1998 VOLVO 770 Complaints

CLUTCH PEDAL WOULD NOT ENGAGE AS DESIGNED. ON SEVERAL OCCASIONS IT FAILED. TWICE IN TRAFFIC AND ONE AFTER COMING TO A COMPLETE STOP. USED EXCESSIVE FORCE TO ENGAGE, FOR IT WOULD ENGAGE AFTER REPEATED STOMPING ON THE CLUTCH PEDAL. HOWEVER, THE LAST TIME IT WOULD NOT ENGAGE, I USED BOTH FEET TOO ENGAGE IT, HOPING THAT THE FOR TO MENTIONED WOULD OCCUR, IT DID NOT. THE ENTIRE CLUTCH PLATE ON THE FIRE WALL BROKE. THIS LED TO THE SUDDEN COLLAPSE OF THE PEDAL WHICH SLAMMED INTO THE FLOOR AND SNAPPED BOTH KNEES AND BUCKLED MY LEFT HIP WHICH I NOW HAVE RECURRING INJURIES WHICH HAS NOW FORCED ME TO LEAVE THE TRUCKING INDUSTRY. THE SHOP SUPERVISOR EXPLAINED TO ME THAT THIS HAS HAPPENED ON SEVERAL VOLVO TRUCKS AND HE HAS HAD TO REPLACE THEM FOR THE CYLINDER THAT CONTROLS THE CLUTCH LEVER RODS HAVE A PROBLEM WITH RUST AND OTHER CONTAINMENTS WHICH CAN CAUSE THE LEVEL ROD THAT CONTROL THE CLUTCH PEDAL TOO FREEZE UP, WHICH STOPS THE CLUTCH FROM ENGAGING. THIS IS CAUSED BY THE CYLINDER HAVING TOO MUCH OPEN SPACE ON THE TOP BEFORE A RUBBER SEAL WHICH IS LOWER INSIDE TO STOP THE RUST, WATER, AND CONTANIMENTS FROM CAUSEING PROBLEMS WITH CLUTCH OPERATION. VOLVO HAS A REPLACEMENT FOR THIS AND DID IN FACT REPLACE IT WITH ANOTHER CORRECTED CYLINDER AT THE TIME OF MY INJURIES.*AK

CONSUMER STATES THAT THE VEHICLE WILL NOT START. CONTACTED DEALER AND THE DEALER IS NOT WILLING TO DO ANYTHING. PLEASE PROVIDE FURTHER INFORMATION. *MR

THE OWNER REPORTS POOR MILEAGE AND DURABILITY OF THE FRONT WHEEL BEARINGS AND HAS HAD A PROBLEM WITH EXCESIVE STEER AXLE WEIGHT, FUEL TANKS AND 5TH WHEEL RAILS MOVE AFT BUT STEER AXLE WEIGHT RUNS ABOUT 13,140 LBS (CUMMINS ENGINE)(REPORTED TO MANUFACTURER). NLM

CONSUMER STATES THE U-BOLT FAILED, HOWEVER IS UNSURE AS TO IF IT FAILED BEFORE OR AS THE RESULT OF VEHICLE CRASH. *MJ

OWNER REPORTS REGULAR OCCURRENCE OF STEERING WHEEL "LOCK-UP". REPORTS THAT WHEEL FREQUENTLY LOCK AFTER 1/2-3/4 REVOLUTION OF STEER WHEEL WHILE MANEUVERING AT LOW SPEEDS OR WHILE ACCELERATING FROM STOP.UPON LOCKING, STEERING WHEEL MUST BE FORCE TO REGAIN MOVEMENT . *MJ

VEHICLE WAS EXPEREINCING NUMEROUS ELECTRICAL PROBLEMS, THE FUSES IN THE DASH WERE CONTINUOUSLY BLOWING BECAUSE OF A LOOSE WIRE ON SEVERAL OCCASSIONS, THE STARTER WAS REPLACED, THERE WERE KEY SWITCH PROBLEMS, AND THE TRAILER POWER CORD WAS INOPERATIVE, DEALER REPLACED THE WIRING HARNESS.*JB

THE BAFFLE INSIDE THE FUEL TANK CAME LOOSE AND IS FLOATING INSIDE THE TANK AND MAKING NOISE. NLM

CONSUMER EXPERIENCING VARIOUS FRONT END PROBLEMS. NEW SPINDLE AND SPRINGS WERE INSTALLED. *TT

EXPERIENCING HEAVY FRONT END, VEHICLE IS ON FOURTH SET OF STEER TIRES, CAB ALIGNMENT THREE TIMES. *TT

THE CONSUMER STATED THAT THE PASSENGER SIDE REAR AXLE HAD A U-BOLT PROBLEMS. *YH