2006 VOLKSWAGEN JETTA Complaints

BRITTLE WIRING INSULATION LOCATED IN THE DOORS. WIRING ON A 2006 VW JETTA, AFTER 50,000 MILES THE USE OF ELECTRONICS AND LIGHTS ON DRIVERS DOOR FAILED. INSPECTION OF THE WIRING HARNESS SHOWED CRACKED WIRING INSULATION, CHAFFED WIRING AND BROKEN WIRES WHERE THE ELECTRICAL HARNESS WERE SUBJECT TO MOVEMENT FROM THE DOOR OPERATION. *TR

AT 72K OUR 2006 VW JETTA TDI BEGAN TO MAKE A LOUD INTERMITTENT RATTLE IN THE ENGINE COMPARTMENT. THE DEALER SAYS THE FLYWHEEL FAILED IT IS A DUAL-MASS FLYWHEEL THAT I SEE SOMETIMES FRAGMENTS, DAMAGING THE HOUSING OR EVEN THE TRANSMISSION. WE HAD NO FRAGMENTING BUT CONSIDER FLYWHEEL FAILURE A SERIOUS SAFETY DEFECT. VW DEALER WANTS TO INSTALL A NEW DMF! *TR

TL*THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT WAS DRIVING APPROXIMATELY 15 MPH, WHEN AN OPPOSING VEHICLE CAUSED A HEAD ON COLLISION. THE AIR BAGS DID NOT DEPLOY UPON IMPACT. THE CONTACT WAS INJURED; HOWEVER, THE SEAT BELT WAS WORN DURING THE CRASH. THE VEHICLE WAS DESTROYED AND TOWED TO A COLLISION CENTER. THE FAILURE MILEAGE WAS 125,201. THE CURRENT MILEAGE WAS 125,201.

TL* THE CONTACT OWNS 2006 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 40 MPH THE CONTACT CRASHED INTO A NEARBY TRUCK CAUSING THE CONTACTS VEHICLE TO ROLL OVER, HOWEVER THE AIR BAGS DID NOT DEPLOY DURING OR AFTER THE CRASH. THE VEHICLE WAS DESTROYED AND THE CONTACT SUSTAINED MINOR INJURIES.THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 39,000.

THE PASSENGER SIDE AIRBAG EXPERIENCES A COMPUTER FAULT EVERY 3 MONTHS OR SO, NEEDING TO BE RESET. INDICATOR LIGHT FOR PASSENGER AIRBAG SHOW AIRBAG IS NOT FUNCTIONING WHILE AIRBAG FAULT IS REGISTERING AND UNTIL RESET AT DEALER. THIS HAS HAPPENED THREE TIMES. IT COSTS ~$200 TO FIX EACH TIME. VW NOW OFFERS A "SUGGESTED" SOFTWARE FIX THAT COSTS $200. THE COSTS OF THESE SIGNIFICANT SAFETY ISSUES SHOULD BE FIXED AT COST TO VW. THE DEALER SAYS THEY HAVE SEEN MANY CARS WITH THIS ISSUE AND HOPES A RECALL WILL BE ISSUED? SHOULDN'T THERE BE A LAW REQUIRING DEALERS TO REPORT TRENDS THEY SEE? *TR

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA TDI. THE CONTACT STATED THAT WHILE DRIVING ON THE INTERSTATE AT APPROX 55 MPH, THE VEHICLE SEEMED TO NOT ACCELERATE, ALTHOUGH SHE WOULD PRESS THE ACCELERATOR PEDAL, THE VEHICLE WOULD NOT MOVE PAST 55 MPH. SHE ACTIVATED THE CRUISE CONTROL AND THEN THE ENGINE REVVED AND THE VEHICLE WAS IN 6TH GEAR BUT MANUALLY SHIFTED DOWN TO 4TH GEAR. SHE TOOK IT OUT OF THE AUTOMATIC SHIFT AND SWITCHED TO MANUAL SHIFT AND DOWNSHIFTED TO LOWER THE RPMS. THE AVERAGE SPEED WAS 30 MPH BECAUSE SHE COULD NOT MOVE ANY FASTER. IT STALLED TWICE ON THE SIDE OF THE ROAD AND COMPLETELY SHUT DOWN WITH NO WARNING LIGHTS PRIOR TO THE FAILURE OR AFTER. SHE CALLED A REPAIR SHOP AND THE MECHANIC TOLD HER TO LET THE VEHICLE COOL DOWN. WHEN SHE DID THAT AND WAS ABLE TOR RESTART, THE CHECK ENGINE LIGHT ILLUMINATED. ABOUT 15 MILES DOWN THE ROAD, THE VEHICLE SHUT DOWN AGAIN. SHE WAITED AGAIN AND WAS ABLE TO RESTART. WHEN DRIVING DOWN HILLS, SHE SHIFTED TO NEUTRAL. SHE ALSO NOTICED THAT THE VEHICLE WAS JERKING. SHE WAS ABLE TO GET TO HER DESTINATION AND THEN TOOK IT TO THE REPAIR SHOP. THE MECHANIC PERFORMED A DIAGNOSTICS TEST BUT COULD NOT PINPOINT THE CAUSE FOR FAILURE. SHE CALLED THE DEALERSHIP AND LEFT A MESSAGE; SHE WAS CURRENTLY AWAITING A RESPONSE. THE CONTACT HAD NOT CALLED THE MANUFACTURER TO-DATE. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE CURRENT MILEAGE WAS APPROXIMATELY 117,993. THE FAILURE MILEAGE WAS APPROXIMATELY 117,000-BK

2006 JETTA TDI 2/ 68K BEGAN SHUDDERING AT STOP LIGHTS. DEALER CLAIMS THE TWO-PIECE FLYWHEEL AND CLUTCH ASSEMBLY IS A WEAK DESIGN. OWNER REPORTS ONLINE CLAIM LOSS OF CLUTCH (PEDAL FALLING TO FLOOR) WHILE DRIVING. MY CAR WILL NOT BE OPERATED UNTIL REPAIRED FOR THE SAKE OF SAFETY. *TR

SEVERAL WIRES IN THE WIRING HARNESS BETWEEN THE PASSENGER COMPARTMENT AND DRIVER DOOR HAVE FAILED, MAKING IT IMPOSSIBLE TO OPERATE WINDOWS, DOOR LOCKS, RELEASE FUEL DOOR, AND RELEASE TRUNK FROM DRIVER DOOR. THERE IS NO MANUAL RELEASE FOR THE FUEL DOOR. THE FAILED WIRING ALSO RESULTS IN A CONSTANT DOOR AJAR INDICATION ON THE INSTRUMENT PANEL AND ILLUMINATION OF THE FRONT DOME AND ENTRY LAMPS. THE WIRE INSULATION AND STRANDS APPEARED TO BE BRITTLE, WHICH RAISES CONCERNS ABOUT OTHER WIRING IN THE VEHICLE. THIS WIRING WAS INSIDE A PROTECTIVE RUBBER BOOT, INTEGRAL TO THE HARNESS, BETWEEN THE CABIN AND DOOR. THERE WAS NO MOISTURE OR DEBRIS WITHIN THE BOOT WHEN IT WAS OPENED TO INSPECT THE WIRING. *TR

TL*THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, SHE HEARD A NOISE COMING FROM THE FRONT END OF HER VEHICLE. WHEN THE VEHICLE WAS PARKED AND TURNED OFF, THE VEHICLE WOULD NOT RE-START. THERE WERE NO WARNING LIGHTS PRIOR TO OR AFTER THE FAILURE. A LOCAL MECHANIC INSPECTED THE VEHICLE AND STATED THAT THE DUAL MASK FLY WHEEL (CONNECTED TO THE CRANKSHAFT ON THE ENGINE) HAD A LARGE HOLE (SIZE OF A SILVER DOLLAR) IN IT. SHE CALLED THE MANUFACTURER BUT WAS TOLD THAT THERE WAS NOTHING THEY COULD DO ABOUT THE FAILURE. THE VEHICLE WAS REPAIRED BY THE MECHANIC. THE CURRENT MILEAGE WAS APPROXIMATELY 79,990. THE FAILURE MILEAGE WAS 78,750.

WHENEVER THE OUTSIDE TEMP REACHES 82 OR ABOVE AND I AM STUCK IN TRAFFIC, I LOSE MY POWERSTEERING (ELECTRIC). THIS HAS HAPPENED SINCE DAY 1 WHEN I PURCHASE THE VEHICLE ON 11/1/2006. I HAVE BEEN TO THE DEALER 3 TIMES. EACH TIME THEY ACKNOWLEDGE THAT THE COMPUTER SHOWS THE FAILURE BUT WILL NOT REMEDY THE CONDITION UNLESS THE IDIOT LIGHT IS ON WHEN I ARRIVE. *TR