VOLVO Complaints

DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS (15-75 MPH) ON NORMAL ROAD CONDITIONS WITH THE CRUISE CONTROL ENGAGED AND AFTER AN EXTENDED RIDE FROM 45 TO 90 MINUTES, ALL WARNING LIGHTS ILLUMINATED. THE CRUISE CONTROL DISENGAGED BY IT SELF AND THE ENGINE HESITATED. THE VEHICLE WAS TAKEN TO THE DEALERSHIP TWICE, WHO PERFORMED A NHTSA RECALL #06V41000 WHICH ENTAILED UPGRADING THE CURRENT SOFTWARE. HOWEVER, THE PROBLEM WAS NOT CORRECTED EITHER TIME, THE LURCH/STALL PROBLEM CONTINUED. THE DEALERSHIP AND THE MANUFACTURER COINCIDED THE REPLACEMENT OF THE AIR FLOW CONTROL AND THE ABS CONTROL UNIT WAS NOT COVERED BY THE VEHICLE'S EXTENDED WARRANTY, EVENTHOUGH THOSE REPLACEMENT CORRECTED THE PROBLEM. THE CONTACT WAS VERY CONCERNED BECAUSE THE RECALL DID NOT SOLVE THE DANGEROUS PROBLEM. UPDATED 12/28/2006 - *NM

DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS ON VARIOUS ROAD CONDITIONS, THERE WAS A LOSS OF ALL VEHICLE POWER FOLLOWED BY THE ENGINE STALLING WITHOUT WARNING. AFTERWARDS, THE ENGINE WAS EASILY RESTARTED. THE VEHICLE WAS INSPECTED BY A DEALER, WHO WAS UNABLE TO DUPLICATE THE PROBLEM. THERE WAS A NHTSA RECALL, #06V441000, REGARDING THE VEHICLE SPEED CONTROL. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN. THE MANUFACTURER WAS ALERTED.

I BROUGHT MY 2005 XC90 IN FOR ROUTINE MAINTENANCE AT 25,500 MILES. AT THAT TIME, IT WAS DETERMINED THREE OF THE FOUR TIRES WERE WORN ON THE OUTER EDGES AND SHOULD BE REPLACED. THIS IS UNACCEPTABLE FOR A VEHICLE TO HAVE THREE OF ITS TIRES REPLACED WITHIN THE FIRST 25K MILES OF SERVICE. SOMETHING IS OBVIOUSLY WRONG WITH EITHER THE TIRES OR THE VEHICLE DYNAMICS. *JB

ELECTRICAL PROBLEMS: FIRST, THE LIGHT BULBS, INCLUDING HEADLIGHTS, BRAKE LIGHTS, AND TURN SIGNALS, ON MY 2001 VOLVO S60 HAD TO BE REPLACED AT LEAST EVERY TWO MONTHS. THIS IS CAUSING PROBLEMS WITH VISIBILITY AND ALSO WITH THE LOCAL POLICE DEPARTMENT -- THEY DON'T LIKE IT WHEN I'M DRIVING THROUGH TOWN WITH NO LIGHTS ON. SECOND, THE INTERIOR LAMPS ABOVE MY DASHBOARD AND THE SUNROOF STOPPED WORKING ON AN INTERMITTENT BASIS. FOR NO SEEN REASON, I WON'T BE ABLE TO OPEN OR CLOSE THE SUNROOF (NOT GREAT WHEN IT'S RAINING AND I CAN'T GET IT CLOSED) AND THE LIGHTS WON'T WORK EITHER. *JB

WHILE DRIVING ON I-290 THE ENGINE OF MY 2003 VOLVO S60 SUDDENLY LOST ALL POWER. I NARROWLY ESCAPED SEVERAL SERIOUS ACCIDENTS ON A BUSY CHICAGO HIGHWAY. WHEN THE CAR LOSES POWER THERE IS ABSOLUTELY NOTHING THE OPERATOR CAN DO TO MOVE OVER TO THE SIDE. I WAS DRIVING APPROX. 60 MPH WHEN THIS HAPPENED. THE VEHICLE COMPLETELY STALLED, AND I WAS ABLE TO RESTART THE VEHICLE AFTER APPROX. 30-60 SECONDS. THE PROBLEMS EXHIBITED BY THE CAR ARE EXACTLY THE SAME AS THE RECENT RECALL THAT VOLVO HAS ANNOUNCED FOR VOLVO VEHICLES. MY CAR IS NOT INCLUDED IN THIS RECALL. THE CAR IS NOW STALLING RANDOMLY AT LOWER SPEEDS. *NM

1. LOSS OF ACCELERATION AND SOMETIMES STALLING DURING FREEWAY TRANSITION FROM ON RAMP TO FREEWAY AND OR DURING LEFT TURNING AGAINST TRAFFIC. 2. THE CAR FAILED TO ACCELERATE AND THE ACTION OF PUSHING THE ACCELERATOR CAUSED THE TRANSMISSION TO DOWN SHIFT CAUSING THE EXTREME SLOWING AND SOMETIMES STALLING. THE CONSEQUENCES WERE THAT TRAFFIC WAS GOING CONSIDERABLY FASTER AND HAD TO TAKE EVASIVE ACTION TO AVOID HITTING THE SLOWING CAR. 3. TODAY THE MEDIA REPORTED A POTENTIAL RECALL OF VOLVO'S DUE TO THIS PROBLEM AND I BELIEVE IT SHOULD BE EXTENDED TO 1997 MODEL 850 GLT. *JB

DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS ON THE HIGHWAY, THE AIR SUPPLY BRAKE CONTROL RELEASE VALVE EXPELLED THE BRAKE AIR AND DEPLETED THE AIR BRAKE SUPPLY WITHOUT WARNING WHICH RESULTED IN POOR BRAKE FUNCTION AS WELL AN INCREASED STOPPING DISTANCE. THE VEHICLE WAS INSPECTED BY A DEALER, WHO DETERMINED THE MAGNETVENTIL VALVE NEEDED TO BE REPLACED. AFTER THE INITIAL REPLACEMENT, THE PROBLEM PERSISTED. THE MANUFACTURER WAS ALERTED.

2001 VOLVO V70 SURGES WHILE UNDERWAY, SURGES AND STALLS AT IDLE, GOES INTO REDUCED PERFORMANCE MODE (20 MPH OR LESS). CAR RUNS NORMALLY WHEN COLD (UP TO 1 MILE AFTER STARTING IN MORNING), THEN BEGINS TO SURGE AND FAIL. NEED TO PULL OVER TO SHOULDER, STOP ENGINE FOR 3 MINUTES, AND RESTART. IF ENGINE IS STOPPED FOR LESS THAN 3 MINUTES, IT RESTARTS IN 20 MPH MODE. THIS HAS HAPPENED DAILY FOR 2 WEEKS. INDEPENDENT MECHANIC REPLACED IGNITION COIL BASED ON OBD CODE, BUT PROBLEM RECURRED THE NEXT DAY. HAVE APPOINTMENT WITH VOLVO SERVICE DEPARTMENT 11/22/06. *JB

MY 2006 XC90 HAS BEEN STALLING WHILE DRIVING ON THE FREEWAY. IT IS VERY ALARMING AND DANGEROUS. THE FUEL PUMP AND MULTIPLE ELECTRONIC COMPONENTS HAVE BEEN REPLACED THREE TIMES. *JB

FOR THE PAST YEAR MY CAR HAS BEEN REEKING OF GASOLINE FUMES, NORMALLY IN THE MORNING WHEN COLD STARTING, BUT WOULD OCCUR PERIODICALLY THROUGHOUT THE DAY. THE SMELL WAS SO OVERWHELMING THAT I COULD NOT TURN THE HEATER ON IN THE CAR, AND WOULD HAVE TO PUT THE WINDOWS DOWN IN THE CAR WHILE DRIVING DOWN THE ROAD TO TRY TO RID THE CAR OF FUMES. I TOOK THE CAR TO THE VOLVO DEALER AND LEFT IT WITH THEM FOR DAYS. THEY ASSURED ME IT WAS A ACCUMULATION OF SOMETHING IN THE VENT SYSTEM, AND THEY CLEANED THAT OUT. THE PROBLEM STILL EXISTED. I FINALLY TOOK IT TO ANOTHER MECHANIC WHO FOUND THE PROBLEM. THE FUEL RAIL. THE END PIECE WOULD ALLOW FUEL TO VIRTUALLY SPILL OUT. PLEASE REFER TO THIS WEB SITE WHICH DESCRIBES THIS POTENTIALLY DANGEROUS SITUATION IN DETAIL: HTTP://WWW.VOLVOCLUB.ORG.UK/FAQ/960_90INFO.HTML#960B6300FUELRAILLEAKAGEPROBLEMS MY CAR WAS A POTENTIAL TIME BOMB. NOT ONLY DID VOLVO NOT FIND THE PROBLEM, BUT WHEN MY NEW MECHANIC FOUND THE PROBLEM IT TOOK MY MECHANIC THREE TRIPS TO VOLVO IN ORDER TO HAVE THEM ORDER THE CORRECT PARTS AS VOLVO NO LONGER MANUFACTURERS THAT PARTICULAR PART - HMMMM....I WONDER WHY. THIS COULD HAVE CAUSED A HORRIBLE SITUATION, ESPECIALLY WITH MY CHILDREN IN THE VEHICLE. WE EXPERIENCED SORE THROATS, AND FROZE TO DEATH ON COLD MORNINGS NOT BEING ABLE TO TURN THE HEATER ON DUE TO BEING FUMIGATED WITH GASOLINE FUMES. *NM *NM