2003 VOLKSWAGEN PASSAT Complaints

ABS MODULE FAILURE, ABS LIGHT ON BRAKE LIGHT BLINKING AND THEN ASR LIGHT ON, HAPPENS RANDOMLY, NO SPECIFIC REASON, DRY WEATHER, HUMID, DAY OR NIGHT. STILL COMES ON RANDOMLY, NO SPEEDING, PROBLEM GOES AWAY WHEN CAR IS TURNED OFF. *TR

TL* THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT WAGON. THE CONTACT STATED THAT AFTER PARKING THE VEHICLE, SHE NOTICED A LEAK FROM THE FUEL SYSTEM. THE LEAK WAS NOTICED ON TWO SEPARATE OCCASIONS. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE CONTACT STATED THAT THE VEHICLE WAS NOT REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 02V026000 (FUEL SYSTEM, GASOLINE). THE APPROXIMATE FAILURE MILEAGE WAS 115,000.

ON OR ABOUT FEB. 1, 2013, I STARTED MY MANUAL-TRANSMISSION 2003 VOLKSWAGEN PASSAT GLS (V6) AND SHIFTED INTO REVERSE TO BACK OUT OF MY DRIVEWAY. AS SOON AS I TOOK MY FOOT OFF THE BRAKE, THE CAR LURCHED BACKWARD EVEN THOUGH I WAS NOT DEPRESSING THE ACCELERATOR PEDAL. I QUICKLY SHIFTED INTO NEUTRAL, ENGAGED THE PARKING BRAKE AND TURNED OFF THE IGNITION. WHEN I TRIED TO RESTART THE CAR, IT WOULD NOT START AND DID NOT START UNTIL ABOUT AN HOUR LATER. MY FIRST THOUGHT WAS THAT THE ACCELERATOR COULD HAVE BECOME LODGED UNDER THE FLOORMAT, BUT THAT WAS NOT THE CASE; NOR WAS IT THE CASE IN AT LEAST FOUR OTHER SIMILAR INCIDENTS. TWO OF THESE INCIDENTS TOOK PLACE AS I WAS DRIVING AT A LOW SPEED IN A RESIDENTIAL AREA. FORTUNATELY, THERE WERE NO PEDESTRIANS OR OTHER CARS AROUND ME AND I HAD THE PRESENCE OF MIND TO RECOGNIZE THE ISSUE, SHIFT INTO NEUTRAL AND PARK THE CAR. HOWEVER, I FEAR WHAT COULD HAPPEN IF THIS INCIDENT RECURRED WHEN I WAS AT AN INTERSECTION, RAILROAD CROSSING OR CROSSWALK. DESPITE REPEATED ATTEMPTS, MY MECHANIC HAS BEEN UNABLE TO REPLICATE THE INCIDENT OR IDENTIFY THE CAUSE. *TR

TL* THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE ENGINE PRESSURE WARNING INDICATOR ILLUMINATED CONTINUOUSLY. THE FAILURE RECURRED TWELVE TIMES WITHIN THE SAME DAY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS. THE TECHNICIAN STATED THAT THE ENGINE WOULD NEED TO BE REPLACED DUE TO EXCESSIVE OIL SLUDGE. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.

I WAS DRIVING ON THE HIGHWAY AROUND 47-50 MPH ALL OF A SUDDEN I HEARD A STRONG HIT,AS IF SOMEONE HIT ME FROM THE REAR... THEN MY DASHBOARD STARTED FLASHING AND ALL THE TRANSMISSION GEARS GOT LOCKED UP, I WAS ABLE TO STOP THE CAR AND TURN IT OFF, FUNNY THING IS THIS HAPPENS DURING SUMMER ONLY WHEN IT'S HOT OUTSIDE OTHERWISE, I DON'T SEE IT... THIS CAN BE DANGEROUS. *TR

WHEN I TURN MY HEATED SEAT ON THE DRIVER'S SIDE PAST LEVEL 1, THERE IS ONE SPOT ON THE SEAT THAT GETS PAINFULLY HOT. I USUALLY TURN THE HEAT OFF AT THAT POINT. TODAY I WAS SO COLD THAT I DIDN'T WANT TO TURN THE SEAT OFF, SO I PUT MY HAND BETWEEN THE SEAT AND MY LEG. WHEN I TOOK MY HAND OUT, IT SMELLED LIKE SMOKE. I CALLED VOLKSWAGEN, AND THEY DON'T HAVE ANY RECALL ON THESE SEATS. I THOUGHT THEY MIGHT MAKE A CONCESSION SINCE IT IS A POSSIBLE SAFETY ISSUE, BUT THEY WOULDN'T DO ANYTHING FOR ME. *TR

WHILE DRIVING THE ON THE CAPITOL BELTWAY (495 INNER LOOP) I STARTED TO SMELL A BURNING SMELL. MOMENTS LATER WITHIN ABOUT 30 SECONDS THE ENGINE BURST INTO FLAMES. I WAS ABLE TO STOP THE VEHICLE SAFELY AND EXITED THE CAR. NEEDLESS TO SAY THE VEHICLE IS TOTALED. I WOULD DESCRIBE THE INCIDENT AS A SPONTANEOUS ENGINE FIRE. THERE WAS NO WARNING. THANK YOU. *TR

THE TURN SIGNAL WOULD CONTINUE TO MAKE A CLICKING NOISE EVEN AFTER THE SIGNAL HAD BEEN SHUT OFF. THIS CONTINUED TO HAPPEN FOR SEVERAL MINUTES AND THEN SMOKE BEGAN TO RISE FROM BEHIND MY STEERING WHEEL WHERE THE TURN SIGNAL ENTERS THE WHEEL CONSOLE. I BEGAN TO PULL OVER AT THE NEXT SAFE AREA AND BEFORE I COULD I NOTICED SMALL FLAMES COMING FROM THE SAME AREA WHERE THE TURN SIGNAL ENTERS THE WHEEL CONSOLE. WHEN I TURNED OFF THE CAR THE SMOKE/FIRE SLOWLY SUBSIDED. I ENDED UP REMOVING THE TURN SIGNAL FUSE IN ORDER TO DRIVE TO A REPAIR SHOP. AFTER SOME RESEARCH THIS SEEMS TO BE A COMMON ISSUE WITH NO RECALLS ISSUED YET. *TR

TL* THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT. WHILE DRIVING APPROXIMATELY 20 MPH, THE CONTACT NOTICED SMOKE COMING FROM UNDER THE HOOD AND POURING INSIDE THE VEHICLE. THE CONTACT FOUND WATER AND COOLANT LEAKING FROM THE DASHBOARD AND ONTO THE DRIVER'S SIDE OF THE VEHICLE. THE VEHICLE WAS ALSO OVERHEATING. AFTER EXITING THE VEHICLE, THE CONTACT NOTICED FLAMES COMING FROM UNDER THE HOOD. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE HOWEVER, THE CONTACT SUSTAINED BURNS TO HER LEGS DUE TO THE HOT LEAKING COOLANT. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THE ENGINE BLEW AND THE INSTRUMENT PANEL CLUSTER WAS DAMAGED. THE CONTACT WAS UNAWARE OF WHAT CAUSED THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 174,256.

FUEL TANK VENTILATION VALVE IS CRACKED AND LEAKING ON 2003 VW PASSAT 4MOTION/AWD (UNDER NHTSA CAMPAIGN # 08V156000). CONTACTED MULTIPLE DEALERS AND VW DIRECTLY AND DEALERSHIP/VW WILL NOT REPLACE FUEL TANK UNDER RECALL. BOTH STATED THIS RECALL WAS COMPLETED IN 2009 HOWEVER WORK COMPLETED WAS ONLY ONE PART OF THE RECALL THAT INCLUDED ADDING ADDITIONAL HEAT SHIELDS. VW CUSTOMER CARE STATED VEHICLE WAS OUT OF WARRANTY AND THEY COULD NOT ASSIST. CUSTOMER OBJECTED STATING THIS IS A SAFETY CONCERN NOT A WARRANTY ISSUE. *TR *JS