2005 VOLKSWAGEN JETTA Complaints

ON FEBRUARY 16TH WHILE RUNNING ERRANDS I PULLED THROUGH A DRIVE THROUGH FOR LUNCH, CAR WAS RUNNING AND SOUNDED JUST FINE, AFTER PULLING AWAY I HEARD A LOUD "SHRIEKING" NOISE AND THEN A CLUNK, THE CAR LOST POWER AND MADE A GRINDING NOISE, I IMMEDIATELY PULLED INTO THE ADJACENT PARKING LOT AND SHUT THE CAR OFF, I WAITED A FEW MINUTES THEN RESTARTED THE CAR IT STARTED JUST FINE BUT SEEMED TO BE IDLING A LITTLE ROUGH, I SHIFTED CAR INTO DRIVE AND LIGHTLY PRESSED THE ACCELERATOR THE GRINDING NOISE WAS PRESENT SO I PUT THE CAR BACK IN PARK AND SHUT OFF THE ENGINE, CALLED AAA AND HAD THE CAR TOWED TO THE DEALERSHIP. THE DEALERSHIP THEN CALLED ME LATER THAT AFTERNOON AND INFORMED ME THAT THE DUAL MASS FLYWHEEL HAD SEPARATED AND WOULD NEED TO BE REPLACED, THEY QUOTED ME $1800 FOR THE REPAIR. I WAS INFORMED THAT THEY HAD THE PART IN STOCK AND I APPROVED THE REPAIR. THE CAR JUST HAD 64,381 MILES AND I THOUGH IT WAS ODD THAT THIS FAILURE OCCURRED, I DID SOME RESEARCH ON THE INTERNET AND DISCOVERED THAT THIS IS A "KNOWN" FAILURE. SINCE THE WARRANTY "JUST" EXPIRED I HAD TO PAY FOR THE REPAIR. I CONTACTED VW0FA AND THEY TOOK THE INFORMATION BUT DID STATE THE WARRANTY EXPIRED, I UNDERSTAND THAT BUT IT APPEARS THAT THIS ISSUE HAS BEEN REPORTED NUMEROUS TIMES AND THIS NEEDS TO BE INVESTIGATED! I HAD JUST EXITED THE INTERSTATE BEFORE THIS HAPPENED, WHAT WOULD HAVE BEEN THE OUTCOME IF I STAYED ON THE FREEWAY AT 60MPH AND THIS COMPONENT FAILED?*TR

MY 2005 VOLKSWAGEN JETTA'S LEFT REAR BRAKE HAS WORN METAL TO METAL APPROXIMATELY EVERY 10,000 MILES. THIS VEHICLE HAS REQUIRED 5 BRAKE JOBS TO INCLUDE BRAKES, ROTORS, AND CALIPERS. *TR

TL*THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. IN APRIL OF 2007, THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 07V063000 (EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH). THE VEHICLE WAS REPAIRED AT THAT TIME. APPROXIMATELY A YEAR AND A HALF LATER, THE BRAKE LIGHT SWITCH BEGAN TO FAIL AGAIN. WHEN THE BRAKE PEDAL WAS DEPRESSED, THE BRAKE LIGHT SWITCH WOULD NOT STOP ILLUMINATING ON THE INSTRUMENT PANEL AND THE VEHICLE WOULD NOT SHIFT GEARS. THE VEHICLE WAS TURNED OFF APPROXIMATELY THREE TIMES AND, FINALLY, THE BRAKE LIGHT DIMMED AND THE VEHICLE BECAME MOBILE. THE FAILURE OCCURRED INTERMITTENTLY FOR ONE MONTH AND THE CONTACT CALLED THE DEALER. SHE WAS INFORMED THAT THE BRAKE LIGHT SWITCH WAS DEFECTIVE. THE MANUFACTURER STATED THAT SINCE THE FAILURE OCCURRED MORE THAN TWELVE MONTHS LATER, THEY WERE NOT LIABLE FOR THE REPAIRS. THE CURRENT MILEAGE WAS 71,707 AND FAILURE MILEAGE WAS 71,207. UPDATED 03-09-09 *BF THE SHIFTER WOULD NOT COME OUT OF PARK. THE FUEL PUMP WAS NOISEY AND WHICH WAS REPLACED BY THE DEALER. UPDATED 03/12/09.*JB

2005 VW JETTA CLUTCH FAILURE AT 26K MILES. THERE IS NO WEAR AND TEAR ON THE VEHICLE, BUT MY CLUTCH WENT OUT WHILE DRIVING DOWN HIGHWAY. WITH CAR DISABLED, THIS CAN CAUSE AN ACCIDENT. VW WON'T COVER THIS UNDER WARRANTY BECAUSE THEY DEEM THE CLUTCH AS A NORMAL WEAR AND TEAR ITEM. I HAVE READ NUMEROUS DISCUSSION BOARDS WHERE PEOPLE HAVE HAD THE SAME ISSUE. IT'S TIME FOR A RECALL OF THESE DEFECTIVE CLUTCHES. THEY ARE NOT GOING OUT BECAUSE OF NORMAL WEAR AND TEAR. DEFECTIVE CLUTCHES WERE MADE AND PUT IN THESE CARS AND VW IS MAKING CUSTOMERS PAY FOR THEIR MISTAKES. IF I HAD BEEN IN A REMOTE LOCATION, I COULD'VE BEEN STRANDED ON THE SIDE OF THE ROAD FOR HOURS AND COULD'VE BEEN STRUCK BY ANOTHER VEHICLE. ALSO, WITH THE CLUTCH NOT WORKING, IF I HAD BEEN DRIVING FAST, WHEN I APPLIED THE BREAKS, IT COULD'VE JERKED TO A HALT AND I COULD'VE LOST CONTROL OF VEHICLE. THIS IS NOT ACCEPTABLE. *TR

ON THE NIGHT OF 25 DEC 2008 MY VEHICLE STALLED IN THE MIDDLE OF AN INTERSECTION. THE VEHICLE WOULD NOT START BACK UP, THE IGNITION WAS CYCLED SEVERAL TIMES AND ASSISTANCE WAS REQUIRED TO GET THE VEHICLE OUT OF THE INTERSECTION TO A SAFE LOCATION. THE NEXT MORNING THE VEHICLE STARTED WITH NO ISSUES. IT WAS ADVISED THAT THE FUEL FILTER BE REPLACED AND THAT WAS DONE IMMEDIATELY ON THE MORNING ON 26 DEC 2008. THE SAME EVENING THE VEHICLE STALLED ONCE MORE IN THE MIDDLE OF A MAIN ROAD. IT IS FORTUNATE THAT THE VEHICLE WAS ON A DECLINE AND TRAFFIC WAS MOVING RATHER SLOW WHICH ALLOWED THE VEHICLE TO COAST TO A SAFE TURN-OFF POINT. THREE HOURS LATER THE VEHICLE WAS ABLE TO START ONCE MORE AND MADE IT TO A SAFE LOCATION WHERE THE FUEL PUMP (AKA IN TANK LIFT PUMP) COULD THEN BE REPLACED. A NEW FUEL PUMP WAS ORDERED AND REPLACED ON 29 DEC 2008 AND THE OLD PUMP WAS TESTED AND DEEMED TO HAVE FAILED. THERE WERE NO WARNING SIGNS OF FAILURE, NO ERROR CODES PRODUCED BY THE VEHICLE AND NO MEANS OF SAFELY BEING ABLE TO MOVE THE VEHICLE AFTER IT STALLED. THE VEHICLE HAS BEEN OPERATING WITH THE NEW FUEL PUMP WITHOUT INCIDENT. *TR

MY FUEL PUMP FAILED WITH NO WARNING, LEAVING MY WIFE STRANDED IN WINTER. THIS HAPPENED WITH NO WARNING WHATSOEVER - THE CAR WAS RUNNING PERFECTLY, AND THEN STALLED. THIS IS A COMMON PROBLEM ON THIS MODEL CAR. *TR

REAR BRAKES ON 2005 VW JETTA - METAL ON METAL AFTER 19K AND 38K MILES. TOLD BY VW THAT IT IS DUE TO A SMALLER BRAKE PAD ON THE REAR. FEAR THAT A SMALLER BRAKE PEDAL WEARS FASTER AND IS THUS A SAFETY ISSUE. *TR

OVER THE PAST 11 MONTHS OF OWNING MY VEHICLE, I HAVE HAD TO REPLACE THE HEADLIGHTS (LIGHTBULB ONLY) SEVEN TIMES. ALSO, OTHER VARIOUS BRAKE AND RUNNING LIGHTS HAVE GONE OUT. THE FIRST TIME, I HAD THE VEHICLE FOR 1 DAY OFF THE LOT (USED). THE FIX IS OBVIOUSLY GOING TO PURCHASE NEW HEADLIGHTS. I'VE TRIED HIGH QUALITY SYLVANIA H7 LIGHTS, AND ALSO TESTED THE LOWER QUALITY TO SEE IF IT WOULD LAST LONGER, OR HOLD OUT AT ALL. VW (VIA A DEALERSHIP, NOT CORPORATE) HAS INDICATED THAT IT COULD BE AN ELECTRICAL PROBLEM, A SEAL IN THE HEADLIGHT ASSEMBLY, OR THE OBVIOUS POOR VENTILATION TO RELIEVE THE HEAT BUILD-UP. THERE IS A PLASTIC CAP INSIDE THE ENGINE COMPARTMENT ON EACH HEADLIGHT THAT IS REQUIRED TO BE REMOVED TO ACCESS THE SOCKETS. IT DOES GET VERY HOT IN THERE. VW DID INDICATE THIS IS A COMMON PROBLEM, BUT DOES NOT COVER BULB REPLACEMENT UNDER WARRANTY, AS FREQUENT OR INFREQUENT AS IT MIGHT HAPPEN. ON A SEPARATE NOTE, AUTOZONE (LOCAL PARTS DISTRIBUTOR) HAS MADE COMMENTS INDICATING THE TYPE OF BULB (H7) IS OF POOR DESIGN ON ANY VEHICLE. ANOTHER ACQUAINTANCE HAS ADVISED ME ON HER VW, THERE ARE SIMILAR LIGHTING ISSUES. I AM SEEKING A RESOLVE, AS THE LIGHTS ARE RATHER EXPENSIVE ALONE, AND LETTING THE DEALERSHIP FIX THEM EXTREMELY COSTLY. THE INCIDENT DATE LISTED WAS THE FIRST TIME IT OCCURRED TO MY VEHICLE, AND THE LAST TIME WAS 2 WEEKS AGO. TO NOTE, THE HEADLIGHT USUALLY BLOWS OUT WHEN I START THE VEHICLE, NOT WHEN IT'S RUNNING. THE HEADLIGHTS ARE ALWAYS ON, DAYTIME RUNNING LIGHTS. I AM EXTREMELY CAUTIOUS AS TO NOT TOUCH THE BULB DIRECTLY, AS I KNOW THIS TO CAUSE DAMAGE. *TR

MY TRUNK HAS NEVER CLOSED PROPERLY FROM THE DAY I DROVE IT OFF THE LOT. I TOOK THE VEHICLE BACK WITHIN A FEW WEEKS TO BE REPAIRED. THEY DID NOT HAVE THE PART AND IT TOOK A FEW MORE WEEKS. WHEN THEY REPLACED IT, IT STILL CONTINUED NOT TO CLOSE PROPERLY. I HAVE THE OLD PART. I ALSO RECENTLY HAD AN AIR BAG DEFAULT SENSOR COME ON. I HAVE CONTACTED THEM MULTIPLE TIMES REGARDING THIS AND THEY CONTINUE TO ADVISE THAT THEY WILL HAVE TO CHARGE ME A DIAGNOSIS OF 97.50 AND I WILL HAVE TO PAY FOR A RENTAL IF THIS IS NOT COVERED UNDER WARRANTY. I HAVE CONTINUOUSLY HAD PROBLEMS WITH THIS SERVICE DEPARTMENT. I HAVE TRIED TO DROP THE VEHICLE OFF AND THEY INSIST THAT THEY DO NOT HAVE ROOM AND WILL NOT BE ABLE TO GET TO MY VEHICLE FOR SEVERAL DAYS. THESE ARE VERY SERIOUS HAZARDS THAT COULD BE LIFE THREATENING YET THEY FAIL TO RECOGNIZE THE IMPORTANCE OF THEIR CUSTOMER. *TR

I OWN A 2005 VW JETTA TDI. AT APPROX. 60,000 MILES THE CHECK ENGINE LIGHT CAME ON AND I HAVE REPLACED THE SAME FLAP MOTOR 3 TIMES AND IT HAS FAILED AGAIN. I HAVE ALSO CHANGED THE THERMOSTAT, COOLING KIT, SENSOR, AND IT COMES BACK AS A FLAP MOTOR FAILURE. HAS VW HAD A PROBLEM WITH INTAKE FLAP MOTORS ON THE TURBO DIESEL MOTORS?. VW WILL NOT DO ANYTHING TO HELP WITH THIS SITUATION. *TR