2005 VOLKSWAGEN JETTA Complaints

DRIVING ON INTERSTATE VEHICLE SUDDENLY LOST ALL POWER JUST LIKE IGNITION TURNED OFF. ALMOST WAS REAR ENDED DUE TO SUDDEN SLOWING DOWN. HAD TO PULL OVER TO LEFT LANE ON VERY BUSY INTERSTATE BECAUSE I WAS IN CARPOOL LANE. HAD LIMITED SHOULDER AREA TO STOP. NO POWER STEERING OR BRAKES. ONCE STOPPED TRIED TO START ENGINE. IT WOULD TURN OVER BUT NOT START. CONTINUED ATTEMPTS CAUSED ENGINE PRESSURE WARNING. HAD TO BE TOWED FROM BUSY INTERSTATE LEFT LANE. NOW THE CAR HAS FAILED LIKE THIS WHILE ON THE ROAD 3 TIMES. THERE IS NO WARNING OR INDICATION OF FAILURE. CAR JUST DIES. ALL THREE INCIDENTS WHERE WHILE DRIVING DOWN THE ROAD. 2 WERE ON HILLS NEAR STOP SIGN AND I HAD TO ROLL VEHICLE BACK AROUND OTHER CARS TO SAFE PLACE. *TR

LEFT TURN SIGNAL, DRIVERS DOOR/ALL REMOTE WINDOW SWITCHES, TRUNK/FUEL DOOR RELEASE, DRIVERS DOOR LOCK KEY FOB LOCKING OF DRIVERS DOOR/DRIVERS DOOR INTERNAL LOCK ARE ALL INOPERATIVE. OCCASIONALLY, THE CABIN INTERIOR LIGHT REMAINS ON WITH A DRIVERS "DOOR OPEN" INDICATION ON THE INSTRUMENT CLUSTER EVEN THOUGH THE DRIVERS DOOR IS CLOSED AND SECURE (BUT UNABLE TO BE LOCKED FROM THE DRIVERS DOOR LOCK SWITCH IN THE PASSENGER CABIN). THE PRIMARY SAFETY ISSUE RELATED TO THIS PROBLEM IS THAT THE LEFT TURN SIGNAL DISPLAYS ON INSTRUMENT CLUSTER, BUT DOES NOT ACTIVATE ON THE REAR TURN SIGNAL LIGHT AND DRIVERS WINDOW (ALONG WITH ALL OTHER WINDOWS REMOTELY CONTROLLED ON DRIVERS DOOR) ARE INOPERATIVE IF NEEDED TO MAKE A HAND TURN SIGNAL OR EGRESS FROM THE VEHICLE IN AN ACCIDENT (OR SUBMERGED UNDER WATER FOR AN EGRESS). DEALER AND MANUFACTURE BOTH REFUSED TO COVER THE REPLACEMENT COST OF THE FAULTY PART. I HAVE PERFORMED EVERY MANUFACTURE REQUIRED SERVICE REQUIRED (ALL DOCUMENTED) SINCE PURCHASING THIS VEHICLE IN THE INTEREST OF SAFETY AND RELIABILITY. IT HAD VERY LOW MILEAGE ON MY PURCHASE IN EARLY 2007. PER VW TECHNICAL SERVICE BULLETIN, GROUP 97: 09-01 (201-7600), FEBRUARY 26, 2009, STATES THAT THE DRIVERS DOOR WIRING HARNESS WAS MANUFACTURED 80 MM TOO SHORT. THIS RESULTS IN PUTTING STRAIN ON THE NUMEROUS WIRES IN THIS HARNESS NEAR THE DOOR BOOT AND CONNECTOR PLUG CAUSING WIRES TO BREAK AND/OR ELECTRICALLY SHORT. MY VEHICLE WAS AFFECTED BY THE VIN RANGE OF THIS MANUFACTURES SERVICE BULLETIN. THE NEW REPLACEMENT DRIVERS DOOR ELECTRICAL HARNESS ARE NOW 80 MM LONGER THAN THE ORIGINALLY MANUFACTURED (INSTALLED) FAULTY PART THAT THE MANUFACTURE IS UNWILLING TO REPLACE AT THEIR COST (PARTS OR LABOR). I WILL PAY FOR MY REPAIR PERSONALLY, BUT BELIEVE THAT THE SAFETY ASPECT OF THIS FAULTY PART COULD COMPROMISE THE SAFETY OF THE DRIVER AND OCCUPANTS IN ADDITION TO OTHER MOTORIST. *TR

AS MY DAUGHTER WAS DRIVING DOWN THE ROAD HER DRIVER SIDE WINDOW SUDDENLY DROPPED INTO THE DOOR, CREATING A LOUD NOISE AND SERIOUS DRIVING DISTRACTION. SHE REPORTED SWERVING AND SLAMMING ON HER BRAKES AS SHE DIDN'T KNOW WHAT HAD HAPPENED. IT TURNS OUT THIS IS A KNOWN DEFECT, SEE TECHNICAL BULLETIN 64-08-06 AND THE WARRANTY WAS EXTENDED TO COVER THIS PART, BUT WE WERE NEVER NOTIFIED. APPARENTLY, THERE WAS NO RECALL NOTICE, DESPITE KNOWING OF THIS ONGOING PROBLEM, ONLY A WARRANTY EXTENSION AFTER THE PROBLEM OCCURS. THIS HOW NOW EXPIRED. SHE WAS DRIVING DOWN THE ROAD, IN THE SNOW, AND THIS COULD HAVE CAUSED A SERIOUS ACCIDENT. *TR

TL* THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE VEHICLE LOST ACCELERATION POWER WHILE ATTEMPTING TO MERGE INTO HIGHWAY TRAFFIC. THE FAILURE WAS EXPERIENCED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS FOUND THAT THE TRANSMISSION VALVE BODY HAD FAILED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 86,000.

SWITCHES IN THE DRIVER'S DOOR HAVE BECOME GRADUALLY (AND INTERMITTENTLY) INCREASINGLY INOPERABLE. DOOR LOCK/UNLOCK, WINDOWS UP/DOWN, WINDOW LOCK, SIDE-VIEW MIRROR ADJUSTMENT, AND TRUNK RELEASE ALL HAVE STOPPED WORKING EITHER ENTIRELY OR INTERMITTENTLY. THE MAJOR SAFETY RELATED ISSUES ARE: 1. NON-FUNCTIONAL SWITCHES ARE A DISTRACTION WHILE DRIVING - CAN'T CLOSE WINDOW AT TOOL BOOTH, ETC. 2. THE INABILITY TO ADJUST SIDE-VIEW MIRRORS. 3. THE INABILITY TO LOCK REAR WINDOWS COMBINED WITH HAVING SMALL CHILDREN RIDING IN THE BACK SEAT. 4. THE INABILITY TO UNLOCK REAR DOORS (WITHOUT USING THE KEYLESS REMOTE - ONE OF WHICH HAS ALSO STOPPED WORKING) TO GET TO THE KIDS IN THE BACK IS A CHALLENGE AND POTENTIALLY HAZARDOUS. 5. THE DOOR SWITCH THAT INDICATES TO THE ON-BOARD COMPUTER WHEN THE DOOR IS OPEN OR CLOSED ALSO IS NOT FUNCTIONAL, CAUSING NIGHTTIME LIGHTING ISSUES WHEN PARKED AND OPENING DOOR. *TR

MY 2005 VW JETTA GLI STALLED SUDDENLY WHILE I WAS DRIVING @ 35-MPH. AFTER PULLING OVER AND OPENING THE HOOD TO ASSESS DAMAGE, I TURNED THE IGNITION KEY BUT ALL I HEARD WAS THE STARTER BEING ENGAGED. ONCE THE CAR WAS TOWED TO AN INDEPENDENT REPAIR SHOP, THE TECHNICIAN INFORMED ME THE TIMING BELT BROKE/SNAPPED. I WAS SKEPTICAL BECAUSE MY OWNER'S MANUAL SAYS TIMING BELTS SHOULD BE REPLACED AT 110,000 MILES ACCORDING TO VW'S RECOMMENDED MAINTENANCE SCHEDULE. DURING REPAIRS, THE TECHNICIAN SAID THAT MY VALVES WERE BENT BECAUSE THE 1.8T IS AN INTERFERENCE ENGINE WHICH MEANS THAT CAMS, ROCKERS AND LIFTERS MUST BE REMOVED IN ORDER FOR THE CYLINDER HEAD TO BE SENT TO A MACHINE SHOP FOR ADDITIONAL REPAIRS. TOTAL COSTS = $3,865.66. THERE WAS A CLASS ACTION LAWSUIT AGAINST VW TIMING BELTS BUT I WAS DENIED REIMBURSEMENT BY THE ADMINISTER/CUSTODIAN CLAIMS WERE NO LONGER ACCEPTED AFTER 2009. I SPOKE WITH [XXX] AT VW CUSTOMER SERVICE 1-800-822-8987 WHO SAID THERE ARE NO TIMING BELT RECALLS FOR MY VEHICLE. PLEASE INVESTIGATE THIS CONCERN AND SEE OTHER IDENTICAL COMPLAINTS AT HTTP://WWW.TOPIX.COM/FORUM/AUTOS/VOLKSWAGEN/T33RHDPDVBRPO8D2P/P3 FOR MORE INFORMATION. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. THE CONTACT STATED THAT SHE NOTICED THE TRUNK FAILED TO CLOSE. THE CONTACT HAD TO SLAM THE TRUNK SEVERAL TIMES IN ORDER FOR IT TO CLOSE PROPERLY. ADDITIONALLY, THE FRONT DRIVER SIDE DOOR FAILED TO LOCK AND THE OPEN DOOR WARNING LIGHT ILLUMINATED CONSTANTLY. THE CONTACT ALSO STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE JERKED FORWARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MECHANIC WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 80,375. ... UPDATED 02/28/13 *BF UPDATED 03/11/13

HI, SO MY 2005.5 2.5L VOLKSWAGEN JETTA STARTED MAKING NOISES UPON ACCELERATION AND THE ENGINE WOULD SHIFT QUITE HEAVILY DURING IDLING. THE CHECK ENGINE LIGHT WENT ON AND I TOOK THE CAR TO DEALERSHIP. APPARENTLY, THERE IS AN ISSUE WITH THE TIMING CHAINS OF THE ENGINE. NEVER MISSED A MAINTENANCE, AFTER ONLY 68,000 MILES IT DOESN'T SEEM OKAY THAT TIMING CHAINS ARE ALREADY AFFECTED. AFTER LOOKING AT A FEW FORUMS ONLINE, IT SEEMS THAT THIS IS A VERY COMMON PROBLEM FOR VOLKSWAGEN JETTAS FROM THAT TIME. PLEASE INVESTIGATE! THANK YOU. *TR

DOOR LOCKS INTERMITTENTLY FAIL TO LOCK OR UNLOCK, EITHER BY THE KEY FOB BUTTON OR DOOR PANEL LOCK/UNLOCK SWITCH. I BELIEVE THIS IS A SAFETY ISSUE AS IT MAY IMPEDE ACCESS TO THE VEHICLE IN THE EVENT OF AN ACCIDENT. *TR

FOR CLARIFICATION, MY CAR IS A MARK 5 2005.5 NEW JETTA, NOT A MARK 4 2005 JETTA. WHEN YOU SHUT THE TRUNK, IT SEEMS TO CLOSE COMPLETELY. IT STAYS IN THE CLOSED POSITION AND CANNOT BE PULLED OPEN. HOWEVER, ONCE YOU DRIVE OFF, THE TRUNK MAY OPEN SUDDENLY AND YOU CANNOT SEE ANYTHING BEHIND YOURSELF BECAUSE THE TRUNK HOOD OBSTRUCT YOUR REAR WINDOW. THIS HAS HAPPENED A COUPLE OF TIMES TO ME, AND MANY OTHER JETTA OWNERS CAN BE SEEN SAYING THAT THEY HAVE THE SAME PROBLEM ON ONLINE FORUMS. SOMETIMES, THE TRUNK CANNOT BE CLOSED AT ALL. YOU CAN STAND THERE AND SHUT THE TRUNK OVER AND OVER AGAIN, AND IT WILL NOT LATCH. *TR