2011 VOLKSWAGEN JETTA Complaints

I WAS HAVING TROUBLE WITH VARIOUS LIGHT BULBS GOING OUT. IT TURNED OUT TO BE A FUSE THAT HAD MELTED THE FUSE PLATE. I AM LUCKY THAT IT HAD NOT STARTED A FIRE. MY DEALER REPLACED THE FUSE PLATE AT A COST OF 372 WHICH VW IS REFUSING TO REIMBURSE ME FOR. I KNOW OTHER VW MODELS HAVE HAD THE EXACT SAME PROBLEM AND HAVE BEEN RECALLED. THIS IS A SERIOUS SAFETY ISSUE AND SHOULD BE RECALLED AS SOON AS POSSIBLE. LOOSING YOUR HEADLIGHTS AT NIGHT OR A VEHICLE FIRE ARE SERIOUS SAFETY ISSUES. *TR

HPFP CATASTROPHIC FAILURE STARTED VEHICLE AND WHILE DRIVING EXPERIENCED LOSS OF POWER. DIESEL GLOW PLUG ILLUMINATED AND MFD MESSAGE READ "SERVICE NOW". STALLED AT TRAFFIC LIGHT AND WOULD NOT RESTART. TOWED TO VW OF CORPUS CHRISTI THE NEXT DAY. VW REPAIRED AT THEIR COST. NEVER FUELED WITH ANYTHING BUT DIESEL. REPAIR TICKET INDICATED THAT 'DIESEL LOOKED OK". I WAS FORTUNATE THAT THIS DID NOT OCCUR AT HIGHWAY SPEED. I BELIEVE THAT THE COMPLAINT WAS CLOSED TOO EARLY BY THE NHTSA AND IS NOT DUE TO MISFUELING AS YOU HAVE BEEN CONVINCED BY VW BUT RATHER A DESIGN FLAW IN THE HPFP. I HAVE LOST CONFIDENCE IN THIS BRAND AND THE NHTSA DUE TO THIS ISSUE. *TR

TL* THE CONTACT OWNS A 2011 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 75 MPH, THE DOOR LOCKS ON THE VEHICLE BEGAN TO LOCK AND UNLOCK INDEPENDENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

DRIVING DOWN THE HIGHWAY AT ABOUT 55MPH, STARTED SWITCHING LANES AND STEPPED ON THE GAS TO ACCELERATE. THE CAR SPUTTERED AND THE ENGINE VIBRATED. THE CAR FELT LIKE I WAS GOING TO STALL DRIVING IN THE HIGH-SPEED LANE. THE YELLOW CHECK ENGINE LIGHT CAME ON AND EPC LIGHT STARTED FLASHING. SWERVING BACK INTO THE LOWER SPEED LANE I COULDN'T EVEN KEEP THE CAR AT 55MPH. I HAD TO PULL OVER ON THE HIGHWAY TO SEE IF I COULD MAKE SENSE OF IT. AFTER TURNING OFF THE CAR AND THEN BACK ON, THE LIGHTS WENT OFF AND THE CAR WAS FINE. I TOOK IT TOO THE MECHANIC AND THEY SAID THEY COULDN'T FIND ANYTHING WRONG AFTER $85.00 DIAGNOSTIC. THE CAR RAN FINE FOR 2 DAYS UNTIL THE SAME EXACT THING HAPPENED WHILE DRIVING ON THE HIGHWAY AGAIN. THIS OCCURRED ON AND OFF INTERMITTENTLY ABOUT EVERY 1-2 DAYS FOR ABOUT 2 WEEKS. THREE TRIPS TO THE MECHANIC WITHIN THOSE 2 WEEKS AND WITH EACH VISIT THERE WAS A COMPUTER CONNECTED TO THE CAR AND A FULL SYSTEMS DIAGNOSTIC REPORTED THAT THERE WAS NOTHING WRONG WITH THE CAR. IT BECAME DANGEROUS FOR ME TO DRIVE THE CAR AND EVEN MORE SO TO DRIVE IT ON THE HIGHWAY. AFTER THE SECOND WEEK THE LIGHTS FINALLY CAME ON AND STAYED ON AND THE PROBLEM WAS DIAGNOSED AS THE ENGINE MISFIRING IN 2 OF THE CYLINDERS. THE MECHANIC CHANGED WITH THE IGNITION COIL ON 12/15.2014. THE ENGINE RAN COMPLETELY FINE WITHOUT ANY ISSUES UNTIL LAST WEEK, 3/19/2015. AT 3 MONTHS AND ONLY 28,000 MILES ON THE CAR THE SAME PROBLEM STARTED TO REOCCUR WHILE GETTING ONTO THE HIGHWAY AND ATTEMPTING TO ACCELERATE FROM 40-45MPH. IT STARTED JUST AS IT DID BEFORE INTERMITTENTLY AND ABOUT 2 WEEKS LATER THE ENGINE AND EPC LIGHTS WERE ON PERMANENTLY AGAIN. AFTER THE MECHANIC CONFIRMED THAT IT WAS THE SAME ISSUE WITH THE SAME COMPONENT WE CHANGED THE SAME PART AGAIN. I AM EXPECTING TO BE CHANGING IT AGAIN IN 3 MORE MONTHS, IF I STILL HAVE THE CAR. *TR

MY VW HAS HAD PROBLEMS SINCE A WEEK AFTER I BOUGHT IT. WHILE GOING 1500 RPM'S AROUND 15-25 MPH MY CAR CHUGS AND STALLS. I HAVE BROUGHT IT TO VW 4 TIMES, AND A PERSONAL MECHANIC. EACH TIME VW SAID THERE WAS A EITHER A COMPUTER ISSUE AND THAT THEY HAVE FIXED IT OR SAID THERE WAS NO ISSUE. THEY COMPLETELY RESET MY CARS COMPUTER BACK TO FACTORY SETTINGS DUE TO THEM SAYING THAT MY CAR LEARNED MY DRIVING STYLE. THIS DIDN'T HELP. YEARS LATER I AM STILL HAVING THIS PROBLEM. I HAVE ALMOST GOTTEN IN A FEW CAR ACCIDENTS BECAUSE OF THE STALLING/CHUGGING PROBLEM. I HAVE AN INFANT AND CAN'T HAVE MY FAMILY CAR CAUSING SUCH PROBLEMS. *JS

4:45 AM AT 45 MPH, THE ENGINE SPUTTERED THEN TWO DASH LIGHTS SHOWED UP, I PULLED OVER TO CHECK WHAT THEY MEANT. ONE SAID PRE GLOW BEFORE START UP; IF FLASHING MALFUNCTION IN THE DIESEL ENGINE, THE OTHER WAS THE ENGINE MALFUNCTION WHICH SAID EMISSION MALFUNCTION. I HAD THE VEHICLE TOWED TO LOCAL GARAGE THEY DETERMINED IT WAS A FUEL PUMP ISSUE AND SHOWED ME ALL THE METAL SHAVINGS IN THE FUEL METERING VALVE. THEY TOLD ME TO TAKE IT TO VW AS THERE ARE MANY BULLETINS ON THE PROBLEM. *TR

I WAS ON ROUTE 95 IN FLORIDA DRIVING AT NIGHT AND A CAR HAD CUT IN FRONT OF ME I HONK MY HORN AND THEN BOTH OF MY HEADLIGHTS BLEW. I HAD TO PUT FLASHERS ON AND GET OFF NEXT EXIT TO FIND A AUTO PARTS STORE WHERE THEY CHANGE BOTH HEADLIGHT BULBS. I THEN CHECKED FOR RECALLS ON MY CAR FOUND OUT THAT THE HORN WAS FAULTY AND THAT IT COULD CAUSE ELECTRONIC MALFUNCTION AND SHUT ENGINE OFF. HEADLIGHTS ARE WORKING NOW BUT MY HORN DOES NOT WORK. CONTACTED VW ABOUT RECALL AND THEY SAID THAT SINCE I HAD HIGH MILEAGE. THAT I HAD NO WARRANTY ON THE VEHICLE AND THAT I WOULD BE RESPONSIBLE FOR THE REPAIRS. *TR

OUTSIDE TEMP WAS 3 DEGREES F, APPROX 0730 ON 16FEB15 I HAD BEEN ON SHIFT THE CAR HAD NOT BEEN STARTED FOR 48 HRS. I STARTED THE CAR, AND WENT BACK INSIDE THE WORK BUILDING FOR APPROX. 5 MIN. WHEN I WENT BACK TO THE CAR I NOTICED A LARGE FLUID SPILL EMANATING FROM THE BOTTOM OF THE ENGINE COMPARTMENT. I IMMEDIATELY TURNED OFF THE VEHICLE. AFTER REQUESTING ASSISTANCE FROM A CO-WORKER IT WAS DISCOVERED THAT WHEN THE IGNITION SWITCH WAS ACTIVATED LARGE AMOUNTS OF DIESEL FUEL WAS SPURTING FROM THE TOP-FRONT PORTION OF THE FUEL PUMP. THE VEHICLE HAS BEEN LEFT OFF, IS CURRENTLY AWAITING TOW, DIAGNOSTIC AND REPAIR ESTIMATES. *TR

TRAVELING ALONG AT HIGHWAY SPEED. CAR SPUTTERED AND DIED. I WAS ABLE TO PULL OVER AND BE TOWED TO A REPAIR SHOP. APPARENTLY THERE IS A WELL-KNOWN DESIGN FLAW IN THE INTERCOOLER INTAKE PIPE ON ALL VOLKSWAGEN TDI (DIESEL) ENGINES SINCE 2009 THAT CAUSES MOISTURE TO DEVELOP IN THE INTERCOOLER INTAKE PIPE DURING COLD WEATHER. IF ENOUGH MOISTURE COLLECTS IN THIS PIPE, IT WILL GET CHANNELED TO THE ENGINE AND BE FED INTO THE CYLINDERS, CAUSING THE CAR TO SPUTTER AND STALL EXACTLY AS MINE DID - OR TO SIMPLY NOT START ON COLD DAYS. OTHER SIDE EFFECTS OF THIS, ARE SEVERE ENGINE DAMAGE. VW IS WELL AWARE OF THIS ISSUE, AND HAS ISSUED A TSB ABOUT IT. "TSB# 21 11 06 / 2025464 FROZEN AIR CHARGE COOLER" AND THERE IS A REPAIR PART THEY HAVE ALREADY DESIGNED - # COLD WEATHER IC KIT 1K0-198-803-B... HOWEVER, THE PART IS ONLY MADE AVAILABLE UPON REQUEST AND AT OWNER EXPENSE IF OUT OF WARRANTY. THIS IS NOT A WARRANTY ISSUE; THIS IS HUGE SAFETY HAZARD AND A DESIGN FLAW THAT VW NEEDS TO CORRECT FOR ALL OWNERS. THIS SITUATION ALSO, APPARENTLY DOES NOT THROW ANY CODES TO THE VEHICLE COMPUTER, AS THERE ARE NO SENSORS OF ANY TYPE IN THIS INTERCOOLER PIPE. THE ONLY WAY TO DETERMINE THAT THIS IS THE CAUSE, IT TO PUT THE VEHICLE UP, AND REMOVE ONE END OF THIS HOSE AND SEE IF WATER OR 'SLUDGE' DRAINS OUT OF IT, AND THIS PIPE WOULD PROBABLY BE DESTROYED IN ANY FRONT-END COLLISION, AS IT'S FAR FORWARD IN THE ENGINE COMPARTMENT. THERE IS A TON OF INFORMATION ABOUT THIS ALL OVER THE INTERNET. HERE IS A LINK TO JUST ONE OF THE ARTICLES I FOUND AFTER THIS HAPPENED TO ME. HTTP://FORUMS.THECARLOUNGE.COM/SHOWTHREAD.PHP?5574701-TDI-INTERCOOLER-ISSUE-DESIGN-FLAW. *TR

WAS DRIVING OUR 2011 JETTA SPORTWAGEN TDI 25 MPH AND CHECK ENGINE LIGHT AND ENGINE HEATER LIGHT WERE FLASHING. CAR WENT INTO SAFE MODE WITH VERY LITTLE THROTTLE CONTROL. TOOK TO DEALER AND WAS TOLD A CATASTROPHIC FUEL SYSTEM FAILURE OCCURRED AND THE ENTIRE FUEL SYSTEM NEEDS TO BE REPLACED. FOUND OTHER CAR OWNERS ONLINE HAVE HAD SIMILAR ISSUES. IT IS BEING COVERED UNDER WARRANTY BUT IF THIS IS AN ON GOING PROBLEM SHOULD BE ADDRESSED. THIS WOULD BE A HUGE EXPENSE OVER $6,000.00 IF NOT UNDER WARRANTY. *TR