2006 VOLKSWAGEN JETTA Complaints

VOLKSWAGON HAS A PROBLEM WITH A FAULTY DUAL MASS FLYWHEELS,THE SPRINGS BREAK INSIDE THE FLYWHEEL YOU HEAR A RATTLE WHEN THE CAR IS AT IDLE AND THE GOES AWAY WHEN IN GEAR.FROM READING ABOUT THIS PROBLEM I FINALLY FOUD OUT WHAT THIS NOISE IS.I HAVE ASKED THE SERVICE TECH TO SEE IF ANYTHING IS LOOSE AND THEY ALWAYS COME UP EMPTY.I FINALLY READ ABOUT THIS ON THE VW TDI FORUMS ONLINE.THEY SAID VW RECALLED THIS PROBLEM IN AUSTRAILIA BUT NOT IN THE UNITED STATES.I HAVE CALLED VW CUSTOMER LINE BUT ALL THE TELL ME IS WE HAVE NOT ISSUED A RECALL ON THIS PROBLEM SO THEY CAN'T HELP ME.ONE OF THE SPRINGS ALREADY BROKE A HOLE IN THE COVER FOR THE TRANSMISSION. I HOPE YOU CAN HELP! *TT

#1 JULY 262013 JETTA SEDAN 2.5L AUTOMATIC TRANSMISSION 87,850 MILES A D V E R T I S E M E N T S I RECENTLY PURCHASED A USED 2006 VW JETTA WITH A DSG TRANSMISSION AND 2.5 L MOTOR. THE VEHICLE LURCHES AND LOSES POWER AS IF GAS HAD BEEN SWITCHED OFF OR THE TRANSMISSION HAS BOGGED DOWN AND SEEMS TO OCCUR WHEN SHIFTING. IT ALSO HAPPENS FROM A DEAD STOP, WITH THE VEHICLE LURCHING FORWARD WITH CONSIDERABLE FORCE WHEN THE TRANSMISSION ENGAGES. THIS HAS OCCURRED ON BOTH VERY HOT DAYS, 100+ DEGREES, AND ALSO DURING EVENING AND NIGHTTIME WHILE DRIVING ON SURFACE STREETS AND ON THE INTERSTATE THOUGH ON THE INTERSTATE IT DOESN'T LURCH FORWARD WHEN POWER IS RESTORED. THE VEHICLE USUALLY REGAINS POWER 3-5 SECONDS AFTER LOSS OF POWER MOST TIMES THIS OCCURS BUT THERE WERE A FEW TIMES THE VEHICLE STALLED. ONCE THIS HAPPENS THIS CONDITION CONTINUES TO OCCUR MORE WITH INCREASING FREQUENCY UNTIL THE VEHICLE IS NOT DRIVABLE. ONCE THE VEHICLE HAS COOLED OFF FOR A PERIOD OF TIME, 2 OR MORE HOURS, IT DRIVES WITH OUT THIS PROBLEM FOR THE SAME AMOUNT OF TIME, OR LESS, AS WHEN DRIVEN FROM A COLD START. THIS HAS ALSO OCCURRED WHILE PASSING AND FORCED ME TO CANCEL MY PASS OF A SLOWER MOVING VEHICLE AND MERGE INTO THE TRAFFIC WHICH ON ONE OCCASION HAD CLOSED RANKS LEAVING ME NO ROOM TO MERGE. I HAVE ONLY BEEN DRIVING THIS VEHICLE FOR ABOUT A WEEK. THIS STATEMENT WAS POSTED AROUND 8-5-2013. THE PROBLEM IS STILL THE SAME. *TR

A RATTLING SOUND BEGAN TO COME FROM THE ENGINE COMPARTMENT SHORTLY AFTER PASSING 85,000 MILES ON THE VEHICLE. SCANNED THE COMPUTER AND FOUND SEVERAL CODES FOR MISFIRES AND VACUUM LEAKS ON THE VEHICLE ECU. TOOK IT TO A SHOP AFTER PERFORMING ROUTINE MAINTENANCE DID NOTHING TO SMOOTH OUT ENGINE OPERATION. SHOP SHORTLY CONTACTED ME BACK WITH A QUOTE OF THE TIMING CHAINS WERE COMING APART AND THE ENGINE WAS SEVERELY OUT OF TIME. AFTER SOME RESEARCH ONLINE THIS APPEARS TO BE AN ISSUE WITH THE EARLY 2.5L MK5 JETTA ENGINE. *TR

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE HEADLINER UPHOLSTERY NEAR THE REAR WINDOW WAS SPLITTING. THE VEHICLE WAS TAKEN TO AN UPHOLSTERY CENTER WHERE THEY ADVISED HER THAT THE ENTIRE UPHOLSTERY WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 57,000.

ALL ELECTRONIC COMPONENTS IN DRIVERS DOOR CEASED TO FUNCTION. AUTO DOOR LOCK, DRIVER'S WINDOW, GAS LATCH. COULD NOT OPEN DRIVER'S WINDOW. APPARENTLY THE ORIGINAL DESIGN OF WIRE HARNESS WAS DEFECTIVE IN THAT IT WAS 80 MM TOO SHORT. VW HAS ISSUE A TECHNICAL SERVICE BULLETIN ON APRIL 20, 2011 (V97-11-04) IDENTIFYING THIS INHERENT DEFECT. DEALER REPLACED DRIVER'S DOOR WIRING HARNESS AFTER DIAGNOSING MULTIPLE BROKEN WIRES. VW WILL NOT REIMBURSE CAR OWNERS FOR REPAIR/REPLACEMENT. *TR

IN THE MORNING I WENT TO START MY CAR AND I SHIFTED IT INTO REVERSE AND THERE WAS A LOUD NOISE. I THEN WENT TO DRIVE IT AND THE TRANSMISSION WOULD NOT SHIFT OUT OF THIRD GEAR. *TR

I WAS ACCELERATING FROM A STOP SIGN AND I HEARD A NOTIFICATION "BEEP" ON MY CAR'S DASHBOARD. I LOOKED DOWN TO SEE WHAT WAS WRONG AND SUDDENLY MY STEERING LOCKED UP ON ME. HAVING NO CONTROL OF MY CAR, I DRIFTED INTO A CAR PARKED ON THE RIGHT SIDE OF THE STREET, CAUSING MY CAR TO FLIP OVER. *TR

I SWERVED TO MISS AN ANIMAL AND RAN OFF THE ROAD AT 55MPH AND HIT A TREE HEAD ON AND THE DRIVER AIRBAG NEVER DEPLOYED. SPOKE TO VW CUSTOMER CARE AND WAS TOLD THAT THEIR ENGINEERS LOOKED AT THE PHOTOS NOT THE ACTUAL CAR AND DETERMINED THAT THEY FUNCTIONED PROPERLY. I SAID I THOUGHT THEY WERE SPEED RATED AND WAS TOLD THAT II COULD HIT A WALL AT 100MPH AND THE AIRBAG MIGHT NOT GO OFF. ARE YOU KIDDING ME!!! *TR

THE VEHICLE STALLS WHENEVER DRIVING IN WET CONDITIONS ON THE HWY WHILE SNOWING OR RAINING. I HAVE LOST CONTROL OF THE VEHICLE AND HAVE BROKEN DOWN ON THE SIDE OF THE ROAD WITH NO SHOULDER AND FACING AN UPHILL INCLINE. ON EACH OCCASION I HAVE HAD MY CHILDREN IN THE VEHICLE WITH ME AND FACING HEAVY TRAFFIC IN BOTH DIRECTIONS. I WAS FORTUNATE TO HAVE A HIGHWAY PATROL OFFICER ASSIST ME IN PUSHING THE CAR TO OFF THE HIGHWAY THE LAST 3 TIMES. EACH TIME, THEY INFORMED ME THAT I SHOULD CONTACT VOLKSWAGEN AND LET THEM KNOW BECAUSE IT SHOULD DEFINITELY BE A FACTORY RECALL BASED ON THE DANGEROUS CIRCUMSTANCES. THE PROBLEM HAS BEEN IDENTIFIED ON TDI FORUMS HTTP://FORUMS.TDICLUB.COM/SHOWTHREAD.PHP?T=239987&PAGE=6 AS A WIRE CHAFING CONDITION CAUSED BY THE VIBRATION OF THE DIESEL ENGINE. I TOOK MY VEHICLE TO THE REPAIR SHOP 3 DIFFERENT TIMES AND THEY WERE UNABLE TO IDENTIFY THE PROBLEM BECAUSE EACH TIME I WAS ABLE TO GET THE VEHICLE TO THE SHOP THEY WERE UNABLE TO MATCH THE DRIVING CONDITIONS THAT I WAS DRIVING IN AND EACH TIME I WAS ABLE TO START THE VEHICLE AFTER ALLOWING THE VEHICLE TO SIT FOR A PERIOD OF TIME IN ORDER TO ALLOW THE ENGINE COMPARTMENT TO DRY. *TR

ENTIRE CAMSHAFT HAS TO BE REPLACED, CAR IS INOPERABLE. THIS IS APPARENTLY A KNOWN ISSUE BUT VW OF AMERICA WILL NOT ACKNOWLEDGE THIS OR HELP WITH THE REPLACEMENT COST, WHICH IS SUBSTANTIAL. *TR