2002 VOLKSWAGEN JETTA Complaints

I BOUGHT MY 2002 VW JETTATDI IN 2004, DURING ROUTINE MAINTENANCE I DESCRIBED A HESITATION IN THE TRANSMISSION. THEY CHECKED THE TRANSMISSION FLUID AND SAID IT WAS "BURNED" AND REPLACED IT. I ASKED HOW IT GOT THAT WAY AND WAS TOLD SOMETHING GOT HOT IN THERE. THAT WAS IT. SEVERAL YEARS LATER AND ONE MORE CHANGING OF THE TRANSMISSION FLUID BECAUSE IT WAS BURNED, THE CAR WOULDN'T AUTOMATICALLY SHIFT INTO 4TH GEAR AND WOULD HESITATE AND SURGE FORWARD. THE MECHANIC REPLACED A SENSOR THAT TELLS THE CAR TO SHIFT INTO 4TH. IT WAS FINE FOR TWO WEEKS THEN, WHILE DRIVING 55 MPH ON THE HIGHWAY, THE CAR JOLTED LIKE I HAD HIT SOMETHING (WHICH I DID NOT BECAUSE I LOOKED)AND DECELERATED QUICKLY. I IMMEDIATELY PULLED OVER AND FROM THAT POINT ON THE CAR WOULD GO UP TO 20 - 30 MPH THEN BUCK AND DECELERATE TO 5 MPH. IT KEPT REPEATING THIS AS I TRIED TO ACCELERATE. 1ST GEAR AND REVERSE DIDN'T WORK AT ALL. WHEN THE CAR WAS BEING LOADED TO BE TOWED THE FRONT WHEELS WOULD NOT ROLL BACKWARDS WITH THE CAR IN NEUTRAL AND THE E BRAKE OFF. THE TRANSMISSION COMPANY SAID THE TRANSMISSION HAD MELTED DOWN INSIDE. AND IT WILL COST $4000.00 TO REBUILD THE TRANSMISSION. THE WAY THIS HAPPENED WAS VERY DANGEROUS; FORTUNATELY I WAS NOT PASSING ANOTHER CAR OR THAT THERE WERE NO CARS DIRECTLY BEHIND ME OR PULLING OUT TO CROSS TRAFFIC. *TR

I BOUGHT A 2002 VOLKSWAGEN JETTA GLS FROM A USED CAR DEALER LAST APRIL. I HAVE HAD A COUPLE PROBLEMS THAT I THOUGHT WAS UNIQUE TO MY SPECIFIC CAR, HOWEVER, AFTER HOURS OF RESEARCH I'VE FOUND THAT NUMEROUS OTHER JETTA OWNERS ARE HAVING SOME OF THE SAME PROBLEMS. 1. THE VEHICLE SMELLS LIKE CRAYONS 2. THE HEATER STOPS WORKING AND ONLY BLOWS OUT HOT AIR. 3. THE ENGINE EATS OIL AND HAS A PROBLEM WITH SLUDGE. THIS IS INAPPROPRIATE AND NO ONE IS TAKING ANY RESPONSIBILITY OR HAS A REMEDY FOR THESE PROBLEMS. I'M AFRAID THE FUMES FROM THE VEHICLE MAY BE TOXIC AND AM UNABLE TO GET RID OF THE CAR. *TR

1. 2002 VW JETTA WAGON ELECTRICAL SYSTEM FAILURE ON EXPRESSWAY CAUSED VEHICLE TO STOP & UNABLE TO START 9/6/09. VEHICLE TOWED TO DEALER. 2. VW DEALER FAILURE DESCRIPTION, WIRE HARNESS CORROSION CAUSED RESTRICTION IN POWER FLOW IN LINE WHICH CAUSED ALTERNATOR TO OVERWORK AND OVERHEAT WIRE HARNESS AND FUSE PANEL. THIS EXTENSIVE ENOUGH TO CAUSE MELTING OF BOTH WIRE HARNESS AND FUSE PANEL OVER TOP OF BATTERY. 3. VW DEALER REPAIR AND REPLACE WIRE HARNESS AND FUSE BODY. 4. VW CUSTOMER CARE TOOK INFORMATION ON MY COMPLAINT ABOUT DEFECT AND POTENTIAL SAFETY ISSUE BUT WOULD DO NOTHING REFERRING ME BACK TO THE DEALER. MY QUESTION WAS WHY DID VW HAVE SUCH A DEFECT WHERE THERE WAS NO FUSIBLE LINK THAT WOULD FAIL FIRST PREVENTING THE EXTENSIVE DAMAGE THAT OCCURRED. *TR

2000 TO 2002 VOLKSWAGEN TIPTRONIC OWNERS NOT PROVIDED CORRECT INFORMATION REGARDING THE TRANSMISSION SERVICING SCHEDULING. VOLKSWAGEN STATES THAT THE TRANSMISSION IS A "SEALED" UNIT AND THEREFORE SERVICE IS NOT NEED UNLESS LEAKS ARE VISIBLE. KNOWING THIS, I DID NOT TRY TO DO TRANSMISSION SERVICE ON MY CAR WHEN IT REACHED ABOUT 86,000 MILES. - GEARS SLIP FROM 1ST TO 2ND AT COLD STARTS AND JERKS AT 3RD GEAR. I HAVE TO WARM THE VEHICLE IN 10 MINUTES TO GO BACK TO NORMAL OPERATING MODE. - TODAY I WAS TAKING MY WIFE AND MY 1-YEAR OLD DAUGHTER TO LAKE GEORGE NY FROM QUEENS NY FOR A HOLIDAY WEEKEND. THE CAR SUDDENLY SLIPPED FROM 5TH TO 4TH GEAR WHILE WE ARE DRIVING 65 MPH. HOWEVER, I DID NOT FIND THE PROBLEM UNTIL I NOTICED THAT OUR SPEED ALMOST FEELS THE SAME EVENTHOUGH I DEPRESS THE PEDAL A LITTLE LOWER. I PLACED IT ON MANUAL MODE AND THE CAR SHIFTED FINE. WE PULLED OVER AT THE REST AREA AND FOUND OUT THAT THERE IS A TRANSMISSION FLUID LEAK. WE COULD HAVE HAD AN ACCIDENT IF THE GEAR WOULD HAVE SLIPPED TO 2ND; ALMOST LIKE SLAMMING THE BREAKS WHILE DOING 65 MPH. - TOMORROW, I WILL HAVE VW REPAIR SHOP DIAGNOSE THE PROBLEM. MOST LIKELY IS THE TRANSMISSION CONTROL UNIT OR THE TRANSMISSION SOLENOIDS. - SIMILAR ISSUES IN DSG TRANSMISSION WAS REPORTED AT "GOOD MORNING AMERICA" ON AUGUST 28 2009. - PLEASE SEE SIMILAR TIPTRONIC OWNER'S COMPLAINTS ON THIS FORUM: VWVORTEX.COM. THIS IS A PUBLIC WEB FORUM AND NO PERSONAL INFORMATION IS PROVIDED. *TR

2002 VW JETTA VR6 WITH CYLINDER NO. 5 MISFIRING, ROUGH IDLE AND CHECK ENGINE STAYS ON. VEHICLE TAKEN TO THE DEALER WHERE IT WAS PURCHASED, THEY REPLACED THE COIL PACK INJECTORS AND THE CAR HAS BEEN TUNED, HOWEVER, THE TECH'S AT THE DEALER CAN NOT PINPOINT THE PROBLEM AND THE CAR WILL NOT PASS THE STATE INSPECTION. *TR

2002 VW SEDAN WA BROAD SIDED BY A MOTORCYCLE. IT HIT THE RIGHT FRONT DOOR AND BUCKLED THE CENTER POST AND BENT THE ROOF AND THE DASH WAS PUSHED IN. THE VW HAS FRONT AND SIDE AIRBAGS. NONE OF THE AIR BAGS DEPLOYED. MY SON WAS COVERED WITH GLASS AND THE RIGHT HAND MIRROR JUST MISSED HIM. *TR

I HAVE A 2002 VOLKSWAGEN JETTA THIS MORNING WHILE DRIVING MY CAR TO WORK IN HOUSTON TEXAS ON INTERSTATE 59 SOUTH MY DRIVERSIDE WINDOW AIRBAG DEPLOYED AS WELL AS THE SEAT AIRBAG. AFTER GETTING TO THE SIDE OF THE ROAD MY CAR CRANKED BACK UP AND I GOT OUT TO INSPECT IF THERE WAS ANY DAMAGES. I FOUND NO DAMAGES ON THE CAR AND THE AIR BAG DEPLOYED FOR NO REASON. I AM LUCKY I DID NOT SWERVE OR THERE WOULD HAVE BEEN A HUGE WRECK. I BELIEVE THERE SHOULD BE A RECALL ON ALL OF THESE 2002 JETTA SINCE THERE HAVE BEEN SO MANY OCCURRENCES OF THIS HAPPENING. *TR

I PURCHASED A 2002 VOLKSWAGEN JETTA 1.8T WITH A 5-SPEED MANUAL TRANSMISSION FROM A PRIVATE SELLER ON 07/18/2009 AT 12:00PM. 12 HOURS LATER, AT 12:00AM ON 07/19/2009 I AM ON MY WAY HOME WHEN I REALIZED MY JETTA WAS NOT DELIVERING POWER TO THE WHEELS. THE ENGINE WAS PRODUCING POWER, BUT SOMETHING WAS WRONG WITH THE TRANSMISSION. I SMELLED SOMETHING BURNING (TRANSMISSION FLUID, MOST LIKELY) AND PARKED IT IMMEDIATELY. WHEN I GOT HOME, I SEARCHED ONLINE FOR WHAT IT COULD BE AND IT TURNS OUT I AM NOT THE ONLY ONE THIS HAS HAPPENED TO. THERE ARE COUNTESS OTHERS WHO HAVE POSTED THIS SAME PROBLEM ON VARIOUS MESSAGE BOARDS AND FORUMS ALL OVER THE INTERNET. I AM ASSUMING THAT THE REPAIR SHOP IS GOING TO TELL ME THAT THE TRANSMISSION IS SHOT AND THAT I WILL NEED TO REPLACE IT. HOW CAN MY PREVIOUS CAR, A JUNKER HYUNDAI ACCENT WITH 101,000 MILES AT TIME OF PURCHASE LAST 36,000 MORE MILES WITH A 5-SPEED MANUAL, AND A JETTA CAN'T EVEN LAST ONE DAY? I AM INFURIATED BECAUSE I JUST BOUGHT THIS CAR AND HAVE TO MAKE PAYMENTS ON IT AS WELL AS REPAIR THE THING. THIS SHOULD BE COVERED BY VW AS A RECALL. *TR

TL*THE CONTACT OWNS A 2002 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE SEAT HEATER BURNED HIS BODY THROUGH HIS PANTS. THE MANUFACTURER STATED THAT THEY WOULD SEND AN AGENT TO INSPECT THE VEHICLE AND CALL HIM BACK. THE FAILURE MILEAGE WAS 73,000.

2002 VOLKSWAGEN JETTA 1.8T TRANSMISSION SHIFTS IRREGULAR TRANSMISSION PROBLEMS. *TR