2006 VOLKSWAGEN JETTA Complaints

AFTER USING THE FOB TO LOCK THE DOORS WE NOTICED THE REAR DOORS WOULD NOT LOCK. IF THE CAR IS JUST SITTING THE REAR LOCKS WILL NOT LOCK LEAVING THE DOOR OPEN TO CHILDREN OR WOULD BE THIEVES. WE ALSO NOTICED THE REAR DOORS WOULD SHOW THEY WERE LOCKED ONCE WE WERE MOVING, BUT WERE ACTUALLY UNLOCKED ALLOWING THE REAR PASSENGER TO BE ABLE TO OPEN THE DOORS AT HIGHWAY SPEEDS. EXTREME SAFETY ISSUE! VOLKSWAGEN NEEDS TO ADDRESS THIS ISSUE ASAP. *TR

DURING A HEAVY RAIN, AND WHILE SLOWING TO APPROACH A STOP , MULTIPLE EMERGENCY WARNING LIGHTS APPEARED IN THE DASH DISPLAY. LOW OIL PRESSURE INDICATOR ADVISED TO SHUT OFF ENGINE IMMEDIATELY, GLOW PLUG INDICATOR FLASHED, AND TACHOMETER WENT TO ZERO (EVEN THOUGH ENGINE WAS STILL RUNNING). I SHUT OFF THE ENGINE, CHECKED OIL (LEVEL WAS FINE), BUT THE ENGINE WOULD NOT START. TOWED BACK HOME, AND 30 MINUTES LATER, ENGINE STARTED. NO CHECK ENGINE LIGHT AT ANY TIME. PROBLEM RECURRED AGAIN IN HEAVY RAIN SEVERAL WEEKS LATER. EXAMINED WIRING HARNESS AND FOUND TWENTY INDIVIDUAL WEAR POINTS IN THE WIRES WHERE THE INSULATION WAS WORN ENOUGH TO EXPOSE THE COPPER STRANDS. THERE WERE NUMEROUS OTHER WEAR POINTS WITH NO COPPER VISIBLE, BUT ALL OF THE INSULATION WEAR MATCHED THE CORRUGATION OF THE RIBBING IN THE PLASTIC WIRE LOOM COVERING. CLOSER INSPECTION OF THE WEAR POINTS REVEALED THE MOST PREVALENT AND SERIOUS BARE WIRE CONDITIONS WERE IN THE AREA OF THE HARNESS SUPPORT CLAMPS. VERY CONCERNED REGARDING OTHER SIMILAR POTENTIAL WEAR PROBLEMS THAT COULD RESULT IN ENGINE FAILURE OR FIRE. *TR

BEEN TO MULTIPLE DEALERSHIPS CLAIMING IN FOX VALLEY IL ROCKFORD IL GLENVIEW IL THAT EITHER MY MECHUNIT IS BAD/FAULTY OR DUAL MASS FLYWHEEL IS BAD/FAULTY. WAS DRIVING WHERE EITHER MY CAR WOULD SHIFT VERY ROUGH AS IF SOMEONE WHO IS VERY INEXPERIENCED WOULD LET GO OF THE CLUTCH LATE AND SHIFT HARD/ROUGH INTO 1-2-3 WITH CLICKING NOISES. CAR JUST RECENTLY SHIFTED FROM 2 TO NEUTRAL AND SCARED THE CRAPOUT OF ME. THE CAR HAS EXTREME VIBRATION AND UNCONTROLLED SHIFT PATTERNS. WAS TURNING ONTO MY STREET AND CAR WENT FROM 3-2 TO NEUTRAL WHILE MY CAR WAS STILL IN DRIVE AND WENT INTO A SNOW BANK ON SIDE OF ROAD. WOULD JUST LIKE TO HAVE VOLKSWAGEN CONTACT ME TO EITHER REPLACE OR FIX THIS PROBLEM. THIS IS VERY DANGEROUS OWNERS OF A 2006 VW TDI OR ANY AUTOMATIC WITH DSG MECHUNIT BEWARE AND PLEASE BE CAREFUL. *TR

TRAVELING ALONG AT 55 MPH AND THE GEAR DISPLAY STARTED FLASHING/BLINKING AS THE CAR JUST SHUT OFF. IT WOULD NOT RESTART. BATTERY IS FINE. *TR

WHILE DRIVING HOME WITH MY WIFE, SHE STATED THAT SHE THOUGHT SHE HAD NOTICED A BURNING SMELL. THE HEATED SEATS WERE ON AS IT WAS A COLD MORNING. THE NEXT DAY I NOTICED THAT THE BACK REST OF THE SEAT HAD A SMOLDERING MARK AS WELL AS SOME SORT OF SMOKE DAMAGE AS IF THERE WAS A FIRE ON THE INSIDE OF THE SEAT. WE LATER LOOKED ON HER JACKET AND NOTICED THAT THERE WAS TRANSFER OF THE "LEATHER" TO HER JACKET. *TR

I AM THE OWNER OF A 2006 VW JETTA TDI SEDAN. I PURCHASED THE VEHICLE USED IN A PRIVATE SALE IN 2009. BY 2011 I WAS HAVING NUMEROUS PROBLEMS WITH THE VEHICLE. THE DUAL MASS FLYWHEEL FAILED JUST AFTER I HAD MY CAR AT THE DEALERSHIP FOR THE TIMING BELT SERVICE (APPROXIMATE MILEAGE 106,000). I HAD TO HAVE IT TOWED (AT MY EXPENSE) TO THE DEALERSHIP SINCE IT WASN'T SAFE TO DRIVE THE 130 MILES. DEALERSHIP SAID IT WAS A KNOWN PROBLEM BUT VOLKSWAGEN OF AMERICA HAS NOT OFFERED ANY ASSISTANCE. APPARENTLY SOMEONE HAS TO DIE TO GET THEIR ATTENTION. APPROXIMATE COST OF REPAIRS: $1,800. 2ND BIG PROBLEM IS ELECTRICAL. WIRING HARNESS IN THE DRIVER DOOR FAILED SOON AFTER I PURCHASED IT. IT STARTED WITH THE DRIVER WINDOW SWITCH NOT WORKING. THEN THE LOCK/UNLOCK BUTTON QUIT WORKING. THEN THE INTERIOR/EXTERIOR SAFETY LIGHTS. I HAVE HEARD THAT IT WILL PROGRESS TO THE TRUNK LID, THE OTHER WINDOWS, THE FUEL DOOR, ECT. ONCE AGAIN AN EXTREMELY COMMON PROBLEM DUE TO A POOR DESIGN. ONCE AGAIN VOLKSWAGEN OF AMERICA HAS REFUSED TO OFFER ASSISTANCE - THE DEALERSHIP QUOTED ME JUST UNDER $500 IN PARTS AND LABOR. WHY WOULD A HARNESS COST $205!!! THIRD PROBLEM IS COSMETIC ISSUES. THE PAINT IS FLAKING OFF ESPECIALLY NEAR THE SEAMS AND AT THE WHEEL WHEELS. RUST FORMED WHERE THE PAINT BUBBLED UP AT TWO OF THE FOUR WHEEL WHEELS. THERE IS A SERVICE BULLETIN FOR PAINT PROBLEMS IN THE GENERATION BEFORE THIS VEHICLE AND A 10-12 YEAR CORROSION WARRANTY THAT VW REFUSES TO HONOR. ADDITIONALLY, PROBLEMS WITH POOR MANUFACTURING PRACTICES AND MATERIALS ABOUND IN THIS VEHICLE. THE HEADLINER PULLS AWAY FROM THE PILLARS AT THE SEAMS IN THE REAR DUE TO DEFECTIVE MATERIALS. IT WILL SEPARATE FROM THE ROOF AND BECOME A HANGING VISIBILITY HAZARD. THE PLASTIC DASH PIECES DON'T FIT TOGETHER - SHRINKING AND PULLING AWAY AT THE SEAMS. STEREO BUTTONS (AS WELL AS DOOR SWITCHES) BUBBLE AND FLAKE OFF. *TR

VW IS VERY MUCH AWARE OF THE DEFECT REGARDING CAMSHAFT FAILURE IN THE ENGINE, RESULTING IN HIGH REPAIR COSTS AND DANGEROUS LOSS OF POWER THAT COULD RESULT IN A COLLISION. VW SOUTHTOWNE IN UTAH CALLED THE ENGINE "EXPERIMENTAL" BASICALLY ADMITTED THAT VW KNEW THERE WAS A PROBLEM AND ONLY BUILT THE ENGINE FOR 1.5 YEARS AS A RESULT. THEY ONLY RESPOND THAT THE CAR IS OUT OF WARRANTY AND IS THE CONSUMERS PROBLEM TO PAY FOR A $4000 REPAIR ONTO OF PAYING FOR THE LOAN ON THE CAR. *TR

I HAVE RUN INTO NUMEROUS ISSUES ON MY CAR THAT HAVE CAUSED ME TO TROUBLESHOOT AND SOLVE THESE PROBLEMS. MULTIPLE TIMES I HAVE PULLED BACK THE ABRASION PROTECTION ON THE WIRING AND FOUND THAT THE INSULATION COMMON TO THE WIRES IS CRACK OR WORN OFF EXPOSING THE CENTER CONDUCTOR OF THE WIRES. MANY TIMES THERE ARE NUMEROUS WIRES WITHIN A HARNESS THAT ARE WORN THROUGH. SO FAR I HAVEN'T FOUND ANY THAT ARE SHORTED OUT BUT MANY ARE VERY CLOSE AND AT HIGH RISK OF CAUSING AN ELECTRICAL SHORT/FIRE. I AM AN AIRCRAFT ELECTRICIAN/INSPECTOR AND HAVE FOUND THE ABRASION PROTECTION TO BE HORRIBLE INADEQUATE. THERE ARE 2 HARNESSES THAT GO TO THE TURBO THAT HAVE A HARD PLASTIC ABRASION COVER BUT NOTHING SHIELDING THE WIRE FROM THIS COVER. ON BOTH OF THESE HARNESSES I FOUND THAT THE PLASTIC HAD WORN A SERIES OF RIDGES DOWN THE ENTIRE LENGTH OF WIRE THEY COVERED AND EXPOSED THE CONDUCTOR IN MULTIPLE PLACES. MY RIGHT HAND MIRROR TURN SIGNAL WAS NOT WORKING SO I PULLED IT OUT AND TESTED THE BULB AND FOUND THAT IT WAS GOOD. WHEN I PULLED THE RUBBER BOOT THAT COVERS THE WIRES IN THE DOOR JAM I FOUND A POWER WIRE IN THERE THAT THE INSULATION HAD CRACKED AND PULLED APART EXPOSING .150" OF CENTER CONDUCTOR IN MULTIPLE PLACES. IT SEEMS THAT THE MAJORITY OF THE WIRING IS EITHER POOR QUALITY OR JUST NOT PROTECTED CAUSING THE INSULATION TO FAIL AND BECOME A MAJOR SAFETY HAZARD FOR POTENTIAL ELECTRICAL SHORTS OR FIRES. I HAVE HEARD THESE CARS ARE PRONE TO ELECTRICAL CAUSED FIRES AND STRONGLY BELIEVE THAT SOMETHING NEEDS TO BE DONE IN ORDER TO AVOID MORE VERY SERIOUS PROBLEMS WITH THESE CARS THAT COULD COST SOMEONE THEIR LIFE. I HAVE ONLY OWNED THIS CAR SINCE MAY OF 2013 AND HAVE ALREADY REPAIRED 4 WIRING HARNESSES THROUGHOUT THE CAR. THIS IS SOMETHING THAT SHOULD NEVER HAPPEN ON A CAR THAT IS ONLY 7 YEARS OLD. *TR

AT MY CARS 20K SERVICE THE DEALER INDICATED THAT THE BRAKES NEEDED REPLACEMENT. AT THE 50K THEY NEEDED TO BE REPLACED AGAIN. WEAR THIS RAPID IS DISCONCERTING AND DANGEROUS. HAD I NOT TAKEN MY CAR IN FOR REGULAR SERVICE THIS COULD HAVE LEAD TO A SERIOUS ISSUE. I DO NOT USE MY BRAKES HEAVILY. MOST OF MY DRIVING IS NON-HIGHWAY DRIVING, MOSTLY JUST TRAFFIC LIGHT TO TRAFFIC LIGHT. I CONSISTENTLY USE THE PARKING BRAKE WHEN PARKING. *TR

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, SHE BEGAN TO SMELL GASOLINE INSIDE THE VEHICLE. THE CONTACT OPENED THE HOOD AND SAW THAT GASOLINE WAS LEAKING ONTO THE ENGINE. THE CONTACT WAS INFORMED OF A RECALL FOR THE FAILURE UNDER NHTSA CAMPAIGN NUMBER: 10V621000 (FUEL SYSTEM, GASOLINE) BUT WAS INFORMED THAT HER VIN WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 90,000.