2004 VOLKSWAGEN TOUAREG Complaints

TL*THE CONTACT OWNS A 2004 VOLKSWAGEN TOUAREG. WHILE DRIVING APPROXIMATELY 55 MPH ON NORMAL ROAD CONDITIONS, THE FLAT TIRE CAUTION WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE CONTINUED TO TRAVEL THREE TO FOUR MILES WHEN THE EMERGENCY FLAT TIRE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE DRIVER PULLED OVER TO THE SIDE OF THE ROAD, BUT DID NOT NOTICE ANY FLAT TIRES. THE WARNING INDICATORS REMAINED ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING AND THEY STATED THAT THE FAILURE WAS RELATED TO A FAULTY MANUFACTURER DESIGN. THERE WAS NO REPAIR AVAILABLE. THE TECHNICIAN WAS UNABLE TO DISENGAGE THE TIRE PRESSURE MODULE TO AVOID THE FALSE WARNINGS DISPLAYED ON THE INSTRUMENT PANEL. THE FAILURE MILEAGE WAS 38,200 AND CURRENT MILEAGE WAS 40,083. UPDATED 3/19/09 *CN UPDATED 03/23/09. *JB

I HAVE HAD MY 2004 VW TOUAREG SINCE JUNE 2006 AND HAVE HAD PROBLEM AFTER PROBLEM WITH THE VEHICLE. THE CATALYTIC CONVERTER WENT OUT WITHIN 6 WEEKS OF BUYING THE CAR, THE DRIVE SHAFT HAD TO BE REPLACED, THE AIR CONDITIONING COMPRESSOR HAD TO BE REPLACED, THE BRAKES HAVE HAD TO BE REPLACED AND I AM GETTING ANOTHER "CHECK BRAKE PADS" ERROR AGAIN, THE TIRE MONITORING SYSTEM CONTINUALLY TELLS ME I HAVE A FLAT, THE RADIO AMPLIFIER WAS MAKING A LOUD CRACKING SO THE DEALERSHIP REPLACED A FUSE AND BLEW THE 2 BACK SPEAKERS (WHICH THEY WOULD NOT FIX, HEWLETT VW IN GEORGETOWN, TEXAS), THE AUTO DIFFERENTIAL IS GOING OUT. THERE SEEMS TO BE NO END IN SIGHT FOR REPAIRS. *TR

THE TIRE PRESSURE MONITORING SYSTEM WILL PERIODICALLY DISPLAY VARIOUS WARNING MESSAGES INDICATING A FLAT TIRE. TIRE PRESSURE HAS ALWAYS BEEN NORMAL (UNCHANGED FROM PRIOR TARE), AND VISUAL INSPECTION OF THE TIRE INCLUDING SOAP TEST HAS ALWAYS BEEN NORMAL. DEALER HAS BEEN UNABLE TO FIX THE PROBLEM, CITING INABILITY TO REPLICATE IT. *TR

FOR MONTHS I LISTENED TO "DEFECTIVE TIRE" WARNINGS AND "CHECK TIRE PRESSURE" WARNINGS - ALL TO NO AVAIL - EVERYTHING WAS FINE. FINALLY, A LIGHT CAME ON - "TIRE PRESSURE MONITOR SYSTEM FAULT". I TOOK IT IN THE VACAVILLE VW, AND THEY DETERMINED IT WAS THE TPMS MODULE (NOT THE SENSOR). I HAVE AN EXTENDED WARRANTY AND WAS FIRST TOLD THAT THE MODULE WAS A COVERED COMPONENT, WHILE THE SENSOR WAS NOT. I LEFT IT THERE FOR THE APPROPRIATE REPAIRS ON A THURSDAY (11-6-08). ON FRIDAY, I WAS INFORMED THAT THE REPAIRS HAD BEEN MADE, BUT WHEN TEST DRIVING THE VEHICLE, THE "CHECK ENGINE" LIGHT CAME ON. AFTER CHECKING...THEY FIND THE COIL IS BAD. VACAVILLE VW REPLACES THE COIL AND IT IS READY FOR PICKUP ON TUESDAY, 11-11-08. I PICK THE VEHICLE UP ON WEDNESDAY AND TWO DAYS LATER, THE TIRE PRESSURE MONITOR SYSTEM FAULT LIGHT COMES ON AGAIN. IT IS NOW AT VACAVILLE VW AND I AM WAITING TO FIND OUT WHAT IS WRONG NOW. *TR

DRIVE SHAFT SUPPORT BEARING FAILURE @ 62,000 MILES. MANUFACTURER VW DOES NOT SELL INDIVIDUAL BROKE PART BUT SELLS ASSEMBLY WHICH COST $1,100 PLUS TAX. THIS IS COMMON AND SHOULD BE A FACTORY RECALL. *TR

SCREECHING BRAKES. THE BRAKES WERE SCREECHING FOR THE PAST THREE MONTHS AND THE VW DEALERSHIP REPLACED THE PADS AND DISC. AFTER THREE ATTEMPTS, I WAS TOLD THAT THE SCREECHING IS NORMAL. ALSO, SINCE I BOUGHT THE SUV IN SETPTMBER 2004, I HAVE BEEN HAVING AN ALIGNMENT PROBLEM WHICH RESULTED IN EXCESSIVE TIRE WEAR. THE DEALER DID NUMEROUS ALIGNMENTS AND I CHANGED ALL FOUR TIRES( 3 TIMES), BUT THE PROBLEM STILL EXISTS. THE VEHICLE ONLY HAS ABOUT 28,000 MILES. *TR

MULTIPLE ENGINE LIGHT FAILURES FOR OVER 4 YEARS. ENGINE LIGHT CAME ON AND ENGINE SHUT DOWN IMMEDIATELY WHILE WIFE WAS ON THE FREEWAY. VERY DANGEROUS...ESSENTIALLY NO WARNING. HAVE REPLACED WIRING HARNESS IN THE VEHICLE AND HAVE HAD IT IN THE SHOP FOR ELECTRICAL ISSUES MANY TIMES. UNSAFE HANDLING AND ACCELERATION...CAR JUMPS FORWARD AT STOPS WHILE IT IS DOWNSHIFTING. THINK THE TRANSMISSION, TIRES AND BRAKES SHOULD BE TESTED. THINK YOU WILL FIND THEY ARE DEFECTIVE. ENGINE BLEW UP AT 44,000 MILES. VERY DANGEROUS CAR..AND YOU WILL FIND OTHER TOUAREGS WITH SIMILAR ISSUES. SHOULD BE RECALLED. *TR

TL*THE CONTACT OWNS A 2004 VOLKSWAGEN TOUAREG. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT WAS CONSTANTLY ILLUMINATED ON THE INSTRUMENT CONTROL PANEL. THE DEALER STATED THAT HE WOULD HAVE TO REPLACE THE AIR BAG MODULE AT THE COST OF $3,000. THE VEHICLE HAS NOT BEEN REPAIRED. THE CONTACT IS IN THE PROCESS OF NOTIFYING THE MANUFACTURER IN REFERENCE TO THE CUSTOMER SATISFACTION CAMPAIGN IN 2006 FOR THE AIR BAG WIRING CONNECTOR. THE FAILURE AND CURRENT MILEAGES WERE 37,000.

DRIVE TRAIN FAILED WITHIN WARRANTY PERIOD. ALSO, THE MODULE FAILED WITHIN SIX MONTHS OF THE DRIVE TRAIN BEING REPLACED. THE ABS MODULE HOWEVER; FAILED 3 MONTHS AFTER WARRANTY EXPIRED. AS A RESULT I SKIDDED UNPREDICTABLY ON ICE AND CAME WITHIN INCHES OF CAUSING A SERIOUS ACCIDENT. $1500 WAS QUOTED TO ME TO REPLACE THE MODULE. *TR

2004 VW TOUAREG WITH TIRE FAILURE AND KEY PROGRAMMING. CONSUMER STATES HE HAD TO REPLACE THE TIRES DUE TO A PUNCTURE IN ONE OF THE SIDEWALL TIRES. THE SECOND KEY RECEIVED NEEDED TO BE PROGRAMMED AND DEALER CHARGED HIM FOR PROGRAMMING. *KB THE CONSUMER STATED HE GETS LOW GAS MILEAGE. WHEN THE VEHICLE WAS RETURNED TO THE CONSUMER, THE TIRE MONITORING SYSTEM WOULD COME ON AND GO OFF REPEATEDLY. THE DRIVE SHAFT WAS REPLACED DUE TO A VIBRATION WHEN MAKING TURNS. THE FRONT BRAKES NEEDED TO BE REPLACED.*JB