2003 VOLKSWAGEN PASSAT Complaints

THE AD BLUE HEATER FAILURES ARE RAMPANT IS ALL PASSAT MODELS 2012 TO 2015. THE SAFETY ISSUE IS THAT IN THE WINTER TIME WHEN AD BLUE FREEZES THE CAR GOES INTO A NON RESTART COUNTDOWN. IF THE CAR STALLS DURING THIS TIME THE PERSON MAY BE STUCK IN SUB ZERO WEATHER WITHOUT HEAT. THE AD BLUE HEATER IS ONLY COVERED UNDER THE 3 YEAR 36,000 MILE WARRANTY BECAUSE THEY SAY IT DOES NOT QUALIFY AS EMISSIONS CONTROL SYSTEM. THE CAR WILL SHUT DOWN BECAUSE IF THE AD BLUE FREEZES THE EMISSIONS GOES UNEXPECTEDLY HIGH SO HOW CAN THIS NOT BE PART OF THE EMISSIONS SYSTEM? THE COST OF REPAIR IS $1,000 PLUS.

TL* THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, WHERE IT WAS DIAGNOSED THAT THE ENGINE EXHIBITED SLUDGE. THE VEHICLE WAS REPAIRED BUT THE FAILURE PERSISTED. THE MECHANIC RECOMMENDED THAT THE ENGINE BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 83,000.

I WAS DRIVING THE CAR TO WORK 2 MILES FROM MY HOUSES OIL WARNING COME ON RETURN TO MY HOUSE TO GET A SECOND CAR PARK THE CAR AND LEFT 5 MINUTE LATER GET A PHONE CALL MY CAR IS ON FIRE THANKS GOD I WENT BACK HOME CALL VW THEY SAID NO RECALLS BUT NATIONAL SAFETY INVESTIGATION I LOST MY CAR BECAUSE DON'T HAVE FULL COVER INSURANCE

CYLINDERS MISFIRE CAUSING ACCELERATION HESITATION. SPARK PLUGS AND COIL WERE REPLACED FEB.2009, DEC. 2013, AUG. 2014, JUNE 2015. THE CONDITIONS ARE REPETITIVE AND IDENTICAL.

TL* THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. WHILE DRIVING AT APPROXIMATELY 60 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE FAILED TO RESTART. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TIMING BELT NEEDED TO BE REPLACED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14E007000 (ENGINE AND ENGINE COOLING). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

TL* THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. WHILE REFUELING THE VEHICLE, IT STARTED TO LEAK FUEL FROM UNDERNEATH THE FUEL TANK. THE VEHICLE WAS DRIVEN TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 82,500. ...UPDATED 06-12-15 *BF THE CONSUMER STATED VW CUSTOMER SERVICE WAS ADVOCATING TO GET A NEW FUEL TANK INSTALLED FOR HIM AT NO COST. UPDATED 06/23/15*JB

ENGINE LIGHTS COME ON. CAR AT TIMES START SHAKING - NOT CONSISTENTLY THOUGH. TOOK IT TO SHOP: FOUND OUT IGNITION COILS MISFIRES. THIS HAS OCCURRED 4 TIMES IN A 2 YEAR TIME SPAN. THE MOST RECENT 2 BEING A MONTH APART. THE MOST RECENT INCIDENT BURNED ALMOST ALL OF THE SPARK PLUGS. DID RESEARCH AND THIS WEBSITE DESCRIBES MY SITUATION PERFECTLY: HTTP://WWW.VWPROBLEMS.COM/TRENDS/IGNITION-COIL/. *TR

I HAVE HAD MY 2003 VW PASSAT A YEAR NOW I HAVE JUST NOTICED IN THE PAST WEEK THAT IT HAD A LEAK I THOUGHT IT WAS FROM THE WINDOW OR SUN ROOF I WENT TO VACUUM THE CAR OUT ON A NICE DAY AND SEEN THAT IT STILL HAD VERY WET CARPET AND THEN NOTICED THE CARPET WAS A GREEN COLOR LIKE IT WAS COOLANT I THEN HAD MY BF CHECK IT AND IT IS. I RUN A DAYCARE AND USE THIS CAR DAILY WITH MY CHILDREN WE HAVE BEEN BREATHING IN THIS COOLANT FOR WEEKS NOW AND THAT PROBABLY EXPLAINS MY DAUGHTER SAYING SHE GETS HEADACHES WHEN WE DRIVE THE CAR. I HAVE DONE SOME RESEARCH AND SEE IT IS A VERY COMMON AND RECALLED THING WITH THE HEATER CORE AND I HAD NO IDEA I HOPE US BREATHING THIS IN HASN'T DONE ANY DAMAGE I HAVE A ONE YEAR OLD WHO HAS BEEN IN IT THIS WHOLE TIME AS WELL.IM VERY UNPLEASED WITH THIS CAR. *TR

AFTER A COUPLE ATTEMPTS TO START THE VEHICLE THE ENGINE TURNS OVER AND RUNS FOR 2-3 SECONDS THEN DIES. THIS HAPPENS MULTIPLE TIMES BEFORE FULLY STARTING UP AND IS ABLE TO BE DRIVEN. WHILE OUT OF GEAR AND CAR IS RUNNING, PRESSING ON THE ACCELERATION DOES NOTHING. CAR IS ABLE TO BE DRIVEN SHORT DISTANCES BUT STALLED AT ONE POINT GOING APPROX. 5 MPH. I WAS TOLD MY SPECIFIC VIN # IS NOT COVERED UNDER WARRANTY FOR FUEL PUMP/SYSTEM MALFUNCTIONS. IF THIS IS A KNOWN ISSUE OF 2003 PASSAT'S ALREADY WHY WOULD SOME NOT BE COVERED? *TR

NHTSA CAMPAIGN ID NUMBER: 08V156000 "FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE." NHTSA ACTION NUMBER: PE08008 THE CAR IS OOZING GASOLINE FROM TOP LEFT (DRIVER'S) SIDE OF GAS TANK. THERE IS A STRONG SMELL OF GASOLINE INSIDE AND OUTSIDE (OUTSIDE DUE TO A GAS PUDDLE). VW DEALER (VW DOWNTOWN LOS ANGELES) REFUSES TO GRANT THE REPAIR, ASKING FOR $140 INSPECTION FEE. VWOA REPRESENTATIVE SITES THE RECALL PERFORMED IN 2009. THE RECALL ( PE08008 ) ISSUED HAS 2 PARTS: 1) UNDERBODY HEAT SHIELD INSTALLATION. 2) "DEALERS WILL ALSO INSPECT AND ADJUST THE FUEL LINE ROUTING ON 1.8T VEHICLES AND THE FUEL TANK VENTILATION VALVE ON 4MOTION/ALL WHEEL DRIVE VEHICLES, AND REPLACE COMPONENTS IF NECESSARY FREE OF CHARGE." I SUSPECT THE SECOND PART WAS NOT FULFILLED, GIVEN THE EXACT NATURE OF MECHANIC FAILURE DESCRIBED. *TR