VOLVO Complaints

2000 VOLVO S80 STALLING WHILE DRIVING SEVERAL EPISODES, ALL AT LOW SPEED THE EPISODE BELOW WAS THE LAST. *JB

ON 4 SEPARATE OCCASIONS (3 CITY DRIVING <35 MVPH, AND 1 HWY DRIVING 60 MPH) MY 2001 VOLVO C70 CONVERTIBLE SUDDENLY LOST SPEED TO <5 MPH. ON 3 OCCASIONS, I WAS ABLE TO RESTART THE CAR, ALTHOUGH AFTER SEVERAL ATTEMPTS, AND STILL GET TO MY DESTINATION AND BACK HOME WITHOUT PROBLEMS. DURING THE HIGHWAY TRAVEL, WHICH WAS ON A VERY RAINY EVENING, I WAS ABLE TO KEEP THE CAR RUNNING , AFTER DIFFICULTY RESTARTING, AT SLOW SPEED. AND WITH A LOT OF PRAYERS, FINALLY GOT TO A PARKING LOT WHERE I LEFT THE CAR OVERNIGHT, CALLED FOR A RIDE HOME, AND ANOTHER RIDE TO PICK IT UP THE FOLLOWING MORNING. TOOK IT TO HONOLULU VOLVO DEALER WHO SAID IT WAS THE THROTTLE, MODULE AND COMPUTER, AND COST OVER $1000 FOR PARTS ALONE. I DID NOT HAVE IT REPLACED (THEY WERE SPECIAL ORDER FROM THE MAINLAND), AND THEY SAID THE CAR WAS DRIVABLE. I NOW HAVE A TEMPORARY REPLACEMENT WHICH I NEED FOR WORK WHILE THE VOLVO IS PARKED IN THE DRIVEWAY!*JB

MY 1999 VOLVO S70 GLT WAS JUST TURNED INTO MY LOCAL DEALER. THE ELECTRONIC THROTTLE MODULE IS THE PRIMARY SUSPECT. ROUGH IDLE, STALLING, SURGING AT IDLE, BURSTS OF OVERLY RICH FUEL MIX AT IDLE. INTERMITTENT SYMPTOMS AT IDLE. RUNS OK AT FREEWAY SPEEDS WITH MILD SURGING. *JB

RE:1999, S-80,T-6 VOLVO. SAW AN AP ARTICLE IN MY LOCAL PAPER TODAY RE COMPLAINT INVESTIGATION. I EXPERIENCED VIRTUALLY ALL OF THE SAME PROBLEMS CITED IN THE ARTICLE. NAMELY STALL W/O WARNING, FROM A STOP,STEP ON GAS AND BARELY WOULD MOVE(LIKE SLIPPING CLUTCH ON A MANUAL TRANSMISSION) , HAD NUMEROUS INCIDENTS WHERE I FELT VULNERABLE AND UNSAFE IN TRAFFIC, LOSS OF POWER STEERING ETC. SOUNDS VERY MUCH LIKE THESE OTHER COMPLAINTS. AT SAME TIME I HAD LOTS OF INCORRECT "READOUTS" ON DASH PANEL. I COMPLAINED TO DEALER WHO SAID THIS ALL COULD BE RELATED TO THE ABS CONTROL MODULE WHICH WAS REPLACED AT COST OF $825.00. OLD PART WAS NOT GIVEN BACK TO ME. OF NOTE IS THAT DURING THE SAME REPAIR A BELT WAS REPLACED WHICH THEY DID GIVE BACK TO ME, BUT NOT THE MODULE. MILEAGE WAS ONLY 61,376. THIS MODULE DID SOLVE THE PROBLEM HOWEVER I AM NOW GETTING ANOTHER GOOFY READOUT THAT DEALER SAYS COULD BE A DEFECTIVE MODULE. CURRENT MILEAGE IS 61779. I DID NOT THINK THAT FAILURES OF THIS TYPE SHOULD OCCUR AT SUCH LOW MILEAGE. AT THE TIME I ASKED IF THERE WAS A RECALL FOR THIS AND WAS TOLD NO. I AM NOT HAPPY WITH THIS SITUATION AND II DO SUSPICION THAT A DEFECT EXISTS. *JB

INCIDENCE 7 OF 7 SIMILAR. AS REPORTED ON SERVICE INVOICE: "CUSTOMER STATES: EVER SINCE THROTTLE WAS DONE A COUPLE OF MONTHS AGO, FEELS LIKE IT IS GOING IN AND OUT OF GEAR WHILE DRIVING- FEELS FOR A MICRO SECOND AT VARIOUS TIMES GOING IN AND OUT OF GEAR. NINO CAN CALL FOR MORE INFO IF NECESSARY. REFER TO RO 435245 09/17/04 78697 MILES - FOUND DEFECT IN THROTTLE UNIT ASSEMBLY REPLACED -- TECHNICIAN FOUND CODES FOR ETM INTERNAL MALFUNCTION. REPLACED ETM AND PERFORMED DOWNLOAD." THIS INCIDENT WAS THE 7TH OF 7 SIMILAR PROBLEMS OCCURRING LATER THAT ULTIMATELY LEAD TO HAVING THE THROTTLE BODY CLEANED TWICE & THEN REPLACED TWICE. I HAVE REPORTED ALL THE PREVIOUS INCIDENTS IN SEQUENCE OF OCCURRENCE ON THIS NHTSA COMPLAINT SITE AS WELL. NOTE THAT THIS PARTICULAR INCIDENT SEEMS TO BE CONSISTENT WITH ALREADY-RECOGNIZED NHTSA ACTION NUMBER PE05041 "FAILURE OF THE ELECTRONIC THROTTLE CONTROL MODULE (ETM) IN THE SUBJECT VEHICLES." PREVIOUSLY REPORTED INCIDENTS: 1) ODI #10131200 2) ODI #10131206 3) ODI #10131207 4) ODI #10131208 5) ODI #10131209 6) ODI #10131213. *JB

INCIDENCE 6 OF 7 SIMILAR. AS REPORTED ON SERVICE INVOICE: "CUSTOMER STATES: ETS LIGHT CAME ON AFTER DRIVING CAR AT HIGHWAY SPEEDS. WHEN DECELERATING DOWN TO LOCAL (TOWN) SPEED CAR HAS A SEVERE SPUTTERING, HESITATION AS IF IT WAS GOING TO STALL. FAULT TRACED SYSTEM WITH VADIS AND RETRIEVED CODES ECM-532D ECM-9190, ECM-91A7, AND ECM-91F0... REPLACED ELECTRONIC THROTTLE ASSEMBLY, AND DOWNLOADED NEW SOFTWARE TO ADAPT CAR." THIS INCIDENT WAS THE 6TH OF 7 SIMILAR PROBLEMS OCCURRING LATER THAT ULTIMATELY LEAD TO HAVING THE THROTTLE BODY CLEANED TWICE & THEN REPLACED TWICE. I WILL BE REPORTING ALL THESE SUBSEQUENT INCIDENTS IN SEQUENCE OF OCCURRENCE ON THIS NHTSA COMPLAINT SITE AS WELL. NOTE THAT THIS PARTICULAR INCIDENT SEEMS TO BE CONSISTENT WITH ALREADY-RECOGNIZED NHTSA ACTION NUMBER PE05041 "FAILURE OF THE ELECTRONIC THROTTLE CONTROL MODULE (ETM) IN THE SUBJECT VEHICLES." PREVIOUSLY REPORTED INCIDENTS: 1) ODI #10131200 2) ODI #10131206 3) ODI #10131207 4) ODI #10131208 5) ODI #1013120.*JB

99 VOLVO S70 STARTED TO BUCK AND HESITATE AT 60 + MPH. I DID NOT FEEL IT WAS SAFE TO DRIVE SINCE THE ENGINE ACTED LIKE IT WANTED TO CUT OUT ENTIRELY. I TOOK VEHICLE TO VOLVO DEALER WHERE THEY REPLACED ETM, ELECTRONIC THROTTLE, AT A COST OF CLOSE TO $ 1000. VEHICLE ONLY HAD 76000 MILES ON IT.*JB

INCIDENCE 5 OF 7 SIMILAR. AS REPORTED ON SERVICE INVOICE: "CUSTOMER STATES: CHECK ENGINE LIGHT ON. THERE ARE DRIVE ABILITY CONCERNS. CAR CUTS OUT INTERMITTENT RIGHT AFTER STARTING - WARM OR COLD START. SEE ATTACHED. ACCESS DIAGNOSTIC CODES: ECM 2110 AND ECM 720A. REPLACE IMMOBILIZER ANTENNA RING AND FRONT OXYGEN SENSOR. RESET ADAPTATION." THIS INCIDENT WAS THE 5TH OF 7 SIMILAR PROBLEMS OCCURRING LATER THAT ULTIMATELY LEAD TO HAVING THE THROTTLE BODY CLEANED TWICE & THEN REPLACED TWICE. I WILL BE REPORTING ALL THESE SUBSEQUENT INCIDENTS IN SEQUENCE OF OCCURRENCE ON THIS NHTSA COMPLAINT SITE AS WELL. PREVIOUSLY REPORTED INCIDENTS: 1) ODI #10131200 2) ODI #10131206 3) ODI #10131207 4) ODI #10131208. *JB

INCIDENCE 4 OF 7 SIMILAR. AS REPORTED ON SERVICE INVOICE: "CUSTOMER REPORTS: 1) WHEN SLOWING DOWN TO A STOP TACH DROPS AND THEN PICKS BACK UP WHEN CAR COMES TO A STOP. CLEAN THROTTLE HOUSING. 2) WAS GETTING 20 MILES PER GALLON NOW ABOUT 17 1/2. PERFORM SOFTWARE UPGRADE FOR ECM, TCM AND ETM." THIS INCIDENT WAS THE 4TH OF 7 SIMILAR PROBLEMS OCCURRING LATER THAT ULTIMATELY LEAD TO HAVING THE THROTTLE BODY CLEANED TWICE & THEN REPLACED TWICE. I WILL BE REPORTING ALL THESE SUBSEQUENT INCIDENTS IN SEQUENCE OF OCCURRENCE ON THIS NHTSA COMPLAINT SITE AS WELL. PREVIOUSLY REPORTED INCIDENTS: 1) ODI #10131200 2) ODI #10131206 3) ODI #10131207. *JB

INCIDENCE 3 OF 7 SIMILAR. AS REPORTED ON SERVICE INVOICE: "[THROTTLE & CRUISE] CUSTOMER REPORTS: ETS LIGHT COMES ON INTERMITTENTLY - LIGHT GOES OUT ON RESTART. ACCESS DIAGNOSTIC CODES: ECM 91A7. PERFORM SOFTWARE DOWNLOAD & RESET ADAPTATIONS." THIS INCIDENT WAS THE 3RD OF 7 SIMILAR PROBLEMS OCCURRING LATER THAT ULTIMATELY LEAD TO HAVING THE THROTTLE BODY CLEANED TWICE & THEN REPLACED TWICE. I WILL BE REPORTING ALL THESE SUBSEQUENT INCIDENTS IN SEQUENCE OF OCCURRENCE ON THIS NHTSA COMPLAINT SITE AS WELL. PREVIOUSLY REPORTED INCIDENTS: 1) ODI #10131200 2) ODI #10131206. *JB