2003 VOLKSWAGEN JETTA Complaints

I WAS DRIVING MY CAR ON A STRAIGHT SECTION OF ROAD THAT WAS NEWLY GRADED GRAVEL AT ABOUT 35 MPH WHEN THE PASSENGER SIDE AIR BAGS DEPLOYED. BOTH THE SIDE AIR CURTAIN AND THE SEAT AIR BAGS WENT OFF. THE SEAT BAG HIT MY WIFE ON THE BACK OF THE UPPER ARM LEAVING SOME BRUISING AND WHAT LOOKED TO BE LARGE WELTS AND BURNS. THE SWELLING AND BURNS WENT AWAY AFTER WE FOUND SOME ICE AND PACK HER ARM IN IT. VW SAYS THAT WE WERE IN A COLLISION BUT WE WERE AROUND NO ONE AND DID NOT HIT ANYTHING. THERE IS NO DAMAGE TO MY CAR FOR ANY COLLISION. MY INSURANCE COMPANY FIXED THE CAR UNDER A COMP. CLAIM AS THEY WERE UNABLE TO FIND ANY COLLISION DAMAGE. *JB

DT: ON JULY 3, 2004 THE PASSENGER'S SIDE/CURTAIN AIRBAG DEPLOYED WITHOUT CAUSE. THE PASSENGER SUSTAINED MINOR INJURIES. THERE WAS DAMAGE TO THE VEHICLE. WHEN THE VEHICLE WAS INSPECTED BY THE VOLKSWAGEN FIELD TECHNICIAN HE SAID THAT THERE WERE SOME SMALL DENTS THAT CAUSED THE DEPLOYMENT. WHEN SOMEONE FROM TRANSPORT CANADA INSPECTED THE VEHICLE HE SAID THAT THERE WAS NO REASON FOR THE SIDE CURTAIN AIRBAGS TO HAVE DEPLOYED. HE SAID THAT THE DENTS WERE THERE BEFORE THE CLEAR COAT WAS EVEN PUT ON THE VEHICLE. THERE WAS NO COLLUSION.

DT: THE CONTACT OWNS A 2003 VOLKSWAGEN JETTA. THE DRIVER'S SIDE AIR BAG DEPLOYED FOR NO REASON. THE SPEED AT THIS TIME WAS ABOUT 60 MPH. THE CONTACT WAS UNAWARE OF ANY DEBRIS THAT MAY HAVE BEEN ON THE ROAD. THE CONTACT DID NOT LOSE CONTROL OF THE VEHICLE. THE AIR BAG WARNING LIGHT WAS NOT ON PRIOR TO THE INCIDENT. THERE WERE NO INJURIES. THE DEALERSHIP WAS CONTACTED AND THE CONTACT WAS TO TAKE THE VEHICLE TO THE DEALERSHIP TOMORROW, AND THE VEHICLE WAS COVERED UNDER A WARRANTY. THIS OCCURRED ON AUGUST 31, 2005.*AK

A/C FAN SIEZED, CAUSING ENOUGH HEAT TO START A FIRE. THE SHROUD, UPPER RADIATOR MODLINGS, A/C HOSE, HOOD INSULATION AND PAINT WERE DAMAGED.

* 2003 VOLKSWAGEN JETTA WITH 38,116 MILES / ONE OWNER * VW CASE # 50260581 * REPAIR LOCATION: NORTH POINT VW, SHERWOOD, AR (501) 945-5353 THE PROBLEM THIS VEHICLE'S CLUTCH AND FLYWHEEL BOTH FAILED (COMPLETELY WORN) AT 38,116 MILES, WELL BEFORE THE AVERAGE EXPECTED LIFE... POSSIBLE MATERIAL DEFICIENCY. BACKGROUND ALL SERVICE FOR THE VEHICLE HAS BEEN COMPLETED AND DOCUMENTED WITH VW. THIS VEHICLE HAS NOT BEEN SUBJECTED TO ANY EXTREME DRIVING IN ANY WAY. MANUFACTURER'S ASSISTANCE NONE. THE CLUTCH IS A WEAR ITEM AND THEREFORE NOT COVERED BY THE WARRANTY. ALTHOUGH THE LOCAL SERVICE MANAGER AGREES THAT A CLUTCH SHOULD NOT FAIL AT THIS LOW MILEAGE, NEITHER HE, OR THE VW HELP CENTER (800 411-6688) WOULD HELP IN THE $1,600 REPAIR. BOTTOM LINE AFTER DOING A GOOGLE SEARCH FOR "VW JETTA CLUTCH FAILURE", I NOTED NUMEROUS REPORTS OF PREMATURE VW CLUTCH FAILURE. IS THIS A "WEAK LINK" IN THIS VEHICLE? IS VW TRYING TO HIDE AN INFERIOR PART?

VEHICLE BEING DRIVEN ON A HIGHWAY AND MOTOR "BLEW UP". TOWED TO DEALERSHIP AND TOLD THAT IT WAS FAULTY TURBO DUE TO SLUDGE IN THE TURBO. DEALERSHIP DENIED ANY RESPONSIBILITY CLAIMING IT WAS OWNER'S PROBLEM BECAUSE SYNTHETIC OIL WAS NOT USED.

NO ACCIDENT HAS OCCURRED. HOWEVER, WHO OR WHAT COMPANY DO I EMAIL TO GET INFORMATION ON WHY VOLKSWAGEN WILL NOT PUT FORTH A RECALL ON THE SUNROOF OF THE JETTA MODEL 2001 AND 2002? I AM WAITING TO HEAR BACK FROM THIS COMPANY. HOWEVER, FROM THE CONSUMER REPORTS I SEE THAT THEY HAVE NOT RECALLED THIS PART ON THESE CARS. CAN YOU PLEASE DIRECT ME TO THE EMAIL ADDRESS THAT I MIGHT GET AN ANSWER? IT IS A SERIOUS ISSUE WITH THE AIRBAGS THAT ARE LOCATED IN THE COLULMS OF THIS VEHICLE. IF THEY GET WET THEY WILL NOT WORK. THEREFORE IT IS A HAZARD THAT VOLKSWAGEN SHOULD ADDRESS.THANK YOU

DT: 2003 VOLKSWAGEN JETTA DIESEL TDI. THE ENGINE DIED AT 70 MPH. THE CONSUMER KNEW IT WAS NOT THE TIMING BELT AND BELIEVED IT TO BE AN ELECTRICAL PROBLEM. THE CAR HAS AN ELECTRICAL PROBLEM WITH THE COMPUTER SENSOR THAT CONTROLS THE SIGNALS. LIGHTS TO FLASH, FLASHERS ALSO WITH POWER WINDOWS. THE CONSUMER TOOK THE VEHICLE TO A MECHANIC AND HE COULD FIND NO REASON FOR THIS TO HAPPEN. THE TIMING BELT IS IN PLACE AND IN GOOD CONDITION. *TT *SC *JB

TO WHOM IT MAY CONCERN: MY NAME IS [XXX]. I OWN A 2003 VOLKSWAGEN JETTA TDI THAT I PURCHASED NEW ON 3/10/03 FROM AUTOHAUS OF LANCASTER IN LANCASTER, PA. IT NOW HAS 56,700 MILES ON IT. (MOSTLY HIGHWAY) WHILE DRIVING ON 6/21/05, I WENT TO APPLY THE BRAKES AND THE BRAKES GOT MUSHY AND THEN GRABBED AND THE PEDAL WENT TO THE FLOOR IN A SUDDEN STOP. AS IT WAS STOPPING YOU HEARD A SOUND LIKE THE VEHICLE NOW HAD AIR BRAKES. I DEPRESSED THE PEDAL AGAIN THE BRAKES LET UP. I WAS NEARLY REAR ENDED BY A TRUCK THE FIRST TIME IT HAPPENED. I PULLED OFF THE ROAD AND CALLED THE GARAGE. IT TURNED OUT TO BE A BRAKE BOOSTER. PRIOR TO THIS PROBLEM, WHILE THE VEHICLE WAS STILL UNDER WARRANTY AT 48,000 MILES, I HAD THE VEHICLE IN FOR SERVICE AT THE DEALERSHIP WHERE THE VEHICLE WAS PURCHASED. IT WAS IN BECAUSE SEVERAL TIMES I APPLIED THE BRAKES IN THE SNOW AND THE TIRES LOCKED UP. THIS VEHICLE HAS ANTI-LOCK BRAKES. AT THIS TIME THE ANTI-LOCK BRAKES DID NOT WORK. THIS HAPPENED SEVERAL TIMES. THE DEALERSHIP FOUND NO PROBLEMS. THEY CHECKED IT AND SAID ALL WAS OK. IT HAPPENED AGAIN ABOUT A WEEK AFTER I GOT IT OUT OF THE SHOP. MY CURRENT MECHANIC (ROBERTS AUTOMOTIVE) WHO SPECIALIZES IN VOLKSWAGENS MENTIONED THAT HE BELIEVES THAT TWO PROBLEMS ARE VERY LIKELY THE SAME PROBLEM. THE MECHANIC ([XXX] @ ROBERTS AUTOMOTIVE) ALSO TOLD ME THAT HE CALLED THE LOCAL DEALERSHIP (AUTOHAUS OF LANCASTER, PA) FOR THE PART, AND HE WAS TOLD THEY REPLACED 8 OF THESE BRAKE BOOSTERS IN THE LAST TWO YEARS. I ALSO TALKED TO THE SERVICE MANAGER AT AUTOHAUS. DAVE TOLD ME THEY HAVE HAD SEVERAL BRAKE BOOSTERS GO BAD ON THE TDI MODELS. THE VEHICLE IS NOW IN THE HANDS OF AUTOHAUS. IT SOUNDS TO ME LIKE THERE IS A PROBLEM WITH QUALITY AND WORKMANSHIP HERE. THIS IS A DEFINITE SAFETY ISSUE. BY SHEER LUCK I WAS NOT HIT BY THAT TRUCK. I WILL BE SENDING A SIMILAR LETTER TO VOLKSWAGEN OF AMERICA WITH MY COMPLAINT. THANK YOU FOR YOUR COOPERATION. REGARDS, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

I WAS DRIVING MY 2003 VW JETTA UNDER NORMAL ROAD CONDITIONS. I STOPPED AT A RED LIGHT IN AN INTERSECTION, CONTINUED WHEN IT TURNED GREEN. I HIT A SMALL SIZED POTHOLE AT THE OTHER END OF THE INTERSECTION AT SPEEDS BELOW 15MPH, WHICH CAUSED THE WRONGFUL DEPLOYMENT OF THE SIDE CURTAIN AND SEAT AIRBAGS AS WELL AS LOCKING THE SEATBELT TENSIONER MAKING IT INOPERABLE. I INSPECTED THE VEHICLE AFTER THE INCIDENT AND FOUND NO DAMAGE WHATSOEVER TO ALL BODY PANELS AND WHEELS/TIRES. THE FOLLOWING MORNING I HAD A MECHANIC INSPECT THE CAR FOR ANY SUSPENSION OR STEERING PROBLEMS AND NONE WERE FOUND. I TOOK THE VEHICLE TO THE DEALER WHERE I PURCHASED IT TO HAVE IT FIXED UNDER WARRANTY AND THE DEALER AND VW OF AMERICA HAVE DENIED WARRANTY REPAIRS AND HAVE NOT YET DONE ANYTHING TO FIX THE PROBLEM. I DID RESEARCH ON THE INTERNET FOR SIMILAR INCIDENTS WITH THIS MAKE AND MODEL AND HAVE FOUND THAT THERE HAVE BEEN 500 SIMILAR INCIDENTS OF SPONTANEOUS AIRBAG DEPLOYMENT IN 2002-2004 VW JETTAS, GOLFS, GTI AND NEW BEETLES AROUND THE COUNTRY.