2010 VOLKSWAGEN JETTA Complaints

EGR VALVE: CHECK ENGINE LIGHT CAME ON, CODE P0401 FOR EGR VALVE. DEALER SAID THEY TESTED IT AND IT WAS "STICKING". NOT COVERED UNDER EMISSIONS WARRANTY. FAILED AT 45K MILES. VW PART NUMBER IS 03L-131-501-K. $700 REPAIR. *TR

SLOWLY TURNING RIGHT OUT OF PARKING LOT ON COMPLETION OF TURN CAR STALLED WITH NO INITIAL INDICATION. SHIFTED INTO PARK AND RESTARTED WITH NO PROBLEM. THIS HAS HAPPENED TWICE BEFORE PULLING INTO HOME DRIVEWAY AND STOPPING AT A STREETLIGHT. *TR

TRAVELING HOME ON INTERSTATE HIGHWAY/CHECK ENGINE LIGHT CAME ON,,,,,CAR MADE FUNNY NOISE UP FRONT,,,,LOST ACCELERATION. PULLED OFF ONTO AN OFF RAMP,,,,OFF TO SIDE OF ROAD. .I TURNED VEHICLE OFF. WOULD NOT RESTART. CALLED TOW TRUCK TO BRING IT HOME. NEXT MORNING HAD IT TOWED TO DEALERSHIP WHERE PURCHASED. TOLD IT WAS A "BAD DIESEL" PROBLEM....(I'D PURCHASED 1/2 TANK DIESEL FUEL 24 HRS PRIOR TO THIS AT STATION I'D NOT BEE TO BEFORE.) SUBSEQUENTLY THEY DRAIN TANK, REPLACED FUEL FILTER, STILL WOULDN'T TURN OVER. SAID THE HIGH PRESSURE FUEL PUMP WAS DESTROYED. GELLED UP STUFF IN FILTER,,,WHAT LOOK LIKE RUST FLAKES.... ESTIMATE FOR REPAIR INTO THOUSANDS.....CALLED INSURANCE CO. AND STARTED A CLAIM FOR LOSS.CALLED VW USA. TO REPORT THIS . LAST NITE GOT PHONE CALL FROM VW LADY SAYING THE WERE GOING TO REPLACE MY WHOLE FUEL SYSTEM AND THEY WOULD COVER COST ! GOOD FOR ME , BUT NOT SURE I WANT TO KEEP A CAR THAT IS SO TOUCHY ABOUT IT'S FUEL. DEALER SHIP CALLED TODAY TO SAY THE SAME ABOUT REPAIR....AND FELT IT WAS AN ACCUMULATION OF DAMAGE FROM WATER IN FUEL.... HOW IS ONE TO KNOW WITH CONFIDENCE WHAT EXACTLY THEY ARE PUMPING FROM A DIESEL FUEL PUMP. WILL PROBABLY TRADE CAR......CAR AT SHOP FOR 1 1/2 WEEKS NOW. ...THIS HAS BEEN AN EYE OPENER. PHONE CALL LAST. *TR

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. THE CONTACT WAS TRAVELING 70 MPH WITH THE CRUISE CONTROL ACTIVATED WHEN THE TRANSMISSION LOST POWER. THE CHECK ENGINE LIGHT ILLUMINATED AFTER THE FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE DEALER CONFIRMED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 92,517. UPDATED 08/07/12*LJ UPDATED 08/07/12

FIRST INCIDENCE: DRIVING 45 MPH, GLOW PLUG LIGHT STARTS FLASHING, CAR GOES INTO LIMP MODE. DRIVE SLOWLY HOME. CALL DEALERSHIP, TOLD TO RECYCLE (TURN OFF/ON). IF LIGHT GOES AWAY SHOULD BE OKAY THEY SAID. TOOK TO DEALER TO CHECK OUT TO BE SURE. THEY FOUND NOTHING. A WEEK LATER WAS ON THE HIGHWAY AND NEEDED TO ACCELERATE AND FLASHING LIGHT AND LIMP MODE AGAIN. PULLED OVER, TURNED OFF AND ON. DROVE SLOW TO THE DEALER, CAR VERY SLUGGISH. IT IS AT THE DEALER NOW AND THEY ARE GOING TO REPLACE THE HIGH PRESSURE FUEL PUMP (HPFP). *TR

MY 2010 JETTA TDI BROKE DOWN ON ME WHILE I WAS THREE HOURS AWAY FROM MY HOME. THE SERVICE REP. SAID HE HAS HAD A FEW CARS COME IN WITH THE SAME PROBLEM. HE STATED IT WAS DUE TO BAD FUEL OR WATER IN THE FUEL LINE. I KNOW I HAD PUT DIESEL IN WHEN I FILLED UP THAT MORNING. HE STATED WE HAD PROBABLY RECEIVED BAD FUEL WHEN WE HAD FILLED UP. WE WERE ON A ROAD TRIP (8HRS ONE WAY) AND I HAD DRIVEN ABOUT 5 HOURS BEFORE IT DIED!!! WE WERE TRAVELING AT APPROX. 65 MPH WHEN THE FLASHING GLOW PLUG LIGHT INDICATOR BEGAN TO FLASH. THE CAR THEN STARTED TO LOSE ACCELERATION AND WE PULLED OVER WHERE THE ENGINE FINALLY SHUT DOWN AND IT WOULD NOT RESTART. I HAD TO HAVE THE CAR TOWED TO THE CLOSEST VW DEALER. THEY ARE REPLACING THE ENTIRE FUEL SYSTEM. HOW AM I SUPPOSED TO KNOW WHAT FUEL STATION HAS GOOD DIESEL? I KNOW THE FAULT WAS NOT MINE. I CAN'T AFFORD TO BE WITHOUT MY CAR AGAIN FOR 2 TO 3 WEEKS. AS SOON AS I GET MY CAR BACK I WILL BE TRADING IT IN EVEN THOUGH I AM UPSIDE DOWN ON MY LOAN. I LOVED MY TDI BUT WITH THIS ISSUE ALWAYS BEING A THREAT I WILL NOT BE ABLE TO RECOMMEND THIS CAR TO ANYONE. VW NEEDS TO FIX THIS ISSUE. *TR

CHECK ENGINE LIGHT CAME ON WHILE DRIVING JETTA TDI TO/FROM WORK. TOOK IT TO DEALER AND THEY REPORTED IT WAS THE HIGH PRESSURE FUEL SENSOR (VEHICLE STORING FAULT P0191). THEY REPLACED THE SENSOR (THINKING IT FAULTY), BUT THE FOLLOWING DAY THE CHECK ENGINE LIGHT CAME ON AGAIN. RETURNED THE VEHICLE TO THE DEALER AND THEY REPORTED THE SAME FAULT. DEALER KEPT VEHICLE FOR INVESTIGATION. THEIR INVESTIGATION REVEALED METAL SHAVINGS IN THE FUEL SYSTEM. THE VEHICLE REMAINED WITH THE DEALER BETWEEN 03/23-03/27 WHEREIN THEY REPLACED THE ENTIRE FUEL SYSTEM. ON THE MORNING OF 06/29 WENT TO START CAR AND COULD NOT GET IT TO START. VEHICLE WAS TOWED TO DEALER AND THE REPLACEMENT HIGH PRESSURE FUEL PUMP WAS DETERMINED FAULTY. *JS

WHEN I STARTED MY CAR, A 2010 JETTA SEDAN TDI, IT STARTED MAKING A STRANGE NOISE, BUT STILL RAN. I TRIED TO DRIVE IT OVER TO THE VOLKSWAGEN DEALER WHICH WAS APPROXIMATELY 2 MILES AWAY. I PULLED OUT ONTO THE HIGHWAY AND ACHIEVED A SPEED OF APPROXIMATELY 30MPH. THE CAR CONTINUED TO MAKE THE NOISE AND BEGAN TO LOSE POWER WITHIN A HALF MILE. I PULLED INTO THE PARKING LOT OF A SHOPPING CENTER AT WHICH TIME THE ENGINE DIED AND WOULD NOT RESTART. THE CAR HAD TO BE TOWED TO THE VOLKSWAGEN DEALER, WALLACE IMPORTS OF JOHNSON CITY, TN. IT TOOK THEM APPROXIMATELY 1 1/2 WEEKS TO GET THE PARTS IN AND REPAIR THE VEHICLE. THE SERVICE REPRESENTATIVE EXPLAINED TO MY HUSBAND THAT THERE WAS A CATASTROPHIC FAILURE OF THE HIGH PRESSURE FUEL PUMP, WHICH RESULTED IN METAL FRAGMENTS CONTAMINATING THE ENTIRE FUEL SYSTEM. AS A RESULT, HE WAS TOLD THAT EVERY PART WHICH CAME IN CONTACT WITH THE FUEL HAD TO BE REPLACED, INCLUDING THE FUEL TANK, FUEL LINES, FILTERS, FUEL INJECTORS, AND MANY OTHERS. THERE WAS A TWO PAGE LIST OF THE PARTS USED TO FIX MY CAR. MY CONCERN IS THAT THIS COULD HAPPEN AGAIN RESULTING IN AN UNSAFE SITUATION. FURTHER, WE ALSO HAVE 2010 JETTA TDI SPORTSWAGEN AND HAVE CONCERNS OF THE SAME PROBLEM OCCURRING AT HIGHWAY SPEEDS SINCE MY HUSBAND ROUTINELY MAKE ROUND TRIPS OF 230 MILES AT LEAST TWICE A WEEK TRAVELING MAINLY ON THE INTERSTATE. *TR

THIS WAS A HIGH-PRESSURE FUEL PUMP FAILURE. AT 03:52 ON 060812 I FILLED MY CAR'S TANK WITH 9.4 GALLONS OF DIESEL FUEL AT THE CAMINO PETROLEUM STATION AT EL CAMINO REAL 698, SOUTH SAN FRANCISCO, CA. (MILEAGE: 43375.) NOTE: I HAVE NEVER MIS-FUELLED THIS VEHICLE; I HAVE BEEN A COMMERCIAL MOTOR VEHICLE DRIVER FOR 25 YEARS. AT APPROXIMATELY 08:00, WHILE DRIVING SOUTHBOUND ON CA INTERSTATE 5 AT EXIT #262, THE GLOW PLUG INDICATOR LIGHT BEGAN TO FLASH AND THE ENGINE'S POWER OUTPUT DECREASED. I PULLED INTO THE BUTTON WILLOW (CALIFORNIA) REST STOP, THEN INTO A PARKING STALL WHEREIN THE ENGINE STOPPED RUNNING; IT WOULD NOT START AGAIN. THE CAR WAS TOWED TO THE FAMILY AUTO GROUP VOLKSWAGEN DEALERS SHOP (IN BAKERSFIELD, CA) WHERE HIGH-PRESSURE FUEL PUMP FAILURE WAS DIAGNOSED. I HAVE BEEN INFORMED BY FAMILY AUTO GROUP'S SERVICE REPRESENTATIVE THAT VOLKSWAGEN'S POWER TRAIN WARRANTY WILL COVER THE COST OF REPAIRS. IT IS MY UNDERSTANDING THAT THE CAR'S ENTIRE FUEL SYSTEM (FROM THE FUEL TANK TO THE FUEL INJECTORS) HAS BEEN REPLACED DUE TO SYSTEM-WIDE CONTAMINATION BY METAL PARTICLES FROM THE HIGH-PRESSURE FUEL PUMP. THE COST OF REPAIRS ARISING FROM THIS SORT OF THING IS ESTIMATED TO BE FROM $6,000.00 TO $10,000.00 IN PARTS AND LABOR. *JB

I PURCHASED MY BRAND NEW VW JETTA FROM THE DEALERSHIP LOT. LESS THAN 4 WEEKS LATER WHEN THE CAR WAS IN THE DRIVEWAY I STARTED IT, AND AS I PRESSED THE GAS DOWN THE CAR BEGAN TO MOVE (IN A SPUTTERING/JERKING TYPE OF MOVEMEN)T BUT IT WAS NOT ABLE TO GO MORE THAN 7 FEET BEFORE IT STALLED OUT,, AND THE RPM'S WERE HIGH AND THE CAR JUST MOVED LIKE IT WAS NOT ABLE TO PROPERLY ACCELERATE, IT STALLED OUT BEFORE THE END OF MY DRIVE WAY. I STARTED IT AGAIN AND IT DROVE PROPERLY, THIS EXACT INCIDENT OCCURRED AT LEAST1- 2 TIMES A WEEK ON A COLD START. I TOOK IT TO DEALERSHIP, NOTHING FOUND ON DIAGNOSTICS.THEN AT LEAST EVERY 1-2 MONTHS I TOOK IT TO DEALERSHIP, NO PROOF ON DIAGNOSTICS .NEXT A RECALL & WORK WAS DONE. SAME PROBLEM OCCURRED AGAIN AND AGAIN. TOOK IT BACK. THEY SAID THEY COULD NOT FIND A SOLUTION BECAUSE ITS NOT REPEATING THE STALLING WHEN ITS AT DEALERSHIP. I AM STILL HAVING THE ISSUE OF MY CAR STALLING OUT WHEN DRIVING, IT IS A SAFETY ISSUE. IT IS DANGEROUS DRIVING A CAR THAT STALLS OUT WHILE YOU ARE ON THE ROAD. SINCE THE COLD START ISSUES I HAVE ALSO HAD IT STALL OUT ON THE ROAD, IN AN INTERSECTION. THIS CAR IS STILL REPEATING THE STALLING. I CANNOT GET ANY ANSWERS ON HOW TO FIX IT DUE TO NO "PROOF" ON DIAGNOSTICS CHECK. I FEEL UNSAFE IN MY CAR. IT STARTS TO ACCELERATE THEN SHUTS OFF. THIS IS NOT ACCEPTABLE AND HASNT EVER BEEN PROPERLY FIXED EVEN THOUGHVW CORPORATE HAS A CASE ON THE ISSUES OF MY CAR. *TT