2006 VOLKSWAGEN JETTA Complaints

I'M IN THE MIDST OF GETTING A DSG TRANSMISSION REPAIRED AND IT COULD COST AS MUCH AS $4000. THE TRANSMISSION BEGAN MAKING "GRINDING" NOISES, AND I WAS TOLD THAT THERE ARE BEARINGS THAT WILL NEED TO BE REPLACED. I KNOW THROUGH VARIOUS VW FORUMS THAT THERE HAVE BEEN RECALLS ON THIS TRANSMISSION AND I WOULD LIKE VW TO BACK UP THEIR PRODUCT. *TR

2006 VOLKSWAGEN JETTA TDI DUAL MASS FLYWHEEL IS FAILING. SOUND FROM BELL HOUSING GETTING LOUDER. OTHER OWNERS REPORT DRIVETRAIN LOCKUP WHEN FAILING. PROBLEM APPEARS TO BE HIGHER THAN NORMAL INCIDENT RATE. *TR

1 CLUTCH PEDAL WHEN DEPRESSED STAYS DOWN. 2 INTERMITTENT 3 , FLY WHEEL DAMAGE, RETURN BEARING DAMAGE, COST OF REPAIR $2400.00. *TR

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA TDI. THE CONTACT WAS DRIVING 25 MPH WHEN HE APPLIED THE BRAKES AND THEY DID NOT RESPOND. THE VEHICLE WAS REAR ENDED BY ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY UNTIL AFTER THE CRASH HAD ALREADY OCCURRED. THE CONTACT SUSTAINED ABRASIONS FROM THE AIR BAG DEPLOYMENT. IN ADDITION, THE AIR BAGS FRACTURED THE FRONT WINDSHIELD. A POLICE REPORT WAS AVAILABLE. ALSO, THE AIR BAGS CRACKED THE WINDSHIELD. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGE WAS APPROXIMATELY 96,000.

2006 VW JETTA WITH DSG TRANSMISSION. VEHICLE LURCHED AND LOST POWER AS IF GAS HAD BEEN SWITCHED OFF OR TRANSMISSION WAS UNEXPECTEDLY DISENGAGED FROM ENGINE. THIS OCCURRED ON VERY HOT DAY, 100+ DEGREES, WHILE DRIVING ON THE INTERSTATE. VEHICLE REGAINED POWER 2-3 SECONDS AFTER LOSS. THIS HAPPENED 4 TO 5 TIMES ON A 400 MILE DRIVE. ONE TIME OCCURRED WHILE PASSING AND FORCED ME TO TAKE ACTION AND CANCEL MY PASS OF THE SLOWER MOVING VEHICLE. THIS HAS OCCURRED IN THE PAST BUT IT WAS ONLY ON A VERY HOT DRIVE ABOUT A YEAR OR TWO AGO. *TR

MY JETTA WOULD STALL AND WE WERE ALMOST INVOLVED IN SERIOUS ACCIDENTS. WE BROUGHT IT TO DEALER AND THEY TOLD US IT WAS FIXED AND IT HAPPENED AGAIN. I ASKED FOR A REPLACEMENT AND THEY REFUSED. PROBLEM HAS NOT OCCURRED RECENTLY, HOWEVER WE WERE ALMOST KILLED. UNSURE OF DATES, HOWEVER DEALER HAS RECORDS. *TR

TL*THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. WHILE DRIVING 40 MPH THERE WAS A WARNING LIGHT THAT ILLUMINATED STATING THERE WAS A FAILURE WITH THE VEHICLE. SHE DROVE THE VEHICLE TO THE DEALER WHO STATED THAT THE LIGHT THAT ILLUMINATED WAS AN ENGINE LIGHT. HE WAS TOLD THAT THE RADIATOR COOLING FAN NEED TO BE REPLACED. THE DEALER REPLACED BOTH FANS FOR $975 AT HER EXPENSE. THE FANS WERE NOT UNDER WARRANTY OR RECALL. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 39,400. UPDATED 12/7/10 *CN

2006 VW JETTA TDI WITH DSG AUTOMATIC TRANSMISSION: WHILE SLOWING DOWN APPROACHING A STOPLIGHT VEHICLE TRANSMISSION FAILED TO STAY IN GEAR ACTING LIKE IT WAS IN NEUTRAL. VEHICLE HAD FLASHING LIGHTS ON DASHBOARD BEHIND GEAR-SHIFT INDICATIONS. AFTER SEVERAL ATTEMPTS TO RE-ENGAGE TRANSMISSION, GEARS FINALLY ENGAGED AND VEHICLE WAS DRIVEN TO SIDE OF HIGHWAY. TURNED VEHICLE OFF, WAITED SEVERAL MINUTES AND RESTARTED VEHICLE AND IT OPERATED NORMALLY. OWNER'S MANUAL SAID TO CONTACT DEALER AS SOON AS POSSIBLE IF THIS HAPPENS. DEALER SAID CODE WAS PB1819-VALVE BODY FAILURE. VEHICLE MILEAGE: 72,500. *TR

WE HAVE HAD SEVERAL INCIDENTS WITH OUR 2006 VOLKSWAGEN JETTA 2.5 WHERE WE WOULD LOSE POWER AND THE VEHICLE STALLS OUT. OUR 2006 JETTA IS A GASOLINE 5-CYLINDER WITH AUTOMATIC TRANSMISSION AND HAS ONLY 45,000 MILES. IN JUNE OF 2010 WE FIRST NOTICED THE STALLING ISSUE WHEN DRIVING HOME AND IT STALLED OUT WHILE PULLING INTO THE DRIVEWAY. AFTER SITTING FOR ABOUT 10 MINUTES WE WERE ABLE TO PULL IT INTO THE GARAGE. THE SECOND INCIDENT OCCURRED ON FRIDAY 7/30/2010, WHILE DRIVING HOME FROM WORK (30 MILE COMMUTE) AT 45-55 MPH THE JETTA STARTED TO INTERMITTENTLY LOSE POWER BEFORE THE ENGINE COMPLETELY STALLED. NOTE: I WAS STILL TRAVELING AT 55 MPH WHEN THE ENGINE STALLED. IT WOULD RESTART AND BEGAN EXPERIENCING THE SAME ISSUE MULTIPLE TIMES. WE TOWED THE CAR TO OUR LOCAL VOLKSWAGEN DEALERSHIP. THEY RAN DIAGNOSTICS AND DID NOT FIND ANY ERROR CODES FROM THE CAR'S COMPUTER. THEY REPLACED THE BATTERY THINKING THAT IT MIGHT HAVE BEEN AN ELECTRICAL ISSUE. WE PICKED UP THE CAR ON TUESDAY 8/3/2010 IN THE MORNING. WHILE DRIVING HOME FROM WORK THAT SAME DAY (30 MILE COMMUTE) THE ENGINE BEGAN EXPERIENCING THE SAME ISSUE, INTERMITTENTLY LOSING POWER WHILE TRAVELING ON THE INTERSTATE AT 70-80 MPH. AFTER EXITING THE INTERSTATE THE SYMPTOMS CONTINUED TO GET WORSE AND THE ENGINE COMPLETELY STALLED IN THE MIDDLE OF AN INTERSECTION ALMOST CAUSING A MULTI-CAR ACCIDENT. AFTER MULTIPLE ATTEMPTS TO RESTART AND REPEATED ENGINE STALLS I WAS ABLE TO GET THE VEHICLE TO GAS STATION WHERE IT WAS TOWED TO THE VOLKSWAGEN DEALER FOR A 2ND TIME. ONLY GOOD NEWS OF THIS STORY, THE VW MECHANIC WAS ABLE TO REPRODUCE THE ENGINE STALL ISSUE AFTER TEST DRIVING THE JETTA FOR ABOUT 45 MINUTES. VW DEALER REPORTED THE RESULT TO VW MANUFACTURER TECH SUPPORT. VW DEALER KEPT THE CAR FOR MORE THAN 1 WEEK TO RUN MORE TESTS PER VW TECH SUPPORT. ULTIMATELY REPLACED THE FUEL PUMP AND FUEL FILTER. NO MORE OCCURRENCES IN THE LAST TWO WEEKS...BUT AM LITERALLY HOLDING MY BREATH WHILE DRIVING. *TR

I HAVE A 2006 VW JETTA EQUIPPED WITH A DSG AUTOMATIC TRANSMISSION. I HAVE A FLYWHEEL THAT IS FAILING. THIS CAN CAUSE THE CAR TO LOCK UP AND CAUSE AN ACCIDENT. I NOTICE WHILE SEARCHING ONLINE THAT THIS IS A VERY COMMON PROBLEM WITH THIS MODEL JETTA. I THINK THAT THIS SHOULD BE EXAMINED AND VW SHOULD HAVE TO MAKE THIS RIGHT. *TR