2006 VOLKSWAGEN JETTA Complaints

DRIVER SEAT LOWER RIGHT BACK OVERHEATED. BURNT A HOLE IN THE SEAT AND MELTED THE COAT I WAS WEARING. SMELL OF BURNING IN THE CAR AND INTENSE HEAT ON MY BACK. TURNED OFF THE SEAT HEAT. WHEN I ARRIVED AT MY DESTINATION, NOTICED THE BURN IN THE SEAT AND LATER NOTICED A BURN ON MY COAT.. INTERIOR OF THE CAR IS WELL MAINTAINED, NEVER FLOODED OR ABUSED. NOW I HAVE A CAR DRIVER SEAT THAT IS BADLY DAMAGED, A RUINED COAT AND SCARED TO OPERATE THE CAR OR TO PARK IN MY GARAGE IN FEAR OF A FIRE THAT COULD BURN DOWN MY HOUSE AND CAR PUTTING MYSELF AND FAMILY IN HARMS WAY. I HAVE NOTICED SEVERAL VW CARS IN THE PAST WITH THE SAME PROBLEM IN THE SAME SPOT AND WAS ALWAYS THANKFUL THAT IT WAS NOT MY CAR. NOW IT IS MY CAR WITH THE SAME PROBLEM. CALLED THE VW DEALER, AND THEY SAID THAT THERE IS NOT A RECALL ON THIS. THIS IS A PROBLEM THAT CAN CAUSE A BAD BURN ON A PERSON. I AM GLAD I HAD A COAT ON WHILE DRIVING, OTHERWISE I WOULD HAVE HAD TO SEEK MEDICAL TREATMENT FOR THE BURN. WOULD LIKE TO SEE VW CORRECT THE PROBLEM AND REPLACE THE SEAT AT NO CHARGE TO THE OWNERS. THIS IS A PREVENTABLE PROBLEM THAT NEEDS CORRECTED. *TR

AFTER REPLACING THE CAM SHAFT AND TIMING BELT I TOOK THE CAR FOR A TEST DRIVE. THE PROBLEMS WERE APPARENT, A HARD SHIFT FROM A STOP INTO FIRST GEAR AND HARD SHIFTS ALL THE WAY TO 4TH GEAR. FROM A FULL STOP IT WILL NOT RESPOND TO THE ACCELERATOR AND IF IT DOES IT JOLTS. MULTIPLE TIMES CROSSING TRAFFIC THE ACCELERATOR DOES NOT RESPOND, AND I HAVE NEARLY BEEN HIT MULTIPLE TIMES. I BROUGHT IT INTO A SERVICE SHOP AND THEY HAVE SAID IT IS THE MECHATRONICS UNIT THAT CONTROLS THE TRANSMISSION. I WAS TOLD THAT IS AN ISSUE IN MANY VEHICLES LIKE MINE, AND TO REPORT IT TO NHTSA AND VOLKSWAGEN. *TR

WENT TO START CAR WAS MISFIRING CHECK ENGINE LIGHT CAME ON TOWED TO A SHOP THE TOLD ME MY TIMING CHAIN JUMPED AND IT WAS 2500 DOLLARS TO FIX. *TR

VOLKSWAGEN JETTA 2006 SAGGING HEADLINER FABRIC FROM HEADLINER. THE SEPARATED HEADLINER FABRIC CREATES A VISIBILITY OBSTRUCTION AND POSSIBLY A DANGER TO THE DRIVERS VISIBILITY. IT SHOULD BE A SAFETY ISSUE. I CONTACTED VOLKSWAGEN CUSTOMER SERVICE BUT WAS TOLD THAT WARRANTY HAD EXPIRED, REPAIR WOULD BE UP TO ME. COST TO FIX IT AT THE DEALER IS HOWEVER OVER $1000. *TR

WHILE DRIVING THE TRANSMISSION SLIPS OR WILL NOT CHANGE GEARS WHILE THE GAS PEDAL IS BEING STEPPED ON ALSO AFTER A STOP IT WILL NOT ENGAGE AT TIMES IT STAYS ON 5 GEAR WHILE MOVING SLOWLY AND WILL NOT DOWN SHIFT. *TR

WAS GETTING HEAD ACHES WHEN DRIVING THE CAR AND SITTING IN TRAFFIC OR AT A STOP LIGHT. SMELLED A SULFUR LIKE SMELL FROM THE ENGINE COMPARTMENT. COULD HEAR LOUD BLOWING SOUNDS ON ACCELERATION. DEALERSHIP FOUND AN EXHAUST LEAK IN THE BACK OF THE DIESEL MOTOR FROM THE EGR COOLER ASSEMBLY. THE ENGINE WAS BLOWING SOOT IN TO THE ENGINE COMPARTMENT AND IT COULD BE HEARD AND SMELLED THROUGH THE FIREWALL. THIS IS A DIESEL SO THE EXHAUST CONTAINS CARCINOGENIC CHEMICALS. DIESEL EXHAUST CONTAINS A NUMBER OF POTENTIALLY TOXICOLOGICALLY RELEVANT ORGANIC COMPOUNDS ACCORDING TO THE EPA THAT HAVE HUMAN HEALTH HAZARDS ASSOCIATED WITH EXPOSURE. THE EGR COOLER IS NOT COVERED UNDER THE 8 YEAR 80K FEDERAL EXHAUST EMISSION WARRANTY EVEN THOUGH IT IS A MANDATED PART OF THE EXHAUST SYSTEM AS PART OF THE EXHAUST GAS RECIRCULATION SYSTEM. A SHAFT GOING THROUGH THE WALL OF THE EGR COOLER CONNECTING TO A BUTTERFLY VALVE USED TO DIVERT THE EXHAUST GASES IN TO THE COOLER HAS A FAULTY SEAL THAT WILL FAIL AND ALLOW THE EXHAUST GAS TO EXIT THE EXHAUST IN TO THE ENGINE COMPARTMENT AND GET IN TO THE PASSENGER COMPARTMENT. THIS IS NOT ONLY AN EPA VIOLATION BUT A HEALTH HAZARD TO EVERY VW TDI OWNER OR PASSENGER. TO REPAIR THE ACCORDING TO THE DEALERSHIP, THE EGR COOLER HAS TO BE REPLACED AT A COST TO THE OWNER OF $1000. VW CUSTOMER CARE WILL NOT STAND BEHIND THE PRODUCT BUT DID REALIZE THE ISSUE AND OFFER REPLACEMENT IN THE FIRST 2 YEARS OR 24K MILES. MOST ISSUES OCCUR AT 70K TO 120K MILES BECAUSE OF A POORLY DESIGNED PART. *TR

FIRST NOTICED THAT THE SUNROOF ON MY '06 JETTA TDI WOULD INTERMITTENTLY OPEN AND (SOMETIMES) CLOSE ON IT'S OWN. SINCE THEN MY DOOR LOCKS NO LONGER FUNCTION ON THE DRIVERS SIDE FRONT AND REAR DOORS. I CANNOT USE THE KEY TO LOCK ALL OF THE DOORS AND ACTIVATE THE CAR ALARM. THE REAR DRIVER SIDE DOOR NEVER LOCKS EVEN WITH THE KEY AND CANNOT BE OPENED FROM THE INSIDE BY THE PASSENGER. THE ALARM SYSTEM WILL NOT ENGAGE AND THE REAR WINDOWS WILL ONLY OPERATE FROM THE DRIVER'S DOOR. INITIALLY THESE ISSUES WOULD COME AND GO BUT HAVE NOW BECOME A CONTINUOUS PROBLEM. THE CAR CANNOT BE SECURED. THESE ISSUES POSE A SAFETY HAZARD TO MY FAMILY AND MY PERSONAL PROPERTY. I WAS PLANNING ON PASSING THE CAR DOWN TO MY SON WHEN HE BECOMES OLD ENOUGH TO DRIVE (IN 2 YEARS) HOWEVER WITH THESE ISSUES I DO NOT TRUST THE SAFETY OF THIS VEHICLE. AFTER RESEARCHING THE COMPLAINTS IN THIS DATABASE I AM SHOCKED THAT VW HAS NOT BEEN MADE TO FIX THE PROBLEM UNDER A RECALL. THIS IS A COMMON, RECURRING PROBLEM THAT NEEDS TO BE ADDRESSES BY THE MANUFACTURER. *TR

I WAS DRIVING DOWN THE HIGHWAY IN IOWA AND TO MY HORROR, MY CAR SEAT STARTED MOVING BACK BY ITSELF. I COULD NOT REACH THE PEDALS IN THE CAR AND HAD TO HOLD THE ELECTRIC SEAT BUTTON AND FIGHT IT TO KEEP IT FROM MOVING BACK. THIS WAS PRETTY DIFFICULT SINCE THE CAR IS A STICK SHIFT. VOLKSWAGEN WAS UNINTERESTED IN HELPING DEFRAY THE COST OF REPAIRING THIS VERY SERIOUSLY UNSAFE DEFECT! *TR

THIS CAR HAD A DEFECTIVE CAMSHAFT AND LIFTERS. DEALER REFUSES TO REPAIR UNDER WARRANTY 2 YEARS AGO, NOW ITS GETTING WORST AND I DON'T HAVE THE MONEY TO REPAIR IT. *TR

WHILE I WAS DRIVING ON A BUSY ROAD, WHILE ACCELERATING MY ENGINE STARTED REVVING, AND IT WOULD NOT MOVE. I PULLED OVER SAFELY BUT WAS UNABLE TO PUSH THE CAR IN NEUTRAL. WHEN TURNING THE CAR OFF AND ON AGAIN, MY PRDNS ON DASH WAS FLASHING. THE CAR WILL NOT MOVE FORWARD WHILE IN DRIVE OR BACKWARDS WHILE IN REVERSE. WHEN I PUT THE CAR IN NEUTRAL NOTHING HAPPENS. I HAVE SEEN THAT THERE ARE RECALLS ON 2007 VOLKSWAGEN JETTA TRANSMISSIONS, BUT WONDERING IF THIS COULD BE PART OF THAT PROBLEM. *TR