1996 VOLVO 850 Complaints

1996 VOLVO 850 - ABS LIGHT INTERMITTENT - NOT SURE IF ABS IS WORKING OR NOT - TOLD BY VOLVO REPAIR SPECIALISTS THAT THIS IS A COMMON OCCURRENCE ON THE 96 & 97 MODELS - ALSO TOLD THAT ABS COMPUTER HAS TENDENCY TO BURN OUT RELATIVELY QUICKLY ON THIS MODEL & YEAR - TOLD TO GO AHEAD AND REPLACE IT - AGAIN - HAD IT REPLACED LESS THAN 4 YEARS AGO - *TR

1996 VOLVO 850 ABS LIGHT INTERMITTENT NOT SURE IF ABS IS WORKING OR NOT COMES AND GOES. *TR

HEAT GENERATED IN THE ENGINE COMPARTMENT CAUSES ABS CONTROL MODULE AND TRACTION CONTROL MODULE TO FAIL IN MY '96 VOLVO 850R. AS OF TODAY, THERE'S 3 MODULES ALREADY REPLACED (EACH COSTING $800). THE DEALER SAID THAT THE CONTROL MODULE FAILS BECAUSE IT'S NOT DESIGNED BY THE MANUFACTURER TO WITHSTAND TYPICAL ENGINE HEAT. THE CHATROOM OF VOLVO OWNERS (WWW.BRICKBOARD.COM) IS FILLED WITH THE SAME COMPLAINT FROM VARIOUS MODEL YEARS. THE FAILURE OF THE BRAKING SYSTEM IS ESPECIALLY DANGEROUS SINCE THE FAILURE CAUSES INTERMITTENT BRAKING CAPABILITY AND HAZARDOUS DURING WINTER/SNOWY ROAD CONDITIONS. THE FAILURE IS SUDDEN AND WITHOUT WARNING.

CUSTOMER STATES THAT SHE BEGAN TO DETECT CREAKING SOUNDS EVERY TIME SHE OPENED AND CLOSED THE FRONT DOOR ON THE DRIVER' SIDE**CC THE CONSUMER WAS INFORMED THERE WAS A CRACK IN THE FRAME OF THE DOOR. *JB

DT*: THE CONTACT STATED WITHOUT WARNING, THE SPEEDOMETER BECAME INOPERABLE. THE DEALERSHIP DETERMINED THE SPEEDOMETER NEEDED TO BE REPLACED. *AK

DT*: THE CONTACT STATED THE DRIVER SIDE SEAT BELT WILL NOT COME OUT OF THE RETRACTOR. THE VEHICLE WAS TAKEN TO THE DEALERSHIP, WHERE IT WAS DETERMINED THE SEAT BELT ASSEMBLY NEEDS TO BE REPLACED.

DT*: THE CONTACT STATED THE DRIVER SIDE SEAT BELT WILL NOT COME OUT OF THE RETRACTOR. THE VEHICLE WAS TAKEN TO THE DEALERSHIP, WHERE IT WAS DETERMINED THE SEAT BELT ASSEMBLY NEEDS TO BE REPLACED.

> MY FAMILY RECEIVED A NOTICE FROM VOLVO CARS OF NORTH AMERICA, VIA US MAIL, DATED FEBRUARY 2005 > NOTICE EXPLAINS THAT: "IN CERTAIN CASES, AFTER PROLONGED EXPOSURE TO EXTREME HEAT, THE FUEL TANK IN MODEL YEAR 1994-1997 VOLVO 850 VEHICLES MAY DEVELOP SEEPAGE AT THE HEAT SHIELD ATTACHMENT. WHEN THIS OCCURS, A FUEL ODOR MAY BE PRESENT." >THIS IS A SERIOUS UNDERSTATEMENT AND, IN MY OPINION BASED ON MY FAMILY'S RECENT EXPERIENCE ON OUR VOLVO 850 LISTED ED IN THE RECALL, BORDERS ON CRIMINAL NEGLECT. > WE EXPERIENCED THIS PROBLEM WITH OUR OWN VOLVO 850 WITHIN THE LAST TWO WEEKS, AND IT WAS MUCH MORE THAN FUEL VAPOR. I WILL EXPLAIN: - A VERY STRONG INTERMITTENT FUEL ODOR BECAME NOTICEABLE, FOLLOWED SEVERAL DAYS LATER BY SEVER LEAKING FROM NEAR THE TOP OF THE GAS TANK DOWN ONTO THE CARS EXHAUST PIPE. I AM REALLY SURPRISED IT HAD NOT CAUGHT FIRE WHILE WE WERE DRIVING THE VEHICLE. - GAS WAS DRIPPING FROM THE TANK AT A RATE OF ONE DROP EVERY TWO TO THREE SECONDS. MY WIFE AND I NOTICED THIS AFTER A QUICK TRIP TO THE GROCERY STORE WHERE WE HAD PARKED ON LEVEL GROUND, ALLOWING THE GAS TO POOL UNDER THE CAR. - WE HAD TO CALL THE FIRE DEPARTMENT TO SECURE THE VEHICLE; THEY HAD EM MOVE THE CAR TO A SLOPED GRAVEL AREA TO KEEP THE GAS TO ONE SIDE OF THE TANK AND TO ABSORB THE DRIPPING GAS. > THE DEALER TOOK CARE OF THE PROBLEM IMMEDIATELY. THE POINT THAT I AM TRYING TO MAKE WITH ALL THIS IS THAT IF THE NOTICE HAD BEEN WORDED MORE STRONGLY AND INDICATING THE POTENTIAL SEVERITY OF THIS PROBLEM, WE WOULD HAVE HAD THE CAR IN A LOT SOONER. I'M JUST GLAD WE DIDN'T HAVE THE CAR PARKED IN A GARAGE ATTACHED TO OUR RESIDENCE. FEEL FREE TO GIVE ME A CALL OR E-MAIL AND I WILL BE GLAD TO FORWARD A COPY OF THIS NOTICE TO YOUR OFFICE FOR REVIEW. JOHN DOMINSKI FAIRFAX, VA. *JB

1996 VOLVO 850 MANUFACTURER'S SUPPLIED TIRE JACK IS INSUFFICIENT TO LIFT CAR, EXTREMELY DIFFICULT TO TURN CRANK AND IS DANGEROUS. JACK KEPT ON SLIPPING AND FINALLY COLLAPSED. MY KNUCKLES WERE SCRAPING CONCRETE AS I TRIED TO TURN THE SMALL CRANK. *NM

VEHICLE WAS PARKED IN THE GARAGE, ONCE THE CONSUMER TRIED TO START IT, IT WOULD NOT START. THE AUTOMOBILE CLUB CAME AND JUMPED THE VEHICLE. CONSUMER PROCEEDED TO THE DEALER, AND WAS TOLD THE BATTERY NEEDED TO BE REPLACED, AND IT WAS REPLACED. CONSUMER RETRIEVED THE VEHICLE, AND THE PROBLEM OF STARTING THE VEHICLE RECURRED. AUTOMOBLE CLUB CAME AGAIN, AND THE CONSUMER WAS TOLD THE ALTERNATOR WAS DEFECTIVE.*AK *JB