2005 VOLKSWAGEN BEETLE Complaints

I OWN A 2005 BEETLE INTERMITTENTLY IT DOESN'T START. I HAVE HAD IT IN THE SHOP AS MUCH AS I HAVE DRIVEN,IN A YEAR AND A HALF.THE LAST THING THEY THOUGHT IT MIGHT BE IS THE ELECTRIC CONTROL MODULE. HAS THERE BEEN ALOT OF COMPLAINTS IN THIS AREA. PLEASE FURTHER ADVISE ME. *TR

TL*THE CONTACT OWNS A 2005 VOLKSWAGEN NEW BEETLE CONVERTIBLE. WHILE DRIVING AT AN UNKNOWN SPEED, THE AIR BAG LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT TOOK THE VEHICLE TO A MECHANIC AND WAS INFORMED THAT THE AIR BAG SENSOR FAILED AND WOULD COST $500 TO REPAIR. THE DEALER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 08V178000. THE MANUFACTURER HAS NOT BEEN NOTIFIED AND THE VEHICLE HAS NOT BEEN REPAIRED. THE CURRENT MILEAGE WAS 35,140 AND FAILURE MILEAGE WAS APPROXIMATELY 33,500.

2005 VW BEETLE WITH 86,000 MILES DIAGNOSED WITH INTERNAL TRANSMISSION FAILURE (METAL IS SHEARING OFF INTERNALLY). I HAVE BEEN ADVISED BY TWO MECHANICS THAT THIS IS PROBLEM WITH THIS MODEL YEAR. II CONTACTED VW AND THEY WOULD NOT ACKNOWLEDGE THE PROBLEM. SUGGESTED REPAIRS COULD TOTAL $9,000. *TR

MY 2005 NEW BEETLE CONVERTIBLE HAS BOTH A SIDE CRASH SENSOR AND A COOLANT TEMP SENSOR BOTH ARE OUT AND NEEDING TO BE REPLACED. COST OF OVER 800.00. *TR

I OWN A 2005 VW BEETLE AND HAVE HAD THE CAR SINCE NEW. THE HEADLIGHTS ON THE CAR ARE COMING APART AT THE SEAMS. VW SAYS THIS IS NORMAL. I DON'T THINK IT IS NORMAL AT ALL. SEEMS LIKE FAULTY PARTS TO ME. HEADLIGHTS SHOULD NOT BE COMING APART AT THE SEAMS. *TR

TL*THE CONTACT OWNS A 2005 VOLKSWAGEN BEETLE. THE CONTACT STATED THAT THE FRONT DRIVER'S SIDE AIR BAG FAILED AND THE WARNING INDICATOR WAS ILLUMINATED ON THE INSTRUMENT PANEL. THE DEALER STATED THAT THE ENTIRE DRIVER'S SIDE AIR BAG WAS INOPERABLE AND THE SENSOR FAILED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 08V178000 (AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE), ALTHOUGH THE FAILURES WERE IDENTICAL. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 53,000.

PURCHASED 2005 VW BEETLE WITH 7,300 MILES ASSURED FULL WARRANTY....GUARANTEED PAINT ON FRONT BUMPER WOULD BE CORRECTED...DID IT TWICE STILL PEELING OFF....ELECTRIC WINDOWS REPAIRED TWICE....BEGAN MAKING NOISES WHEN WEATHER WAS DAMP...TOOK IT TO BE CHECKED OUT AND WAS ASSURED IT WOULD NOT ALWAYS HAPPEN BUT NORMAL...TOLD THEM TRANSMISSION SEEMED TO BE SLIPPING....ONE HEADLIGHT HAD A SHORT, AND THEN RECALL ON BRAKELIGHT...THEY DID REPAIR THAT...BUT INFORMED ME THAT WAS ALL THEY HAD TIME TO DO THAT DO DUE TO RECALL...GAS CAP COVER WAS STICKING AS WELL...DIDN'T FIX IT EITHER....THEN MY AIR BAG LIGHT CAME ON...TOOK IT IN FOR RECALL ON THAT ...AFTER IT WAS SUPPOSEDLY FIXED AIRBAG LIGHT DID NOT GO OFF, INSISTED IT HAD NOTHING TO DO WITH SENSOR THAT WAS RECALLED...NOISE IN FRONT END BEGAN AND FLOORBOARD FLOODED DURING HEAVY RAIN....WITH NO OBVIOUS ENTRY POINT....DID SEARCH FOR PROBLEMS WITH VW BEETLES AND THERE ARE THOUSANDS HAVING THE VERY SAME PROBLEMS I HAVE BEEN EXPERIENCING....NOW HEAT GAUGE LIGHT COMES OFF AND ON, ALARM RANDOMLY SOUNDS.....BUT NOISE IN FRONT END CONCERNS ME GREATLY...WOULD NOT EVEN DIAGNOSE CAR WITHOUT $98 BUCKS AN HOUR LABOR CHARGE TO FIND PROBLEMS.... THIS CAR ONLY HAS 34,952 MILES ON IT AND IT IS FALLING APART...NO WAY CAN ALL THESE PROBLEMS BE FIXED AND ME MAKE PAYMENTS....BUT THOUSANDS ARE HAVING THESE VERY SAME PROBLEMS...WHY HAS OUR GOVERNMENT NOT INSISTED ON A RECALL..... *TR

2005 VW NEW BEETLE. AIRBAG LIGHT CONTINUES TO LIGHT UP. THE CAR HAS BEEN TO VW SHOP CONTINUALLY FOR THIS ISSUE AND NOW THE WARRANTY IS OUT IT WILL COST $108.00 FOR THE TEST AND $100.00 PLUS LABOR TO REPAIR. THIS PROBLEM IS CONTINUING AND THE FACTORY SHOULD HAVE A SOLUTION. *TR

DMF FAILED BLEW SHRAPNEL THROUGH BELL HOUSING! NORMAL DRIVING, VOLKSWAGEN NEW BEETLE, 2005.5 DIESEL 1.9L TDI AUTOMATIC TRANS DSG. DUAL MASS FLYWHEEL (DMF) EXPLODED ON THE ROAD UNDER 10MPH. SMALL METAL PARTS OF SPRINGS AND ALUMINUM PUNCHED HOLE IN SIDE OF CASE. CLEAR 'GREASE' AND SHAVINGS EVERYWHERE. COULD HAVE CAUSED ENGINE OR WHEELS TO LOCKUP IF IT HAD JAMMED A LARGER PIECE IN THE DRIVETRAIN. TOWED TO DEALER WITH 95K MILES, SOUNDS LIKE A SLIGHT GRINDING NOISE ON ACCELERATION. THIS IS HEAVY PART WITH A LARGE HOLE BLOWN IN THE EDGE WHERE PARTS CAME FLYING OUT. ONLY OFFERED A $750 REBATE ON PURCHASE OF A NEW VW... THIS IS A MANUFACTURING DEFECT, IMHO, THAT VWOA DID NOT COVER. REPLACEMENT PART NUMBER FOR DMF, OEM PART NO LONGER AVAILABLE. VW REPLACED WITH PART NUMBER 03G-105-266-BE $785. WORK DONE AT DEALER, ALMOST $2K! MANY DMF FAILURE STORIES BLAME THE CLUTCH, BUT MINE IS AN AUTOMATIC! THIS IS A BAD PART, THAT VWOA IS TRYING TO HIDE KNOWLEDGE OF, BLAMING CUSTOMERS. OTHER AUTO MAKERS HAVE ADMITTED BAD PART AND REPLACED AT 100K MILES! I HAVE THE OLD PART AND FURTHER CHECKS CAN BE DONE TO SHOW IT FAILED ON THE INSIDE. MY TEENAGE DAUGHTER IS SCARED TO DRIVE IF IT WERE TO HAPPEN TO HER! NO WAY TO KNOW, THERE IS NO SCHEDULED MAINT, NOTHING TO CHANGE OR CHECK. FLYWHEEL SHOULD BE COVERED BY VWOA, IT IS NOT A WEAR ITEM! CAN YOU HELP? MANY OTHERS MAY NOT BE REPORTING IF VWOA IS REPLACING UNDER WARRANTY, AS MY WEB RESEARCH SEEMS TO SHOW. THEY HAD TO REPLACE AN AIRBAG, BUT MY DMF EXPLODING ON THE ROAD IS NOT THEIR PROBLEM? WHY NO RECALL AND NO TSB'S? BEW GYS WITH DIRECT SHIFT GEARBOX. DAMPING LAYER FAILED IN DMF. THIS WILL BECOME A LARGER ISSUE AS MORE MILES ARE LOGGED ON THIS PART. WILL IT CAUSE SOMEONE TO LOOSE LIFE? THANKS. *TR

TL*THE CONTACT OWNS A 2005 VOLKSWAGEN NEW BEETLE. THE CONTACT RECEIVED A SAFETY RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 08V178000 (AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE), AND CALLED VOLKSWAGEN TO SCHEDULE A REPAIR APPOINTMENT. HE HAD TWO SCHEDULED APPOINTMENTS THAT WERE CANCELLED BECAUSE THE PARTS WERE UNAVAILABLE. HE WAS INFORMED THAT VOLKSWAGEN WAS ONLY ALLOTTING TEN PARTS PER WEEK TO THE DEALERS FOR THE REPAIR. THE FAILURE MILEAGE WAS 49,000. UPDATED 08/29/08.*LJ UPDATED 09/03/08. *JB