1995 VOLKSWAGEN PASSAT Complaints

1. NORMAL DRIVING ON A SURBURBAN ROAD AT ABOUT 45MPH. ALL OF A SUDDEN, SMOKE/STEAM FROM THE VENTS, A COMPLETELY FOGGED WINDSHIELD, A SWEET SMELL, AND SCALDING HOT COOLANT ONTO MY FEET, ALMOST CAUSING ME TO HIT A PEDESTRIAN WALKING ALONGSIDE THE ROAD. 2. IT WAS THE HEATER CORE. A VERY COMMON PROBLEM TO 80'S AND 90'S VW PASSENGER CARS. SO NOW I HAVE NO WORKING HEATER (LUCKILY ITS SUMMER) AND MY CAR WONT REACH ITS MAX COOLING CAPACITY. THUS, CAR RUNS HOT. 3. BECAUSE I AM A COLLEGE STUDENT AND CANNOT AFFORD A $1200USD FIX, I HAVE BYPASSED IT WITH A COPPER U-PIPE. THE PART IS AVALIBLE, AND VWOA HAVE DONE A MASSIVE NUMBER OF 'GOOD-WILL' FIXES. I'M STILL TALKING WITH THEM TO COME OF WITH A RESOLUTION.

HEATER CORE ON THE VR6 POWERED VEHICLES IS THE VALEO BRAND, KNOWN TO FAIL. IT JUST BLEWS COOLANT THROUGH THE DASH VENTS ALL OVER THE COUPE INSIDE.*AK

HEATER CORE EXPLODING, NO EVENTS LEADING UP TO THIS I WAS SIMPLY GOING FROM A STOPLIGHT WHEN SMOKE STARTED POURING IN THROUGH THE VENTS AND ENGINE COOLANT GOING EVERYWHERE. I HAVE NOT REPLACED ANYTHING YET, BUT THE HEATER CORE IS DESTROYED.

RACK AND PINION STEERING FAILED. AS RESULT STEERING MALFUNCTIONED. HOWEVER TCONSUMER WAS ABLE TO GAIN CONTROL. *AK

I WAS STARTING MY 1995 VOLKSWAGEN PASSAT VR6 (MANUAL), AND IT STARTED UP JUST FINE, BUT AS I STARTED TO GET GOING, THE CAR DIED. I LOST ALL ELECTRICAL FUNCTIONS OF THE CAR INITIATED BY THE IGNITION SWITCH, INCLUDING POWER BRAKES, POWER STEERING, AND HEADLIGHTS. I FOUND OUT THAT MY IGNITION SWITCH HAD MALFUNCTIONED. I CALLED VW OF AMERICA (1-800-822-8987), AND THEY TOLD ME THAT A RECALL WAS OUT FOR THE 1996 AND 1997 MODELS. THE ONLY DIFFERENCE BETWEEN THESE TWO MODEL YEARS AND MY MODEL YEAR IS THE SWITCH IN THE ON BOARD DIAGNOSTIC SYSTEM FROM OBD 1 TO OBD 2. I KNEW FROM EXPERIENCE THAT THE IGNITION SWITCH WAS THE SAME FOR ALL 1995 TO 1997 PASSATS, BUT JUST TO BE SURE, I CALLED STEVENS CREEK VOLKSWAGEN PARTS DEPARTMENT (1-408-492-1200). THE GUY THERE TOLD ME THAT PART NUMBERS MATCHED THROUGH ALL 3 YEARS, AND THAT THE IGNITION SWITCH MALFUNTCIONS AN ALL 3 MODEL YEARS INCLUDING 1995. SO, I CALLED VW OF AMERICA AGAIN, AN ASKED THEM WHY THEY DIDN'T RECALL MY MODEL YEAR. THEY STATED THAT "VW COULD HAVE RECTIFIED THE PROBLEM" WHICH IS IMPOSSIBLE WHEN ALL 3 PART NUMBERS ARE THE SAME. THEY THEN SAID THAT THEY WOULD LAUNCH THEIR OWN INVESTIGATION INTO IT, AND TOLD ME TO CALL NHTSA. MY FINAL SAY ON THIS MATTER IS THAT IT DEFINITELY IS LIFE THREATENING, BECAUSE THE IGNITION SWITCH IS ELECTRICAL, AND CAN MALFUNTCION AT AND TIME, CAUSING YOU TO LOSE POWER STEERING, BRAKES, AND LIGHTING ON THE ROAD. I WAS LUCK BECAUSE I JUST GOT GOING, AND WAS ABLE TO PUSH THE CAR BACK BY MY HOUSE. MEANWHILE, VOLKSWAGEN OF AMERICA IS CUTTING CORNERS TO SAVE MONEY BY ONLY RECALLING THE MODEL YEARS THAT YOU HAVE TESTED, EVEN THOUGH THE MALFUNCTIONING PART IS THE SAME INALL 3 MODEL YEARS: 1995, 1996, AND 1997. AS A MEMBER OF A VW VORTEX FORUM, I WILL TELL OTHERS WITH THIS SAME PROBLEM TO WRITE IN TO YOU. *AK

FRONT END WAS MAKING A RATTLING NOISE. ALSO, RADIATOR OVERHEATED. TOOK VEHICLE TO DEALER, AND THEY REPLACED THE HEAD GASKET. *AK

TIMING CHAIN STRETCHED AND VALVES WENT AGAINST PISTONS. ENGINE LIGHT GOES ON AND OFF ALL THE TIME. IGNITION SWITCH FAIL AND LIGHTS GO OFF. RIGHT WINDOW DOESN'T WORK. IGNITION COIL IS DEFECTIVE.

1995 VW PASSAT. DOOR LOCKS HAVE BEEN REPAIRED SEVERAL TIMES BY AUTHORIZED VW DEALER AND REPAIR SHOP. DOORS DO NOT OPEN IN COLD WEATHER DESPITE CAR BEING IN HEATED GARAGE.*AK

THE ABS LIGHT CAME ON MY 1995 PASSAT. THE DEALER DIAGNOSIS INDICATED I NEEDED A NEW ABS HYDRAULIC UNIT AT A COST OF $1,768.00. I CONSIDER THIS AN OUTRAGEOUS AMOUNT FOR SUCH AN IMPORTANT SAFETY ITEM. I CONTACTED VWOFA CORPORATE AND THEY TOLD ME THERE WAS NOTHING THEY COULD DO BECAUSE THE CAR WAS OUT OF WARRANTY. *LA

IN FEBRUARY OF 2003 ON ONE OF THE COLD DAYS, THE FAN SYSTEM DIDN'T WORK AND AS A RESULT CAR OVERHEATED AND BLEW OF THE HEAD GASKET. TOTAL COST TO FIX $2000. SMALL RECALL OF COOLING FAN COST ME $2000 AND IN SPITE OF CALLS TO CUSTOMER SERVICE DEPARTMENT, NO COST WAS BORN BY THE COMPANY. *NLM