2014 VOLKSWAGEN JETTA SPORTWAGEN Complaints

I FILLED THE FUEL TANK, WHICH WAS NOT QUITE EMPTY, WITH DIESEL ON 11/21. ON 11/25, AFTER DRIVING A COUPLE HUNDRED MILES AND MULTIPLE TRIPS, IT WOULD NOT START FOR MANY TRIES ONCE IT WAS SHUT OFF, EVEN WITH ENGINE HOT. FAR FROM HOME, I WAS AFRAID TO SHUT IT OFF. THE TEMPERATURE WAS NEAR FREEZING, TANK A LITTLE MORE THAN HALF. I GOT IT STARTED THREE MORE TIMES AFTER THIS AND DROVE ANOTHER 150 MI. WITHOUT ISSUES, AND IT HAS NOT STALLED. THE CAR HAS NEVER BEEN MISFUELED. ON 11/28, STARTED IT WITH 3 10-15 SECOND TRIES AND TOOK IT TO THE DEALER. DEALER COULD NEVER GET IT STARTED, CLAIMED TO SEE METAL PARTICLES IN FILTER AND TOOK FUEL SAMPLE FOR TESTING. SERVICE MGR MADE COMMENTS ABOUT NOT NEEDING TO BLEED FUEL SYSTEM, LIKE WHEN THEY TOOK A SAMPLE FUEL. DEALER COULD HAVE CAUSED (MORE) DAMAGE TO HPFP BY LETTING AIR IN. DEALER HAS NOT SEEN SIMILAR SYMPTOMS IN OTHER TDI. HIGH PRESSURE FUEL PUMP (HPFP) FAILURE SUSPECTED (ALL REPLACED IN APRIL), VW BLAMES POOR FUEL BUT LAB REPORT SAYS "OBSERVED FREE WATER" AND DID NOT ACTUALLY MEASURE IT. LAB ESTIMATED 0.5%VOL VS REQUIRED ULSD SPEC OF 0.05% VOL. CAR WILL NOT START (BUT HAS STARTED A FEW TIMES AFTER MANY TRIES AND THEN RUNS VERY WELL). DEALER ASSUMES IT'S FUEL RELATED BUT OBD CODE IS P2002(DPF PRESSURE) SO DEALER INCLUDED THAT IN THE $13K ESTIMATE. VW CONSUMER CARE INDICATED THAT REGARDLESS OF REPLACING THE FUEL SYSTEM OR FUEL, UNLESS I HAVE A COMPLETELY DIFFERENT OBD CODE, THEY MAY USE THE FUEL TEST FAILURE TO DENY ANY REPAIR OF ANY TYPE IN THE FUTURE. CAR MUST DRIVE UNDER ITS OWN POWER FOR TDI EMISSIONS BUYBACK, BUT THEY SAY THIS CONDITION IS NOT ACCEPTABLE. I AM LEFT TO PAY FOR THE REPAIRS, WITH NO KNOWN RESOLUTION, MYSELF. I AM AFRAID TO DRIVE IT (OR THAT THE DEALER CRIPPLED IT) WHEN/IF I DO GET IT RUNNING. *TR

WHEN I STARTED THE CAR THE HVAC BLOWER MOTOR WOULD NOT WORK. THE DEALER FOUND THAT THE MOTOR HAD SHORTED OUT AND INSTEAD OF BLOWING THE FUSE AND DEACTIVATING THE BLOWER MOTOR AND MOTOR CIRCUIT, THE BLOWER FUSE MELTED, THE FUSE BOX MELTED, AND THE CONNECTOR WAS ALSO MELTED. THIS CAR IS PRIMARILY USED FOR SHORT TRIPS AND WAS TAKEN TO THE DEALER SHORTLY AFTER THE MOTOR STOPPED WORKING, IF I HAD BEEN ON A LONG TRIP OR IGNORED THE PROBLEM I BELIEVE THIS SHORT CIRCUIT WOULD HAVE RESULTED IN A FIRE UNDER MY DASHBOARD. WHY DIDN'T THE FUSE BLOW AND WHAT'S THE POINT OF HAVING A FUSE IN THE CIRCUIT IF A SHORTED MOTOR CAUSES THE FUSE BOX AND FUSE TO MELT, AND NOT BLOW THE FUSE AND ISOLATE THE SHORTED CIRCUIT? THIS DESIGN IS A DISASTER WAITING TO HAPPEN. I DID NOT NOTICE ANY SMOKE OR SMELL OF MELTING PLASTIC BEFORE THE MOTOR STOPPED WORKING. I'VE ATTACHED THE REPAIR WORK ORDER, THE REPAIR WAS COMPLETED UNDER NEW CAR WARRANTY AT NO COST TO ME.

VOLKSWAGEN TDI HIGH PRESSURE FUEL PUMP FAILED, CAUSING CAR TO SUDDENLY STALL IN LEFT LANE OF LOCAL HIGHWAY RT-198 IN BURTONSVILLE, MD. I WAS IN MOTION IN TRAFFIC STALLED AS I WAS COMING THROUGH INTERSECTION AT RT-198 AND RT-29.