1996 VOLVO 850 Complaints

AT 49,706 MILES THE DEALER REPLACED THE AIR CONDITIONER EVAPORATOR UNDER WARRENTY. APPROXIMATELY 32,000 MILES LATER IT HAD TO BE REPLACED AGAIN AT A COST OF APPROXIMATELY $800. APPROXIMATELY 36,000 MILES LATER IT NOW NEEDS TO BE REPLACED AGAIN. THE DEALER ESTIMATED THE WORK WOULD COST $800. WE LIVE IN A CLIMATE WHERE THE A.C. IS USED ONLY IN SUMMERS. THE CAR IS SERVICED REGULARLY AT A VOLVO DEALERSHIP AND THE CAR IS GARAGED. BOTH THE DEALER AND THE MANUFACTURER REFUSED TO MAKE ANY CONCESSIONS SITING THE CURRENT MILEAGE AND THE FACT THAT THE PARTS ARE NO LONGER UNDER WARRENTY. I FEEL THE SYSTEM CONTINUES TO BE DEFECTIVE, WAS NEVER FIXED PROPERLY AND VOLVO SHOULD ACCEPT SOME MONETARY RESPONSIBILITY TO MAKE IT RIGHT. AIR CONDITIONING SYSTEMS SHOULD NOT HAVE TO BE REPLACED THREE TIMES IN 125,000 MILES.

DT: CALLER RECEIVED A RECALL LETTER BUT THE CONSUMER FEELS THE DEALER DID NOT REPAIR THE PROBLEM. THE MANUFACTURERS RECALL #140 AND THE NHTSA RECALL #04V368000 WERE TO REPLACE A HEAT SHIELD. THE CALLER SAID SHE FEELS THE DEALER DID NOT DO THE RECALL BECAUSE AFTER THE REPAIR FUEL LEAKED WHEN SHE FILLED THE TANK. NEITHER THE DEALER NOR THE MANUFACTURER HAVE BEEN CONTACTED ABOUT THE PROBLEM. *NM

SUDDENLY, HEADLIGHTS AND DASH LIGHTS FAIL TO OPERATE WHEN SWITCH IS IN EITHER HEADLIGHT "ON" POSITION. WHEN SET IN PARKING LIGHT POSITION, DASH AND PARKING LIGHTS (ONLY) WORK. IF HIGH BEAM SWITCH IS MANUALLY HELD, THEN HIGH BEAMS (ONLY) WORK.

DT: ODOMETER/SPEEDOMETER DOES NOT WORK, V THIS PROBLEM APPEARS TO BE A FLAW IN VOLVO'S MANUFACTURING. *AK CONSUMER WANTS NAME AND CONCERN SHARED WITH VOLVO. CONSUMER STATES VOLVO KNOWS OF THIS WIDESPREAD ERA IN THEIR CARS. ON MAY 18TH 2005 CONSUMER SENT A LETTER TO VOLVO ABOUT THE ODOMETER PROBLEM, ALONG WITH A FOLLOW UP LETTER ON JUNE 9TH 2005. CONSUMER STATES THAT FAILURE IS DUE TO A SMALL PLASTIC GEAR IN THE SPEEDOMETER.*SB *NM

ABS CONTROL UNIT FAILURE ON 96 VOLVO 850 WITH JUST OVER 60,000 MILES ON IT. ABS LIGHT COMES ON DUE TO FAILURE IN UNIT. FAILURE IS A RESULT OF CRACKS THAT DEVELOP IN CIRCUIT BOARD. ABS FAILS & IS NO LONGER OPERABLE LEADING TO HAZARDOUS BRAKING CONDITION. THIS IS A COMMON & WELL KNOWN ISSUE ON 850 VOLVO'S. INTERNET MESSAGE BOARDS AND VOLVO REPAIR SPECIALISTS AND MEMBERS OF VOLVO COMMUNITY ALL KNOW THAT ABS LIGHT COMING ON MEANS 90% CHANCE TOTAL FAILURE OF UNIT IS INVOLVED. REPAIR COST IS PROHIBITIVE. REPLACEMENT OF DEFECTIVE UNIT IS $650 TO $900.00.

AFTER STARTING THE VEHICLE THE ABS WARNING LIGHT ILLUMINATED AND STAYED ON UNTIL THE VEHICLE WAS SHUT OFF. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK

I OWN TWO VOVO 850S. ONE IS A 1993 VOLVO 850 GLT AND THE OTHER IS A 1996 VOLVO 850 TURBO WAGON. THE AIR CONDITIONER IN BOTH CARS DEVELOPED LEAKS IN THE EVAPORATORS. THE 1996 CAR DEVELOPED THE LEAK IN 2003. I HAD IT REPLACED IN 2004 FOR $1400. THE 1993 VOLVO A/C EVAPORATOR ALSO DEVELOPED A LEAK. TO REPLACE IT WILL COST ANOTHER $1400 PLUS. VOLVO DENIES THAT THERE IS ANY PROBLEM WITH THE DESIGN OF THE A/C EVAPORATORS. I SUGGEST THAT THE FACT THAT IN MY TWO CARS BOTH EVAPORATORS HAVE DEVELOPED LEAKS INDICATES THAT THERE IS A DEFECT. NOTE THAT LIVING IN VIRGINIA THE A/C IS USED SEASONALLY. I WOULD BE CURIOUS TO KNOW HOW MANY EVAPORATORS VOLVO REPLACES PER YEAR IN WHAT MODELS AND WHAT YEAR MADE. MY GUESS IS THAT THERE IS A PATTERN HERE THAT VOLVO IS AWARE OF (MUST BE) AND REFUSES TO ACKNOWLEDGE DUE TO POTENTIAL COST TO THE COMPANY. *AK

WHILE DRIVING ABS LIGHT APPEARED ON THE DASHBOARD AND REMAINED ON. CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE AND DROVE IT TO THE DEALER FOR INSPECTION. MECHANIC DETERMINED THAT ABS PUMP MOTOR NEEDED TO BE REPLACED. *AK

REAR MIDDLE SEAT BELT WILL NOT EXTEND, RESULT IN INOPERABLE SEAT BELTS. *AK THE SEAT BELT FOR THE INTEGRATED CHILD SEAT WOULD NOT EXTEND TO ALLOW THE CONSUMER TO FASTEN THE CHILD IN THE SEAT. *NM

WHILE APPLYING THE BRAKES THE ABS BRAKE LIGHT APPEARED ON THE DASHBOARD, AND REMAINED ON. FOLLOWING THAT THE BRAKE PEDAL WENT TO THE FLOOR. THIS CAUSED A LOSS OF BRAKING POWER. CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE AND DROVE IT HOME. CONSUMER CONTACTED THE DEALER, AND THE MECHANIC DETERMINED THAT THE ABS MODULAR UNIT NEEDED REPLACEMENT. *AK