2006 VOLKSWAGEN JETTA Complaints

THE DRIVER'S SIDE WINDOW IN MY VEHICLE STOPPED WORKING COMPLETELY. WHEN I TOOK THE VEHICLE TO THE DEALER THEY TOLD ME THE CAUSE WAS A FAULTY DRIVER'S SIDE DOOR HARNESS. THERE WERE SEVERAL WIRES THAT WERE BROKEN OR ABOUT TO BREAK, AND THEY SUGGESTED I REPLACE IT IMMEDIATELY. I WAS QUOTED OVER $400 FOR PARTS AND LABOR. THIS ISSUE WAS RECALLED ON THE EARLIER MODELS, AND THEN FIXED ON THE 2008 AND LATER MODELS DURING PRODUCTION. HOWEVER THE 2006 AND 2007 MODELS ARE STILL AFFECTED BY THE PROBLEM. VOLKSWAGEN HAS NOT ISSUED A RECALL FOR THIS CRUCIAL PART AND CONTINUES TO LET ITS CUSTOMERS PAY FOR THE DANGEROUS DESIGN FLAW IN THESE VEHICLES. WARNING TO POTENTIAL BUYERS: BEFORE PURCHASING A 2005.5 (NEWER BODY STYLE), 2006, OR 2007 JETTA CHECK TO MAKE SURE THIS PROBLEM HAS BEEN FIXED. OTHERWISE, YOU COULD WIND UP WITH YOUR POWER WINDOWS, LOCKS, MIRRORS, GAS DOOR, AND TRUNK RELEASE NO LONGER WORKING WHEN YOU NEED THEM TO. ALSO, I WAS TOLD THE VEHICLE WOULD NOT PASS INSPECTION WITH THIS PROBLEM. IT IS A RISK AND A SAFETY CONCERN THAT SHOULD BE RECALLED IMMEDIATELY. *TR

AT 130,623 MILES OUR JETTA HAD TO HAVE THE CAMSHAFT AND LIFTERS REPLACED. THE LOBES ON THE CAMSHAFT HAD COMPLETELY WORN OFF AND THE LIFTERS HAD PITTED. I FEEL LIKE OUR DIESEL MOTOR HAS AGED PREMATURELY AND THERE IS AN UNDERLYING PROBLEM THAT VW IS IGNORING. THIS IS A COMMON PROBLEM FOR THIS MODEL AND YEAR. WE ARE HAVING BOTH REPLACED, BUT UNTIL THE ROOT OF THE PROBLEM IS FOUND THERE WILL BE AN ISSUE AGAIN. VW MUST KNOW OF THIS PROBLEM. THEY STOPPED PRODUCTION OF THE TDI JETTA IN 2006. THE 2006 WAS THE LAST YEAR BEFORE STOPPING PRODUCTION. WHY WOULD THEY STOP MAKING A CAR THAT WAS IN SUCH HIGH DEMAND WITH THE RISING COST OF DIESEL AND GAS. THEY KNEW OF AN ISSUE IN THE CAR THAT THEY COULDN'T FIGURE OUT. NOW THEY IGNORE THE PROBLEM AND CONTINUE TO BLAME THE CUSTOMER FOR POOR MAINTENANCE. THE CAR IS DEFECTIVE AND VW NEEDS TO ADDRESS THE PROBLEM. *TR

MAY 2011 VEHICLE WAS TAKEN TO CASEY IMPORTS (CASEY VOLKSWAGEN) 777 J. CLYDE MORRIS BLVD NEWPORT NEWS VA 23608 (757)988-1236 IN REGARDS TO SERVICE ACTION 97U3/T3 DATED JANUARY 2011. ---FAILURE WAS DRIVER'S SIDE AIRBAG CONNECTOR RESULTING IN ILLUMINATED AIRBAG LIGHT IN INSTRUMENT CLUSTER. CASEY VW PROCEEDED TO REPLACE THE CONNECTOR ON THE DRIVER'S SIDE BUT ONLY "INSPECTED" THE PASSENGER SIDE WITH NO REPAIR ACTION PERFORMED. THE INSTRUCTIONS CLEARLY STATE ON PAGE 6: PERFORM PROCEDURE ON BOTH FRONT SEATS. RECALL WAS ENTERED INTO VOLKSWAGEN'S ELSAWEB AS COMPLETED EVEN THOUGH THE REPAIR PAPERWORK CLEARLY STATES ONLY HALF OF THE WORK WAS PERFORMED. JULY 2012 VEHICLE WAS TAKEN TO CASEY VW WITH AIRBAG LIGHT ILLUMINATED. ---FAILURE WAS PASSENGER SIDE AIRBAG CIRCUIT HIGH RESISTANCE. I WAS TOLD I WOULD NEED TO AUTHORIZE A $120 DIAGNOSTIC FEE BEFORE ANYTHING WAS DONE AND THAT THE RECALL WAS PERFORMED. I INFORMED [XXX] (SERVICE ADVISOR) REGIONAL SERVICE MANAGER [XXX]AND CASEY SERVICE MANAGER [XXX] THAT I DID NOT WANT ANYTHING DIAGNOSED OR REPAIRED. I MADE IT PERFECTLY CLEAR THAT I WANTED THE RECALL PERFORMED IN IT'S ENTIRETY. I CALLED VWOAMERICA AT 1-800-893-5298 TWICE. THE SECOND TIME I RECORDED WITH PERMISSION A CUSTOMER SERVICE REPRESENTATIVE BY THE NAME OF[XXX]. THE ONLY ANSWER I HAVE BEEN GIVEN IS TO AUTHORIZE A DIAGNOSTIC FEE. I BELIEVE THIS CONSTITUTES NEGLIGENCE ON VW AND CASEY IMPORTS FOR NOT ONLY IMPROPERLY PERFORMING A SAFETY RECALL BUT FAILING TO ADDRESS AND CORRECT THE ISSUE WHEN IT IS WAS BROUGHT TO THEIR ATTENTION. THIS TYPE OF SERVICE SHOULD BE INVESTIGATED TO SEE HOW MANY OF CASEY IMPORTS CUSTOMERS MAY STILL BE AT RISK. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*TR

I WAS SITTING IN TRAFFIC IN MINNEAPOLIS MN. THE LIGHT TURNED GREEN, TRAFFIC MOVED AND WHEN I PRESSED ON THE ACCELERATOR, THE ENGINE SPED UP AS IF IT WAS IN NEUTRAL. THE SHIFT SELECTOR WAS IN D FOR DRIVE. THE PRNDL INDICATOR ON THE DASH FLASHED RED WITH ALL FIVE LETTERS ILLUMINATED. I TRIED TURNING OFF THE IGNITION AND TURNING IT BACK ON WITH THE SAME RESULTS. NO MOVEMENT WITH ENGINE ACCELERATING. AFTER BEING PUSHED INTO A PARKING LOT BY PASSERSBY, I TRIED AGAIN AND THE TRANSMISSION WORKED AS IT WAS SUPPOSED TO. AFTER RESEARCHING THE PROBLEM ON THE INTERNET, I FIND THAT IT IS A COMMON VW PROBLEM AND THE NHTSA ACTION NUMBER IS PE09035 OPENED JULY 17, 2009 COVERING 2008 AND 2009 MODELS. MY TDI IS A 2006 MODEL PURCHASED IN MAY 2007 BECAUSE VW KEPT SELLING 2006 TDIS IN 2007. THERE WERE NO 2007 VW JETTA TDIS. *TR

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT WAS TRAVELING 60 MPH WHEN THE VEHICLE BECAME RESISTANT TO ACCELERATION ATTEMPTS. THE CHECK ENGINE WARNING LIGHT ILLUMINATED PRIOR TO THE FAILURE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 122,000.

RECURRING DSG TRANSMISSION PROBLEMS: FIRST REPORTED TO VW IN JANUARY OF 2006 WITH FAILURE TO DOWNSHIFT AT 22K MILES (NO PROBLEM FOUND/NO CODES).IN 2010 REPORTED LOSS OF POWER AND OR SHIFTING IN AND OUT OF GEAR DURING HIGH AMBIENT TEMPERATURE. IN JUNE OF 2012; FROM PARKING, DELAYED SHIFTING INTO REVERSE OR DRIVE AND THEN VIOLENTLY ENGAGING. ON RETURN FROM ARIZONA, AGAIN HIGH TEMP, FOR APPROXIMATELY 100 -150 MILES WOULD LOSE POWER TO WHEELS AND THEN WOULD RETURN TO NORMAL REPEATEDLY. VW WILL NOT COVER 2006 JETTA UNDER DSG RECALL (I BELIEVE THERE ARE TWO RECALLS). COST OF NEW DSG TRANSMISSION QUOTED AT $7000.00! *TR

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, HE NOTICED THAT THE VEHICLE WOULD NOT SHIFT GEARS. HE PULLED OVER AND WAITED UNTIL THE VEHICLE COOLED DOWN. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE DEALER STATED THAT THEY WERE NOT SURE WHAT WAS WRONG WITH THE VEHICLE. THE MANUFACTURER WAS CONTACTED BUT PROVIDED NO ASSISTANCE.THE FAILURE MILEAGE WAS 29,000 AND THE CURRENT MILEAGE WAS 94,000. UPDATED 08/23/12*LJ UPDATED 09/24/2012 *JS

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT AND A LIGHT INDICATED THAT THE HEADLIGHTS WERE NOT FUNCTIONING WERE ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER AND THE DEALER STATED THAT SENSORS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE CONTINUED. THE MANUFACTURER WAS NOTIFIED AND OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE NOT AVAILABLE.

2006 JETTA 2.0T WITH A DSG TRANSMISSION HAS A DUAL MASS FLYWHEEL (DMF) WHICH IS FAILING: CHATTERING AT IDLE, WHEN SHIFTING GEARS, AND WHEN SLOWING TO A STOP. SPOKE WITH A FEW DEALERS IN THE AREA TO ASK ABOUT THE REPAIR AND WAS QUOTED $2500 TO REPAIR (THE DMF ONLY!). CONTACTED VOA TO FIND OUT IF THIS ISSUE WAS PART OF A RECALL, BUT NO RECALLS FOR SUCH FAILURES. HOWEVER, I WAS OFFERED $1000 TOWARDS THE PURCHASE OF A NEW VW - THAT WON'T FIX MY PROBLEM. ALL DEALERS I SPOKE WITH HAVE NO RECOLLECTION OF ANY OTHER FAILED DMFS - AT ALL. THROUGH MY OWN RESEARCH, I DISCOVERED THAT AUDI (VW PARTNER COMPANY) ISSUED A RECALL FOR A NUMBER OF 2006 A3 MODELS WITH THE SAME PART NUMBER (SAME PART) TO REPLACE THIS DEFECTIVE DMF PART (R/2006/031). ALSO LEARNED THAT THERE WAS A RECALL ISSUED FOR 1.9TDI MODEL JETTAS IN AUSTRALIA (135C). THERE HAS BEEN NO SUCH RECALL FOR US OWNERS OF VW MODELS WITH THE DSG TRANSMISSION AND THE DMF. WHY NOT? I ALSO OWN A 2010 PASSAT WITH THE SAME ENGINE, TRANSMISSION AND DMF PART. I CAN ONLY EXPECT TO HAVE THE SAME ISSUES WITH THAT CAR LATER ON. IT WOULD BE NICE EVEN TO HAVE VW ACCEPT THE RESPONSIBILITY OF ADDRESSING THE DMF PART MAKER (LUK AND/OR SACHS) FOR A PARTIAL PAYMENT OF THE REPAIRS. AT THIS POINT I HAVE TWO OPTIONS; SELL THE CAR TO AN UNSUSPECTING VICTIM, OR PAY NEARLY 50% OF THE TRADE VALUE OF THE CAR WITH 106,000 MILES ON IT TO HAVE IT FIXED. *TR

ENGINE LOSS OF POWER, BLACK SMOKE FROM EXHAUST AND PINGING NOISE FROM ENGINE VEHICLE STALLED A FEW TIME IN TRAFFIC ALMOST CAUSING AN ACCIDENT WITH OTHER VEHICLES DRIVING VEHICLE TO WORK, STARTED MAKING NOISE AND DECIDED TO DRIVE TO VW DEALERSHIP. DEARLERSHIP FIRST DIAGNOSED THE PROBLEM AS A BAD CLUTCH. UNDER MY RECOMMENDATION CAMSHAFT WAS INSPECTED AND FOUND TO BE DEFECTIVE AS WELL AS THE LIFTERS THAT CONTACT THE CAMSHAFT. DEALER SAYS THIS IS NOT A VW PROBLEM AND WAS SURPRISED TO SEE A PROBLEM WITH THE CAMSHAFT. IF YOU LOOK ON THE INTERNET, MANY TDI VW OWNERS ARE EXPERIENCING THE SAME PROBLEM. THIS PROBLEM IS NOT BEING RECONGIZED BY VW AND IS COSTING OWNERS A LOT OF MONEY IN REPAIRS AS WELL AS CREATING UNSAFE DRIVING CONDITIONS FOR OWNERS OF THIS VEHICLE. *JS