VOLVO Complaints

WHILE DRIVING CLUTCH CYLINDER WILL STICK AND OR LOCK UP, CAUSING VEHICLE TO DISENGAGE. DEALER HAS BEEN NOTIFIED; HOWEVER, HAS NO REMEDY FOR PROBLEM.*AK

STEER SHAFT WOULD LOCK UP WHILE DRIVING AND BECOME INOPERABLE. DEALER HAS BEEN NOTIFIED; HOWEVER, HAS NO REMEDY.*AK

AXLE:REAR: U BOLTS FAILED, RESULTING IN VEHICLE BECOMING INOPERABLE. DEALER HAS BEEN NOTIFIED;HOWEVER, WAS UNABLE TO FIND REMEDY FOR PROBLEM. THERE ARE 15 OTHER VEHICLES WITH SIMILAR PROBLEMS.**AK

WHEN TAKING VEHICLE INTO DEALERSHIP TO CHANGE TIE ROD ENDS TIRE AND WHEEL SIZE, THEY NEVER DID A FRONT END ALIGNMENT. THIS CAUSED NEW TIRES TO WEAR OUT SOONER THEN NORMAL. CONTACTED DEALER. *AK CONSUMER STATES THAT THE NEW TIRES HAD 80000 MILES ON THEM AND WORE THE INSIDES ABOUT 3 INCHES ON BOTH TIRES, ONE TIRE WAS SO BAD THAT CONSUMER GOT NO TRADE ALLOWANCE, THE TIRES THAT WERE ON WHEN RECALL 02V037005 WAS COMPLETED HAD APPROX 125000 MILES AND STILL HAD GOOD TREAD, CONSUMER WAS INFORMED BY THE VOLVO HOTLINE THAT THE ALIGNMENT WAS NOT INCLUDED IN THE RECALL. HOOD LATCH WAS OUT OF ADJUSTMENT, DEALER REMOVED AND REPLACED. ALL LIGHTS ON TRAILER BLINK WHEN TRUCK IS HOOKED TO TRAILER AND USING TURN SIGNALS OR 4 WAY, ENGINE CONTINUES TO RUN WITH THE KEY TURNED OFF. *SLC

PLASTIC ON CHILD SEAT LOCK CRACKED/ASSEMBLY FELL APART WITHOUT ANY STRESS OR TENSION BEING APPLIED TO IT.

ENGINE SUFFERS COMPLETE SHUTDOWN AT 30-40MPH. OCCURS 3-4 TIMES A WEEK AND HAS BEEN HAPPENING FOR LAST 3-4 MONTHS. DEALER CAN FIND NO PROBLEM AND HAS NEVER HEARD OF SUCH A PROBLEM HOWEVER I SEE SEVERAL REFERENCES TO THIS EXACT PROBLEM AT THIS DATABASE AND ALSO WWW.CARREVIEW.COM. ENGINE WILL RESTART WITH NO PROBLEM HOWEVER OBVIOUSLY WHEN ENGINE STOPS ALL POWER TO BRAKING AND STEERING SYSTEM IS LOST. ALWAYS HAPPENS WHEN COASTING, TYPICALLY DOWN LOW GRADE, AND TAKING A CORNER. I BELIEVE ISSUE IS TIED TO POWER STEERING, CLIMATE CONTROL AND LOW RPM (OR COMBO THEREOF) AS AT THIS SPEED THE TACHOMETER SWINGS WILDLY BETWEEN 400 AND 1200 RPM THOUGH SPEED IS STEADY (POSSIBLE EMISSION CONTROL ISSUE).*AK

THE FUEL TANK WAS OBSERVED TO BE LEAKING ON 7/8/02 AND THIS WAS CONFIRMED BY A TECHNICIAN ON 7/9/02. THE LEAKAGE OCCURS ON ONE OR MORE OF THE MOLDED BOSSES UPON WHICH THE HEAT SHIELD IS MOUNTED. MY SUSPICION IS BUILT-IN STRESSES FROM THE MOLDED BOSS, PERHAPS NOT RADIUSED PROPERLY WHERE THE BOSS JOINS THE TANK WALL. IT MAY ALSO BE A MATERIALS PROBLEM. THE TECHNICIAN ANALYZING THE PROBLEM SAID THAT THEY HAD SEEN THE SAME FAILURE ON ANOTHER 850 TANK WITHIN THE LAST 10 DAYS. IT IS ALSO POSSIBLE THAT OUR EXTREME AMBIENT HEAT MAY HAVE CAUSED A RELATIVELY INFLEXIBLE HEAT SHIELD TO STRESS THE ASSEMBLY. IT SEEMS TO BE A CRITICAL SAFETY PROBLEM, AND I AM DISAPPOINTED THAT VOLVO HAS NOT BEEN WILLING TO JOIN IN REMEDYING THIS SITUATION WITH US, AFTER CALLING IT TO THEIR ATTENTION.*AK

FRONT PASSENGER SIDE AND LEFT REAR DOOR LOCKS FAILED MAKING IT IMPOSSIBLE TO LOCK VEHICLE WITH THE KEY OR THE DOOR LOCK BUTTON. DEALER WAS NOTIFIED BUT WOULD NOT FIX THE LOCKS. MANUFACTURER NOTIFIED. *TT

WHILE PULLING INSIDE OF THE DRIVEWAY, VEHICLE STARTED SMOKING. VEHICLE WAS ON FIRE. DEALERSHIP WAS AWARE OF PROBLEM.*AK TO DATE, THE CAUSE OF FIRE IS STILL UNDETERMINED. IT APPEARS THE COOLANT OVER FLOW BOTTLE EXPLODED AND SOME HOW SET FIRE TO THE ENGINE. VOLVO WANTS TO TAKE NO RESPONSIBILITY FOR THE VEHICLE ALTHOUGH IT IS STILL UNDER WARRANTY. *JG

FAILURE OF MODULE DISENABLED THE ABS. SPORATIC FAILURE FIRST OCCURRED AT 32000 MI, BUT COMPLETE FAILURE OCCURRED AT 52,000 MILES. CAR REPAIRMAN INDICATES THAT FAILURE OF THIS MODULE IS COMMON FOR 1996-1998 VOLVOS. HE REPLACES 3-4 PER WEEK. *AK