2005 VOLKSWAGEN JETTA Complaints

DT: THE CONSUMERS VEHICLE BEGAN TO SMOKE WHEN HE APPLIED THE ACCELERATOR. THIS CAUSED SOOT BUILD UP ON THE INSIDE OF THE CAR. THE SOOT WAS WORSE IN THE BACK OF THE STATION WAGON. SOOT AFFECTED THE WHOLE VEHICLE. THE CAR WAS TAKEN TO THE REPAIR SHOP FIVE TIMES FOR THIS COMPLAINT. CONSUMER STATED THAT IT WAS SIX TIMES, BUT THE DEALER DID NOT LOG THE FIRST COMPLAINT IN THE COMPUTER. CONSUMER STATED THAT THE DEALERSHIP WAS NOT ACKNOWLEDGING THE FIRST COMPLAINT. THE DEALERSHIP TOLD THE CONSUMER THAT THERE WAS NOTHING THEY COULD DO ABOUT THE EMISSION PROBLEM BECAUSE THIS WAS A NEW TYPE OF DIESEL ENGINE. THE TYPE OF ENGINE HAD A PUMP MADE TO USE EURO DIESEL WHICH WILL NOT BE AVAILABLE IN THE UNITED STATES UNTIL 2007. THIS INFORMATION WAS NOT MADE AVAILABLE TO THE CONSUMER BEFORE THE PURCHASE OF THE VEHICLE. THE CONSUMER DIDN'T WISH TO POLLUTE THE ENVIRONMENT. HE ALSO STATED IT WAS NOT SAFE FOR BREATHING. SOOT COULD CAUSE BLACK LUNG DISEASE. MANUFACTURER HAS BEEN NOTIFIED AND CLAIMED THAT THERE WAS NOTHING WRONG WITH THE VEHICLE, AND IT WILL NOT POLLUTE THE ENVIRONMENT UNTIL 2007 WHEN THE DIESEL WAS CONVERTED. THE CONSUMER HAD A MEETING WITH THE VOLKSWAGEN REPRESENTATIVE. THEY OFFERED TO REFUND THE COST OF CLEANING THE CAR FROM THE SOOT ON THE INSIDE. THE DEALERS PHONE NUMBER WAS NOT PROVIDED.*AK

SHIFTING FROM PARK TO EITHER REVERSE OR DRIVE WHILE ENGINE IS COLD, VEHICLE HESITATES AND THEN SUDDENLY JERKS INTO GEAR.

DT: THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. HE IS HAVING PROBLEMS WITH THE ACCELERATOR PEDAL. THE VEHICLE WILL NOT ACCELERATE WHEN HE NEEDS IT TO. WHEN HE TURNS THE CAR OFF AND LETS THE COMPUTER RESET THEN START THE VEHICLE IT WILL ACCELERATE. HE TOOK CAR TO A DEALER, AND SINCE THE PROBLEM WAS INTERMITTENT THEY COULD NOT FIGURE OUT THE CAUSE OF THE PROBLEM. DEALER COULD NOT DUPLICATE THE PROBLEM WHILE HAVING THE CAR FOR EIGHT DAYS.*AK *NM

ON THE 'NEW' 2005.5 JETTA TDI DIESEL VEHICLE, THE FUEL NOZLE INLET IS TOO SMALL TO USE A MOAJORITY OF THE DIESEL FUEL PUMPS MORE COMMONLY FOUND AT TRUCK STOPS. SINCE WHEN TRAVELING CROSS COUNTRY YOU WOULD MOST LIKE STOP AT A TRUCK STOP TO FUEL UP, YOU WOULD MOST LIKELY BE OUT OF LUCK -AND HAVE 'SEARCH' FOR A GAS STATION IN A STRANGE TOWN, AWAY FROM YOUR ROUTE, THAT 'MIGHT' HAVE A SMALLER NOZLE THAT WOULD FIT YOUR FUEL TANK. THE OLDER JETTA, GOLF AND PASSAT CARS USE A LAGER FUEL INLET THAT IS UNIVERSAL IN TERMS OF BEING ABLE TO FUEL UP ANYWHERE. THE CURRENT 2005 PASSAT HAS THE LARGER INLET, SO WHAT GIVES WITH THE NEW JETTA? TDI OWNERS TRAVEL GREAT DISTANCES AND WOULD LIKE TO NOT BE STRANDED OR MADE TO GO OUT OF THEIR WAY JUST TO FUEL UP. VW SHOULD RETROFIT THE OLDER STYLE NOZLE ON THESE CARS, OR PURCHASE A SMALLER FUELING PUMP NOZLE FOR EVERY GAS STAION OR TRUCK STOP THAT SELLS DIESEL IN THE COUNTRY. WHICH IS EASIER?

THIS HAS BEEN REPORTED BY OTHERS AND I WOULD LIKE TO REPORT IT AS WELL, SO THAT VW WILL EVENTUALLY BE FORCED TO MAKE A RECALL ON THIS MALFUNCTION. WHEN I START MY CAR AFTER IT HAS BEEN SITTING FOR AND HOUR OR MORE, I PLACE MY FOOT ON THE BRAKE, PUT IT EITHER INTO REVERSE OR DRIVE, AND IF I AM ON ANY HILL, VERY SMALL OR LARGE, WHEN I TAKE MY FOOT OFF OF THE BRAKE, THE CAR WILL ROLL DOWNHILL. THE FIRST FEW TIMES THIS HAPPENED, I ALMOST ROLLED THE CAR OVER A CURB AND DOWN A LARGE EMBANKMENT. THE ONLY WAY TO STOP THE CAR IS TO APPLY THE BRAKE AGAIN, AND THEN RELEASE THE BRAKE AND QUICKLY APPLY THE GAS. WHEN THAT IS DONE, THE CAR VERY ABRUPTLY JUMPS INTO GEAR.

I WAS MAKING A LEFT HAND TURN AND FOR NO REASON WHATSOEVER THE DRIVER AND PASSENGER AIRBAGS DEPLOYED. FOLLOWING THE DEPLOYMENT OF THE AIRBAGS, MY HANDS WERE THROWN OFF THE STEERING WHEEL, CAUSING ME TO LOSE CONTROL OF THE VEHICLE. THE VEHICLE THEN PROCEDED TO GO STRAIGHT UP ONTO A CURB CAUSING THE ENTIRE PASSENGER SIDE OF THE VEHICLE TO BE DAMAGED. THE CAR WAS NOT DRIVABLE

MY WIFE AND I PURCHASED A 2005 VW JETTA TDI (1.9 LITER DIESEL ENGINE) IN OCTOBER OF 2004. THIS VEHICLE HAD A HEATING ELEMENT THAT WAS BAD AND EVENTUALLY FIXED BY DEALER UNDER WARRANTY IN NOVEMBER OF 2004. SINCE APPROX. DECEMBER OF 2004 WE HAVE EXPERIENCED INCREASED PROBLEMS WITH THE CLUTCH DISENGAGING FROM THE FLYWHEEL WHILE SHIFTING UP OR DOWN AND WHILE PASSING CARS. I HAVE SINCE FOUND OUT THE CAR (SINCE 2001) HAS A DUAL MASS FLYWHEEL ASSEMBLY INSTALLED BY VW THAT IS AT ROOT OF PROBLEM. THE TWO LAYERED FLYWHEEL IS BECOMING OVER HEATED AND WARPING THE CLUTCH DISC ABNORMALLY IN CERTAIN SPOTS. SOME MECHANICS AND ENGINEERS HAVE SPECUALATED IMPROPER DESIGN, AND OTHERS SAID TRANSMISSION BOLTS AROUND FLYWHEEL WERE PROBABLY OVERTIGHTENED AT MANUFACTURER. EITHER WAY, OUR CLUTCH IS DISENGAGING BY ITSELF FROM THE FLYWHEEL AFTER WE DRIVE CAR FOR 60 OR 70 MILES AT ONE TIME (AND CAR IS HEATED UP). THE CLUTCH DISENGAGES AFTER SHIFING UP OR DOWN AND SOMETIMES WHILE PASSING, CAUSING PROBLEMS NEGOTIATING SPEEDS. THIS MEANS LACK OF CONTROL FROM THE DRIVER WHICH EQUALS SAFETY HAZARD FOR MOST. OUR CAR STARTED THIS AT 11,500 MILES, BUT DEALER IS REFUSING WARRANTY WORK BECAUSE HIS SERVICE ADVISOR FAILED TO NOTE THE PROBLEM WE REQUESTED TO HAVE CHECKED ON THREE SEPARATE OCCASIONS. DEALER IS ALSO DENYING IT IS A CLUTCH/FLYWHEEL PROBLEM SINCE HE CAN NOT DUPLICATE IT IN FIFTEEN MINUTES, BUT HAS REFUSED TO LOOK ANY FURTHER. MOST RESEARCH I HAVE DONE SHOWS THOUSANDS OF VW JETTA CUSTOMERS WITH SAME PROBLEM BETWEEN 11K AND 20K MILEAGE (FROM 2001 TO 2005 MODELS).

IN THE MORNINGS THE CAR WILL NOT GO INTO REVERSE WHEN YOUR FOOT IS ON THE BRAKE, YOU HAVE TO LET OFF ON THE BRAKE AND REVERSE THE ENGINE A BIT, THEN THE CAR JUMPS INTO REVERSE, SUDDENLY AND UNEXPECTLY LURCHES BACKWARD. DEALERS RESPONSE: BACK YOUR CAR INTO YOUR GARAGE OR PARKING SPACE AT NIGHT SO YOU DON'T NEED TO USE REVERSE IN THE MORNING. *AK

MY ALARM ON MY 2005 JETTA TDI IS MALFUNCTIONING. I HAVE HAD SEVERAL OTHER ELECTRICAL PROBLEMS, INCLUDING FAULTY CONTROLS IN THE STEERING COLUM, AND FAULTY COMPONENTS IN THE ESP. I HAVE BEEN TOLD THAT TO REPAIR THE ALARM, THE RADIO MUST BE REPLACED, HOWEVER THE RADIO IS ON 'BACKORDER', HAS BEEN FOR SIX WEEKS, AND I DO NOT AS OF TODAY, KNOW WHEN I WILL HAVE THIS REPAIRED. THESE PROBLEMS, ALONG WITH THE EXTENDED DELAY IN REPAIRING THE RADIO HAVE CAUSED ME TO CONSIDER THE POSSIBILITY OF A MORE SIGNIFICANT PROBLEM WITH THE VEHICLE ITSELF AND I AM CONCERNED.*AK

THIS PROBABLY IS THE SAME AS THE EXISTING COMPLAINT NUMBER 10079735 FOR VOLKSWAGEN JETTA 04. 1. IT HAPPENS ONLY WHEN IT IS COLD. IF IT IS COLD, THE PROBLEM IS REPEATABLE. 2. WHILE PUSHING THE BRAKE, WE MOVE THE SHIFT FROM PARK TO EITHER DRIVE OR REVERSE (IT'S THE SAME). THEN NORMALLY, TORQUE IS TRANSMITTED THROUGH DRIVESHAFT THROUGH THE TRANSMISSION. HOWEVER, JETTA DOES NOT FUNCTION AS SUCH. 3. THE TRANSMISSION ONLY CAN ENGAGES WHEN I RELEASE THE BRAKE ALMOST COMPLETELY. UP TO THE POSITION, IT IS THE SAME AS NEUTRAL. THAT INTRODUCES SUDDEN AND ABRUPT START OF THE CAR.*AK