2001 VOLKSWAGEN PASSAT Complaints

MY 2001 VOLKSWAGEN PASSAT NEEDS A NEW ENGINE BECAUSE IT IS FILLED WITH SLUDGE. AFTER RESEARCHING THIS ON MY OWN I FOUND THAT THIS IS A COMMON PROBLEM WITH THE 1.8T ENGINE. VW ISSUED AN EXTENDED WARRANTY ON THAT ENGINE PROVIDED THE CONSUMER CAN PRODUCE OIL CHANGE RECEIPTS SHOWING THE CAR WAS MAINTAINED ACCORDING TO THE OWNERS MANUAL. I SENT THEM THE PROPER RECEIPTS SHOWING MY CAR WAS MAINTAINED PROPERLY AND THEY STILL DENIED ME. MY CAR ONLY HAS ABOUT 43,000 MILES ON IT AND I JUST BOUGHT IT 10 MONTHS AGO. *JB

MY 2001 VOLKSWAGEN PASSAT HAD A TIMING BELT FAILURE DUE TO AN INTERNAL COMPONENT THAT CAUSED THE CAR TO JUST TURN OFF. THIS BELT DID NOT FAIL, BUT THE COMPONENT DID WHICH CAUSED IT TO FAIL. HERE IS THE CONCERN: JUST THINK IF YOU ARE TRAVELING IN BUMPER TO BUMPER TRAFFIC AND THIS PART FAILS, YOU ARE ALL DONE. YOU LOSE THE CAR, NOTHING IS AVAILABLE TO GET YOU OVER TO A SAFE SPOT. ITS JUST A MATTER OF TIME WHEN SOMEONE IS TRAVELING AND THIS HAPPENS. NOTE - VOLKSWAGEN IS AWARE OF THIS ISSUE AND OFFERS A UPGRADE KIT TO REPLACE THIS PART. ALSO, NO WHERE IN THEIR SERVICE GUIDE LINES WILL YOU BE ABLE TO DETECT THIS PART THROUGH THE TECHS. I'M HOPING BY SUBMITTING THIS WE MAKE THEM ACCOUNTABLE AND TO CORRECT THIS ISSUE. I DO HAVE THE BELT WHICH SHOWS THAT IT DID NOT FAIL AS THEY PITCHED IT.*AK

2001 PASSAT WAGON GLX WAS STRUCK FROM BEHIND AT A LOW RATE OF SPEED. PASSENGER'S SEAT FULLY RECLINED UPON IMPACT, COMING TO REST ON AN INFANT CAR SEAT THAT WAS PROPERLY INSTALLED IN THE BACK SEAT. PASSENGER SUSTAINED MINOR NECK AND BACK INJURIES. INFANT WAS UNHARMED. SINCE INCIDENT THE PASSENGER'S SEAT HAS SPONTANEOUSLY FULLY RECLINED ON THREE OTHER OCCASIONS.*AK

ABS MODULE FAILED CAUSING THE ABS BRAKING TO STOP FUNCTIONING. BECAUSE THE MODULE WOULD ONLY WORK INTERMITTENTLY IT WAS HARD TO DETERMINE WHETHER OR NOT THE ABS MODULE WAS WORKING SO EXTREME CAUTION HAD TO BE TAKEN WITH BRAKING. ABS MODULE WAS REMOVED BY MYSELF AND SENT TO A REFURBISHER TO BE REPAIRED AND THEN REINSTALLED.*AK

THIS FAILURE IS DOCUMENTED WELL BY DOZENS OF CONSUMERS: HTTP://WWW.THEAUTOBAHN.COM/FORUM/SHOWTHREAD.PHP?T=12789&PAGE=1. AK THIS COMPLAINT IS AGAINST VOLKSWAGEN FOR PASSAT YEAR GLS 2001.5 (1) HEAVY RAIN (2) GALLONS OF WATER COLLECTED IN REAR PASSENGER FOOTWELL (3) POLLEN FILTER REPLACED (TWICE SO FAR)

MY VW PASSAT GLS 2001'S ABS/ASR LIGHT KEEPS ON AT ALL TIMES NOW. WENT TO THE TECHNICIAN TO PUT A REPAIR KIT SINCE THE ABS CONTROL MODULE WAS NOT COMMUNICATING WITH THE MAIN COMPUTER. ON TRYING 3-4 DIFFERENT KITS, TAKING TO THE DEALERSHIPS, THE ERROR CODE SHOWED SENSOR FAILURE BUT ALL THE SENSORS WORKED FINE, ELECTRICAL WERE WITHOUT ANY OPENS OR SHORTS. THE ABS CONTROL MODULE FAILS TO COMMUNICATE. I AM TO KNOW THAT THIS IS A VERY COMMON PROBLEM WITH VW/AUDI ESPECIALLY THE BOSCH MODULES. IT IS A SAFETY ISSUE SINCE ABS DOESN'T WORK ON THIS EXPENSIVE VEHICLE. *JB

2001 VOLKSWAGEN PASSAT LOW MILEAGE OF 21,000 MILES. NORMALLY GARAGED AND MAINTAINED ACCORDING TO SCHEDULE. AFTER RAIN, FOUND AN INCH OF WATER IN REAR PASSENGER FLOOR. TRANSMISSION NON-FUNCTIONAL, AIR BAG WARNING LIGHT AND OTHER WARNING LIGHTS ON. DEALER SAID THE POLLEN FILTER SEAL WAS NO GOOD AND THAT WATER LEAKED IN AND DESTROYED THE TRANSMISSION CONTROL UNIT WHICH IS LOCATED IN THE FLOOR BEHIND THE PASSENGER SEAT. COST OF REPAIR IN EXCESS OF $3,100. VW REFUSES TO COMPENSATE IN ANY WAY BECAUSE WARRANTY WAS ONLY FOR TWO YEARS. TRANSMISSION AND POWER TRAIN ARE COVERED FOR 5 YEARS, BUT VW SAYS THE FAILURE WAS DUE TO "OUTSIDE INFLUENCE". I HAVE READ MANY ACCOUNTS ON THE INTERNET FROM MANY ANGRY OWNERS OF SIMILAR PROBLEMS WHERE LEAKS FROM THIS SEAL HAVE CAUSED CATASTROPHIC REPAIRS. THE SERVICE MANAGER AT THE VW DEALER TOLD ME THAT CHECKING THE POLLEN FILTER SEAL IS NOT PART OF ANY REGULAR MAINTENANCE AND THAT IN ORDER TO CHECK IT, YOU'D NEED TO DISASSEMBLE QUITE A FEW THINGS IN THE ENGINE COMPARTMENT. WHEN I ASKED HIM HOW AN OWNER COULD POSSIBLY KNOW IF THE SEAL NEEDED REPLACEMENT AND HE REPLIED "YOU FOUND OUT HOW". I AM CLEARLY NOT ALONE IN HAVING EXPERIENCED A FAILURE FROM A PART THAT IS NOT IN ANY WAY MAINTAINABLE (THE POLLEN FILTER SEAL) AND THAT HAS CAUSED MAJOR DAMAGE TO THE CAR. I FEEL THIS IS A CONSUMER ISSUE AND THAT THIS IS A DESIGN DEFECT IN THE PASSAT THAT VW SHOULD COMPENSATE OWNERS FOR. THERE IS NO WAY FOR AN OWNER TO BE ABLE TO AVOID THIS SITUATION -- IT IS NOT A MATTER OF MAINTENANCE. IT GOT TO DO WITH THE PASSAT LEAKING WATER AND THE LOCATION OF AN EXTREMELY EXPENSIVE COMPONENT IN THE REAR PASSENGER FLOOR, THE AREA WHERE ANY WATER THAT LEAKS MIGRATES TO. IF THIS FAILURE HAD OCCURRED DURING DRIVING, I MIGHT HAVE HAD AN ACCIDENT. *JB

DT*: THE CONTACT STATES THERE IS NHTSA RECALL 04V584000 REGARDING THE HAZARD FLASHING WARNING LIGHT SWITCH. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER, IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN. THE VEHICLE WAS SEEN BY A DEALER AND REPAIRED AS INSTRUCTED IN THE RECALL. *AK UPDATED 2/24/2005 - THE TURN SIGNAL MADE A TICKING NOISE ALTHOUGH IT WASNT ACTIVATED. *NM

AT APPROX. 70,000 MILES MY 2001 VW PASSAT 4 CYL AUTOMATIC HAS AN ABS FAILURE. I PURCHASED THE VEHICLE CERTIFIED USED IN 2002 FROM A VW DEALER AND HAVE HAD IT REGULARLY SERVICED. OTHER VW OWNERS THAT I KNOW HAVE HAD SIMILAR COMPLAINTS. IN ACT IT IS APPARENTLY WELL KNOWN IN THE AUTOMOTIVE INDUSTRY THAT VW`ABS UNITS ARE SUB-STANDARD AND PRONE TO DEFECTIVENESS. WHEN I RETURNED TO MY LOCAL VW DEALER, I WAS TOLD THAT THE UNIT COST $1300. THE PERSON AT THE DEALERSHIP ALSO MADE A COMMENT THE REFLECTED ON THE SUB-STANDARD QUALITY OF PASSAT ABS MODULES. I HAVE SEEN INTERNET POSTINGS DETAILING THE NUMEROUS FAILURES OF VW PASSAT ABS UNITS. *NM

COWL DRAIN BECAME CLOGGED FOR NO APPARENT REASON. DURING HEAVY RAIN THE PASSENGER COMPARTMENT BECAME FLOODED AND THE DASHBOARD ELECTRONICS BECAME FLOODED RESULTING IN OVER $2,000 WORTH OF DAMAGE. PLEASE NOTE THAT I AM FILING THIS COMPLAINT ON BEHALF OF MY PARENTS WHO ARE ELDERLY AND FRAIL. *JB