2006 VOLKSWAGEN JETTA Complaints

THE DMF FLYWHEEL ON 2006 VOLKSWAGEN JETTA TDI COMES APART. MINE SEPARATED AND WAS SCRAPING SO I STOPPED DRIVING IT UNTIL I RECEIVED THE NEW FLYWHEEL AND CLUTCH. IT STARTED WITH A SCRAPING SOUND THAT HAPPENED MORE FREQUENT EVERYDAY AND A LITTLE LOUDER. AFTER 5 DAYS I REALIZED IT WAS COMING FROM THE FLYWHEEL. THERE ARE NUMEROUS PROBLEMS WITH THESE I HAVE FOUND ON FREDS TDI PAGE. MOST WERE FROM A DIFFERENT FLYWHEEL MANUFACTURER AND I WAS SURPRISED TO SEE MINE WAS MADE BY SACHS THESE CAN CAUSE SERIOUS DAMAGE TO A VEHICLE IF IT BREAKS APART. THIS CAR SEEMS REALLY WELL MADE AND IS ALOT OF FUN TO DRIVE. I HAVE BEEN REAL HAPPY WITH IT BUT THINK THIS SHOULD NOT HAVE HAPPENED AND COULD BE DANGEROUS. *TR

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT WAS DRIVING 25 MPH WHEN THE VEHICLE ABNORMALLY DECELERATED AND WOULD NOT RESPOND TO THE CONTACT'S ATTEMPTS TO DRIVE FORWARD OR IN REVERSE. THE CONTACT WAS UNABLE TO MOVE THE VEHICLE AND IT WAS TOWED TO AN AUTHORIZED DEALER. THE DEALER ADVISED THAT THE TRANSMISSION WOULD NEED REPLACING. A DIAGNOSTIC WAS PERFORMED BUT PRODUCED NO FAILURE CODES. THE MANUFACTURER OFFERED TO COVER ONE HALF OF THE REPAIR COSTS. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGE WAS 68,000.

THE 2006 JETTA GLI HEADLINER FABRIC IS HAVING SHRINKAGE AND FALLING OFF. THE CAR INTERIOR LOOKS UGLY THE VW DEALER IS CHARGING $1100.00 TO CHANGE THE WHOLE HEADLINER. *TR

TL*THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE VEHICLE EXPERIENCED VARIOUS RECURRING FAILURES SINCE THE DATE IT WAS PURCHASED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON NUMEROUS OCCASIONS WHERE THE BATTERY WAS REPLACED, THROTTLE VALVES WERE CLEANED, THE RECIRCULATION VALVE WAS REPLACED, THE ENGINE FAN CONTROL MODULE WAS REPLACED, THE FUEL PRESSURE SENSOR WAS REPLACED, THE CRANK CASE BREEDER VALVE WAS REPLACED, THE HIGH PRESSURE FUEL PUMP WAS REPLACED, AND THE CAM SHAFT FOLLOWER WAS REPLACED. THE VEHICLE WAS ALSO REPAIRED UNDER THE RECALL 09V164000, POWER TRAIN DRIVELINE, DRIVESHAFT AND HAD THE SUNROOF DRAINED DUE TO WATER LEAKAGE. THE FAILURE MILEAGE WAS 16,257 AND THE CURRENT MILEAGE WAS 47,000.

FABRIC HEADLINER ON INTERIOR ROOF OF 2006 VW JETTA IS SEPARATING, SAGGING DOWN SO THAT I CANNOT SEE OUT OF REARVIEW MIRROR. APPARENTLY THIS IS COMMON DEFECT W/THE CAR- THE GLUE SEPARATES AFTER ONLY A FEW YEARS. *TR

VW JETTA TDI 2006, MILEAGE 177 000KM ON AUG 5, 2010, I HEARD A STRANGE NOISE FROM THE ENGINE /TRANSMISSION, AS I WAS DRIVING ON THE HWY. AND I ALSO FELT VIBRATION AT 120-130KM /H. I PULLED INTO A VW DEALERSHIP TO CHECK IT OUT. THE SERVICE ADVISOR TOOK THE CAR FOR A TEST DRIVE AND TOLD ME THAT THERE IS A NOISE COMING FROM THE FLYWHEEL, BUT NOTHING SERIOUS. THE VERY NEXT DAY ON AUG 6,2010 WHILE DRIVING IN THE CITY I HEARD MORE AND LOUDER NOISE FROM THE TRANS. AN AT I DROVE SLOWLY FOR ABOUT 7KM. INTO ANOTHER VW DEALER. AT THIS POINT AFTER A THEY RAISED THE CAR ON THE HOIST THEY TOLD ME THAT THE SPRINGS FROM THE FLYWHEEL ARE BROKEN AND THE FLYWHEEL NEEDS TO BE CHANGED. THEY TOLD ME THAT THIS IS COMMON ISSUE DUE TO WEAR AND TEAR. THE REPLACEMENT PART ( THE FLYWHEEL) WILL COST ABOUT $900CND. AND THE LABOR THEY TOLD ME WOULD BE 8H WHICH IS $800 SO TO TOTAL COST IS $2100. I DO NOT THINK THAT THIS A NORMAL TO HAVE THE FLYWHEEL BROKEN JUST LIKE THAT. I ALSO WON AN ODER CAR WHICH I DROVE OVER 400 000 AND NEVER HAD PROBLEMS WITH THE FLYWHEEL. PLEASE ADVISE ON WHAT ARE MY OPTIONS AT THIS POINT. THANK YOU *TR

TL*THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE TRANSMISSION SHIFTED INTO NEUTRAL GEAR WHILE DRIVING. THE MANUFACTURER STATED THAT HIS VIN WAS NOT INCLUDED IN RECALL 09V333000 POWER TRAIN: AUTOMATIC TRANSMISSION. THE VEHICLE WILL BE REPAIRED. THE FAILURE MILEAGE WAS 91,000 AND THE CURRENT MILEAGE WAS 91, 5000.

PURCHASED A 2006 VW JETTA TDI, USED, WITH 61,800 MILES. CLUTCH FELT WEIRD TO ME WHEN I PURCHASED THE CAR BUT THOUGHT IT WAS NORMAL. LESS THEN TWO WEEKS AFTER PURCHASE I NOTICED GEARS SLIPPING. THE DEALERSHIP DIAGNOSED WORN CLUTCH DISK AND DAMAGED THROW-OUT BEARING. A PROPERLY MANUFACTURED CLUTCH ASSEMBLY SHOULD NOT FAIL AT 61,000 MILES, IF EVER. FROM WHAT I'VE READ IT MAY BE DUE TO BAD DESIGN OF THE DUAL MASS FLYWHEEL, WHICH OVER-HEATS THE DISK AND CAUSES DAMAGE. THIS IS A SERIOUS ISSUE WHICH MAY CAUSE SUDDEN LOSS OF CONTROL OF YOUR VEHICLE WHILE DRIVING DOWN THE HIGHWAY. MANY DRIVERS ARE NOT "IN-TUNE" WITH THEIR VEHICLE AND MAY NOT RECOGNIZE THE PROBLEM UNTIL A SERIOUS ACCIDENT LIKE THIS DOES HAPPEN. THE ISSUE IS RAMPANT, AND SEEMS IT MAY BE INEVITABLE FOR MOST 2006 VW BUILDS. HTTP://FORUMS.TDICLUB.COM/SHOWTHREAD.PHP?T=137014. *TR

THE ENGINE BEGAN CHATTERING WHILE IDLING. IT HAS 80K MILES. THE CHATTERING BECAME WORSE SO I TOOK IT TO THE LOCAL DEALER. THE TRANSMISSION HOUSING WAS CRACKED, THE FLYWHEEL BROKEN AND SLIP KIT CRACKED. IT WAS LEAKING OIL FROM THE TRANSMISSION. TOTAL REPAIR WILL BE MORE THAN $6000 AND TAKE MORE THAN 6 WEEKS TO COMPLETE THE REPAIR. THE PARTS DEALERS ARE HAVING A HARD TIME FINDING A FLYWHEEL. I HAVE HAD THE CAR SERVICED AT THE DEALER SINCE I BOUGHT IT. *TR

DRIVING HOME ON COUNTRY ROAD IN THE POURING DOWN RAIN WHEN AT ABOUT 50 MPH THE ENGINE RPM REVVED, DASH WARNING LIGHTS LIT, FLASHED AND RANG. THE PRND WAS FLASHING. LUCKILY A DRIVEWAY WAS NEARBY TO GET OUT OF TRAFFIC. KNEW AT THIS POINT WHAT HAD HAPPENED BECAUSE WE HAD THE VERY SAME THING HAPPEN IN OCTOBER OF 2009. MEGATRONICS UNIT HAD FAILED AND WAS REPLACED AT A COST OF $1900. CALLED DEALERSHIP FOR APPOINTMENT ON JUNE 8TH. HAPPENED AGAIN 5 TIMES ON WAY TO DEALERSHIP. TOLD FROM DIAGNOSTIC TEST THAT IT HAD A BAD STEERING ANGLE SENSOR AND GATEWAY MODULE. NO PARTS WERE AVAILABLE. HAD TO TAKE CAR 70+ MILES BACK HOME. THE CAR MALFUNCTIONED ON THE WAY HOME IN A CONSTRUCTION ZONE. FELT IT WAS UNSAFE TO DRIVE ANY FURTHER. STOPPED AT A DIFFERENT DEALERSHIP. LEFT CAR FOR THEM TO DIAGNOSE. FOUND A SECOND BAD MEGATRONICS UNIT. REPLACED UNDER WARRANTY FROM THE FIRST REPLACEMENT. I FEEL THAT THIS CAR NEEDS TO BE RECALLED FOR THE SAFETY CONCERN THAT THE VEHICLE LOSES POWER AT ANY GIVEN TIME, IN ANY ROAD SITUATION YOU CAN THINK OF. YOU CANNOT ALWAYS BE PREPARED TO REACT TO THIS. YOU HAVE NO POWER TO GET OUT OF HARMS WAY. THE ONLY WAY TO CORRECT THIS IS TO SHUT THE CAR OFF AND RESTART AND HOPE IT WORKS. PREVIOUS ODI #10286197. *TR