2006 VOLKSWAGEN JETTA Complaints

CAM WEAR FOUND ON 6/8/11, 195761 MILES. CAM SHAFT WEAR SEEN DURING TIMING BELT CHANGE. REPLACED CAM SHAFT, FOLLOWERS, AND BEARINGS. FACTORY RECOMMENDED OIL AND OIL CHANGE INTERVALS WERE USED. CAM SHAFT WAS ALSO REPLACED ON 11/03/09 AT 123086 MILES AFTER THE FOLLOWING INCIDENT: KNOCKING HEARD FROM ENGINE WHILE DRIVING ON HIGHWAY NEAR DESTINATION, APPROXIMATELY 300 MILES FROM HOME. VEHICLE ARRIVED AT DESTINATION, BUT WOULD NOT START. VEHICLE WAS TOWED TO MECHANIC. CAMSHAFT WEAR AND FOLLOWER BORE FOUND TO BE DAMAGED BEYOND REPAIR AND WAS REPLACED USING OEM PARTS. VEHICLE WAS USING FACTORY RECOMMENDED OIL AT REGULAR INTERVALS. *TR

AIR BAG INDICATION LIGHT CAME ON WHILE DRIVING. AIR BAGS DID NOT DEPLOY. CAR WAS NOT INVOLVED IN ANY TYPE OF COLLISION AT THAT TIME. AIR BAG LIGHT HAS BEEN ON SINCE. SRS CODE NOT ABLE TO BE CLEARED FROM MEMORY. *TR

KNOCKING HEARD FROM ENGINE WHILE DRIVING ON HIGHWAY NEAR DESTINATION, APPROXIMATELY 300 MILES FROM HOME. VEHICLE ARRIVED AT DESTINATION, BUT WOULD NOT START. VEHICLE WAS TOWED TO MECHANIC. CAMSHAFT WEAR AND FOLLOWER BORE FOUND TO BE DAMAGED AND WAS REPLACED USING OEM PARTS. VEHICLE WAS USING FACTORY RECOMMENDED OIL AT REGULAR INTERVALS. CAM WEAR FOUND AGAIN ON 6/8/11, 195761 MILES. CAM SHAFT WEAR SEEN DURING TIMING BELT CHANGE. REPLACED CAM SHAFT, FOLLOWERS, AND BEARINGS. ONCE AGAIN, FACTORY RECOMMENDED OIL AND OIL CHANGE INTERVALS WERE USED. *TR

CAM SHAFT AND LIFTER INFERIOR QUALITY!!WHAT HAS HAPPENED ACCORDING TO OTHER OWNERS OF TDI'S THAT I HAVE TALKED TO IS THAT THE CAMSHAFT AND LIFTERS HAVE FAILED. THEY WERE BUILT INFERIOR AND BREAKDOWN. THIS CAUSES A LOT OF CONFUSION WITH MECHANICS TRYING FOR ENDLESS HOURS TO FIGURE OUT WHY ITS SMOKING. WITH A LOT OF RESEARCH I FOUND OUT THAT THE CAMSHAFT AND LIFTERS ARE INFERIOR AND BREAKDOWN. WHY DOES VOLKSWAGEN DO THAT TO PEOPLE, IT COST ME SO MANY THOUSANDS OF DOLLARS REPLACING TURBO, MASS AIR FLOW SENSOR TO REBUILDING THE ENGINE FOR GOD SAKE TO FIND THAT IT IS THE CAM AND THAT THIS IS A COMMON PROBLEM. VOLKSWAGEN SHOULD BE HELD ACCOUNTABLE FOR THIS. *TR

DRIVER'S REAR DOOR LOCK STOPPED RESPONDING TO THE BUTTONS ON IT, AND ON THE MAIN CONTROL, AND ON THE REMOTE. IT INTERMITTENTLY WORKED UNTIL MARCH AND IS NOW DEAD. THE CAR CANNOT BE LOCKED AND THAT IS A SAFETY ISSUE. *TR

AT APPROX 80-90K I STARTED HEARING A CLATTERING NOISE FROM THE ENGINE AND EXTRA NOISE WHEN IDLING. ALSO, THE CAR HAS A HARD TIME SHIFTING (AUTOMATIC TRANS). AFTER TAKING THE CAR TO A MECHANIC, I WAS TOLD THAT IT'S THE DSG DMF COMING APART AND RATTLING. AFTER DOING SOME RESEARCH, I FIND IT'S A COMMON PROBLEM. IT STARTED HAPPENING SHORTLY AFTER MY CAR WENT OUT OF CPO WARRANTY, WHICH EXPIRED AT 74K. I DIDN'T REALLY PAY THAT MUCH ATTENTION TO IT UNTIL IT GOT WORSE. THIS IS A 06 TDI MKV WITH AUTO DSG, BRM ENGINE. ALSO EXPERIENCING DIFFICULTIES WITH SOOT IN FUEL FILTER, LIKELY DUE TO FAULTY SEAL IN FUEL INJECTORS UNDER CAM SHAFT. ONCE AGAIN, COMMON PROBLEM ACCORDING TO MECHANICS AND ONLINE FORUMS ON THIS MODEL. THERE'S A RECALL ON THE DMF FOR THIS MODEL IN AUSTRALIA, NEEDS TO HAVE ONE FOR US. *TR

DUAL MASS FLYWHEEL FAILED CATASTROPHICALLY AND WITHOUT WARNING WHILE DRIVING ON THE FREEWAY. FLYWHEEL FAILURE SENT METAL SHRAPNEL INTO TRANSMISSION, CRACKING THE BELL HOUSING AND THE TRANSMISSION TO SHIFT ERRATICALLY. THE CAR WAS MECHANICALLY TOTALED AND VOLKSWAGEN OF AMERICA REFUSED TO TAKE ANY RESPONSIBILITY FOR THE PREMATURE FAILURE OF THE VEHICLE, DESPITE IT BEING A DOCUMENTED AND KNOWN ISSUE. OTHERS HAVE REPORTED THAT THIS PART WAS RECALLED IN AUSTRALIA BUT NOT THE UNITED STATES. COST OF REPAIR WAS BEYOND VALUE OF VEHICLE AND CAR WAS DEEMED A TOTAL MECHANICAL LOSS. *TR

OUR JETTA EXPERIENCED A "FALSE NEUTRAL" PROBLEM BACK IN DECEMBER, 2013. (95,000 MILES) I DID SOME RESEARCH AND FOUND THAT IT COULD BE DUE TO A LOW VOLTAGE CONDITION. I CHECKED THE ELECTRICAL SYSTEM AND FOUND THE ALTERNATOR TO BE FAULTY. I REPLACED IT AND KEPT DRIVING THE CAR. EVERYTHING SEEMED FINE UNTIL MID JANUARY, 2014 WHEN WE EXPERIENCED ANOTHER FN EVENT. WE WERE ABLE TO SWITCH THE CAR OFF AND THEN BACK ON AND THE CONDITION WENT AWAY. I CALLED OUR LOCAL VW DEALER AND SCHEDULED AN APPOINTMENT FOR A DIAGNOSTIC. THE RESULTS OF THIS TEST CAME BACK AND THEY SAID WE NEEDED A NEW MECHATRONICS UNIT (THIS CONTROLS THE TRANSMISSION) AT A COST OF $2300.00 I AM FAMILIAR WITH THESE CARS AND ALSO FAMILIAR WITH THE FACT THAT VW HAS ALREADY INVESTIGATED THIS ISSUE IN LATER YEAR CARS. THIS INVESTIGATION (NHTSA ACTION# PE09035) RESULTED IN A RECALL CAMPAIGN (NHTSA# 09V333000) WHERE VW REPLACED DEFECTIVE MECHATRONICS UNITS AND EXTENDED THE WARRANTY ON THE AFFECTED UNITS TO 10YRS/100,000 MILES. LESS THAN 24 HOURS AFTER RECEIVING THIS DIAGNOSIS, THE TRANSMISSION COMPLETELY LOCKED UP WHILE DRIVING DOWN THE ROAD, LUCKILY IT WAS AT AN INTERSECTION AND THE SPEED WAS LESS THAN 15MPH. I HAD THE CAR TOWED BACK TO THE VW DEALER, THE TRANSMISSION MUST NOW BE REPLACED ($6,000.00) I CONTENT THAT THIS IS THE SAME OR NEARLY THE SAME ISSUE ADDRESSED IN THE PREVIOUS CAMPAIGN AND THAT VW DID NOT FIND THE ROOT CAUSE OF THE MECHATRONICS AND SUBSEQUENT TRANSMISSION FAILURE. A NEW INVESTIGATION NEEDS TO BE OPENED TO ADDRESS THIS PROBLEM, IT IS A SAFETY ISSUE WHICH HAS ALREADY BEEN ADDRESSED FOR SOME OF THEIR VEHICLES. VW NEEDS TO BE MADE TO ADDRESS IT FOR ALL DSG EQUIPPED VEHICLES, ESPECIALLY ONES MANUFACTURED BEFORE THE PREVIOUSLY INVESTIGATED LOT. I CONTACTED VWOA AND EVEN THOUGH MY VEHICLE IS STILL WITHIN THE MILEAGE RANGE OF THE WARRANTY EXTENSION THEY WILL NOT OFFER ANY ASSISTANCE IN THE REPAIRS. *TR

PURCHASED THE 2006 VOLKSWAGEN JETTA IN AUGUST 2014 WITH 116,000 MILES. ONE MONTH LATER THE HORN WAS NOT WORKING. UPON DOING AN INTERNET SEARCH, DISCOVERED AN INORDINATE NUMBER OF COMPLAINTS THAT THESE HORNS BECOME INOPERABLE EVEN WITH FEWER MILES. THE PROBLEM COMES WHEN PRESSING THE HORN PAD ON THE STEERING WHEEL, IT DOES NOT MAKE CONTACT TO SOUND THE HORN. THE AIRBAG ASSEMBLY IS LOCATED HERE AS WELL SO I DON'T FEEL IT'S SAFE TO TRY TO REPLACE IT MYSELF. THE QUOTE TO HAVE THIS REPAIRED WAS $900.00. VOLKSWAGEN SHOULD ISSUE A RECALL ON THIS PART IMMEDIATELY! *TR

OUR 2006 JETTA TDI HAD AN AIRBAG FAULT. WE TOOK THE VEHICLE TO A VOLKSWAGEN DEALERSHIP AND THEY TESTED THE AIR CODE AND FOUND OUT THAT THE PASSENGER OCCUPANT DETECTOR MODULE WENT BAD DUE TO A ELECTRICAL MALFUNCTION IN THE CIRCUIT. THE DEALERSHIP WAS NOT ABLE TO SAY IF THE AIRBAGS WERE GOING TO WORK ON NOT IN THE CASE OF A CRASH. VOLKSWAGEN IS REFUSING TO TAKE ANY OWNERSHIP OF KEEPING THEIR VEHICLE SAFE AND COVERING THE COST OF THE PART. I CONTACT VOLKSWAGEN USA AND THEY GAVE THE REASON THEY WILL NOT COVER THE PART BECAUSE I DID NOT HAVE AN EXTENDED WARRANTY. I FEEL THAT VOLKSWAGEN IS BEING NEGLECTFUL TO THEIR CLAIM ON PROVIDING A SAFE VEHICLE. NOW THAT THE AIRBAG SENSOR IS GOING OUT, WE ARE HAVING MORE ELECTRICAL PROBLEMS WITH HEADLIGHTS, PARKING LIGHTS, TAILLIGHTS, BRAKE LIGHTS, DAY TIME RUNNING LIGHTS, AND TURN SIGNALS. *TR