PEDAL AND VEHICLE WAS ABLE TO COME TO A STOP. THE DEALER AND MANUFACTURER HAD NOT BEEN CONTACTED YET. THE VEHICLE REMAINS UNREPAIRED IN THE PARKED CONTACT'S YARD. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 180,000. *BF*JB*JB

TL* THE CONTACT OWNS A 2002 TOYOTA TUNDRA. THE CONTACT STATED THAT THE FRAME WAS RUSTED AND THERE WAS A HOLE BEHIND THE DRIVER'S SIDE DOOR. THE CONTACT CALLED ACTON TOYOTA OF LITTLETON (221 GREAT RD, LITTLETON, MA 01460, (978) 263-1500) HOWEVER, THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE CONTACT STATED THE FAILURE WAS LIKE NHTSA CAMPAIGN NUMBER: 09V444000 (STRUCTURE). THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 220,000.

LOUD POPPING SOUND WHEN TURNING THE STEERING WHEEL, HEAD LIGHTS ARE VERY DIM EXTREMELY HARD TO SEE AND MELTING PLASTIC AROUND THEM

I HAD MY LOWER BALL JOINT SEPARATE FROM THE KNUCKLE. LUCKILY I WAS IN A PARKING LOT. I SEE THAT THERE WAS A RECALL ON THE LOWER BALL JOINT FOR 02 TUNDRA. SO I DO I GO ABOUT GETTING A REFUND FOR WHAT I HAD TO SPEND. *TR

REAR DIFFERENTIAL IS LEAKING OIL DUE TO FAULTY METAL USED IN MANUFACTURING. DIFF. IS LEAKING THRU RUST HOLES IN HOUSING METAL AND NOT THRU SEALS.

THE REAR AXEL AND DIFFERENTIAL HOUSING/CASTING IS CORRODED THRU SUCH THAT OIL IS LEAKING THROUGH THE DIFFERENTIAL HUB ONTO THE ROADWAY AND RESULTING IN A LOSS OF GEAR OIL WITHIN THE DIFFERENTIAL AND AXELS. AFTER DRIVING ON THE HIGHWAY THIS OIL WAS OBSERVED ON THE SPARE TIRE (MOUNTED UNDER THE BED) AND UP THE BACK OF THE BUMPER. THE SERVICE REPRESENTATIVE AT ONE DEALERSHIP I APPROACHED TO DISCUSS THE COST OF REPAIR INDICATED THAT THEY HAVE SEEN THE PROBLEM MULTIPLE TIMES. THIS OBVIOUSLY SHOULD NOT BE HAPPENING AND I BELIEVE IT TO BE THE RESULT OF A DEFECTIVELY DESIGNED/MANUFACTURED COMPONENT. I HAVE NOT YET HAD THE VEHICLE REPAIRED DUE TO THE HIGH COST, BUT IT IS NOT DRIVEABLE AS THE DIFFERENTIAL WILL NOT HOLD GEAR OIL.

AIR BAG LIGHT IS ON AND TOOK IT TO MECHANIC WHO SAID THERE IS A PROBLEM WITH THE PASSENGER BAG AND IT IS DEACTIVATED. THIS SEEMS TO BE A PROBLEM THAT MANY OTHERS ARE ALSO HAVING FROM THE COMPLAINTS I HAVE READ.