2006 VOLKSWAGEN JETTA Complaints

MY CAMSHAFT AND LIFTERS WENT BAD AND WERE REPLACED IN 2015. IT WAS JUST AROUND 100,000 MILES. THEN I FOUND OUT TODAY THAT THEY WERE BAD AGAIN. MY UNDERSTANDING FROM THE MECHANIC IS THAT THIS IS A COMMON PROBLEM, AND LOOKING AT THE VOLKSWAGEN TDI FORUM, THAT YEAR IS PARTICULARLY BAD. THIS CAMSHAFT FAILURE CAUSED A LOSS OF POWER ON THE INTERSTATE DURING A HEAVY TRAFFIC TIME, BOTH TIMES. FIRST INCIDENT WAS ON I-240 IN ASHEVILLE MIDDAY. SECOND TIME WAS TRAVELLING WEST ON I-40 NEAR MORGANTON, NC IN EVENING TRAFFIC. LOSS OF POWER, SMOKING. I COULD BARELY GET OFF THE EXIT. I WAS LUCKY NOT TO HAVE IMPEDED TRAFFIC, BOTH TIMES.

WHILE DRIVING ON THE INTERSTATE JULY OF 2015, GOING ABOUT 70 MPH, MY 2006 VW JETTA SHOOK AND LOST ALL POWER. NO CHECK ENGINE LIGHTS OR ANY LIGHTS AT THAT MATTER CAME ON. PRIOR TO THIS I WOULD NOTICE THAT TAKING OFF SOMETIMES THE TURBO WOULDNT KICK IN AND I WOULD HAVE ABSOLUTELY NO POWER WHILE GETTING UP TO SPEED. THIS ALSO HAPPENED ON THE FREEWAY AND ONCE OFF OF THE FREEWAY I TURNED THE CAR OFF AND THEN ON AND WAS LIKE NOTHING HAPPENED. AFTER I LOST ALL POWER THE SECOND INCIDENT, I TOOK IT INTO THE SHOP AND WAS TOLD THAT 2 CYLINDERS WERE COMPLETELY DESTROYED. HAD TO SPEND 2400 DOLLARS TO HAVE A NEW MOTOR PUT IN AND NOW THE THING IS HAVING PROBLEMS AGAIN. BATTERY LIGHT KEEPS COMING ON AND OFF WITHIN A SECOND AND THERE IS A LOUD TICKING NOISE WHILE IDLING. SOUNDS LIKE A LOUD VACUUM IN THE ENGINE COMPARTMENT WHILE DRIVING IT. NO CHECK ENGINE LIGHTS OR TEMPERATURE GAUGE INCREASES ARE PRESENT. WHILE RESEARCHING RECALLS I NOTICED THERE WERE SOME FOR THE YEAR OF MY JETTA SO WANTED TO SEE WHAT IS GOING ON.

I HAVE TWO MAJOR SAFTEY PROBLEMS THAT COULD HAVE ENDED IN A FATALITY.FIRST MY TRANSMISSION WENT OUT WITHOUT A WARNING WHILE I WAS ON THE INTERSTATE GOING 75 MPH AND A 18 WHEELER WAS BEHIND ME THE CAR DROPT DOWN TO 40 MPH AND I ALMOST GOT REARENDED BY THE SEMI.I HAD THE TRANSMISSION REBUILD.SECOND THING I PULLED OUT OF BURGERKING AND THE CAR HAS NO POWER AND ABOUT GOT TBONED AND THERES NO CHECK ENGINE LIGHT ON.

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE BRAKES CONSTANTLY LOSS PRESSURE AND THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD. THE CONTACT HAD TO PUMP THE BRAKES EACH TIME THE FAILURE RECURRED WITHOUT WARNING. THE CONTACT REPORTED THE CONCERN TO THE DEALER AND THE MANUFACTURER WHO INDICATED THAT THE VEHICLE WOULD NEED TO BE FURTHER TESTED TO DETERMINE A REPAIR SOLUTION. THE FAILURE MILEAGE WAS NOT AVAILABLE.

MY VOLKSWAGEN JETTA TDI 2006 GOT THE PRNDS FLASH OF DEATH, AND I FOUND OUT IT WAS THE MECHATRONIC UNIT WHEN I TOOK IT TO THE SHOP. I WAS DRIVING ON THE HIGHWAY GOING 75MPH WHEN THE FLASHES STARTED TO OCCUR. I COULDN'T GIVE MY ENGINE ANY POWER AND I STARTED TO DECELERATE AT A QUICK PACE, AND THE VEHICLE BEHIND ME ALMOST HIT ME. THIS IS A MAJOR SAFTEY ISSUE FOR ME AND FOR ALL OTHER OCCUPANTS ON THE HIGHWAY, BECAUSE MY FAULTY CAR COULD HAVE CAUSED A MAJOR ACCIDENT, THAT COULD HAVE RESULTED IN MANY INJURIES. I WANT TO BRING THIS ATTENTION TO THE NHTSA TO, PROVIDE ME WITH MORE INFORMATION AS TO WHY THE VEHICLE IS FAULTY, AND THE AMOUNT OF TROUBLE I WOULD BE IN IF I DIDN'T MANAGE THIS SITUATION LIKE I DID TO PROTECT MYSELF AND EVERYONE ELSE.

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 25 MPH, THE TRANSMISSION SHIFTED FROM DRIVE INTO NEUTRAL INDEPENDENTLY WITHOUT WARNING. THE ENGINE WAS TURNED OFF. AFTER RESTARTING, THE VEHICLE RESUMED NORMALLY. THE FAILURE RECURRED FIVE TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 199,000.

TRANSMISSION HARD SHIFTING WITHIN 15 MINUTES OF VEHICLE START. LOUD CLUNK NOISE THRU 4 GEARS. CAR IN GARAGE. OST 50-75 DEGREES. AIR BAG LIGHT COMES ON WITH WIRING EXTENSION COMPLETED.

ORIGINALLY, THE TURBO WOULD LOSE BOOST AND THE ENGINE WOULD LOSE POWER. AFTER SOME TIME, PARTICULARLY DURING WET WEATHER, THE CAR WILL SUDDENLY VIBRATE, JOLT, AND THEN THE ENGINE WARNING CHIME SOUNDS. THE TACHOMETER DROPS TO ZERO, THE OIL PRESSURE LIGHT COMES ON, THE STABILITY CONTROL SHUTS OFF, THE GLOW PLUG LIGHTS FLASH, REAR WINDOW DEFROSTER WILL NOT WORK, CRUISE CONTROL WONT WORK, AND IF THE CAR IS SHUT OFF IT WILL NOT RESTART. THIS IS PARTICULARLY DANGEROUS DURING SNOW OR RAIN, AS THE CAR LOSES TRACTION CONTROL DURING WEATHER IN WHICH IT IS MOST IMPORTANT TO HAVE. ALSO, IF THE CAR DIES AND IS ON THE SHOULDER OF THE ROAD, DURING RAIN OR SNOW, THERE IS POOR VISIBILITY AND IT INCREASES THE RISK OF SOMEONE HITTING THE DISABLED CAR. I HAVE SEEN MANY MENTIONS OF THIS SAME EFFECT HAPPENING ON OTHER 2006 TDI MODELS, AND IT SEEMS TO BE A RECURRING ISSUE WITH THIS PARTICULAR MODEL AND ENGINE TYPE. THE ROOT CAUSE APPEARS TO BE AN ELECTRICAL HARNESS THAT RUNS IN THE ENGINE COMPARTMENT CHAFING OVER TIME, WHICH HAPPENS OUTSIDE OF THE WARRANTY PERIOD, BUT CAUSES SIGNIFICANT SAFETY CONCERNS WITH ITS FAILURE MODE.

AUTOMATIC TRANSMISSION SHIFTS HARD AND SOMETIMES FAIL TO SHIFT. THE IS A MAJOR SAFETY CONCERN WHILE OPERATING THE VEHICLE.

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN JETTA. WHILE DRIVING 30-40 MPH, THERE WAS A SUDDEN LOSS OF POWER. THE DEALER STATED THAT THE ENGINE CONTROL UNIT FAILED AND CAUSED THE VEHICLE TO GO INTO LIMP MODE. AS A RESULT, THE ENGINE CONTROL UNIT SHUT OFF THE FUEL. THE CONTACT STATED THAT THIS WAS A DESIGN BY THE MANUFACTURER AS A SAFETY FEATURE, AND THAT THE VEHICLE OPERATED AS INTENDED. THE VEHICLE WAS REPAIRED; HOWEVER, THE CONTACT WAS CONCERNED THAT THE FAILURE WAS NOT ADDRESSED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 42,000. ...UPDATED 04/12/16 *BF UPDATED 04/13/16.*JB *JS *JS *TR