2004 YAMAHA FZ6 Complaints

BIKE IDLE DROPS (600-850 RPM) WHEN CLUTCH PULLED IN CAUSING VEHICLE TO STALL AT RED LIGHTS, EXITING DRIVEWAYS ETC... POOR FUEL MILEAGE AND ROUGH IDLE. UPON CYCLING THE IGNITION KEY OFF AND ON, SYMPTOM WILL TEMPORARILY RECTIFY ITSELF ONLY TO RETURN LATER. I AM FEARFUL OF A REAR-END IMPACT FROM ANOTHER VEHICLE AT INTERSECTIONS AS A RESULT OF THIS PROBLEM. IT SEEMS THAT THE "THROTTLE SENSOR ASSY" PART NO. 5FL-85885-05-00 IS THE MAJOR CULPRIT PER OTHER OWNERS EXPERIENCES WITH THIS VEHICLE AND SAME SYMPTOMS. *NM

'94 FZ6 - 5,000 MILES. THE BIKE HAD A HARD TIME STARTING. NOW IT CAN BE RUNNING AT A STEADY 3000-4500 RPM ON THE HIGHWAY AND START TO STUMBLE OR CUTOUT. I'VE HAD TO PULL OVER AND CUT IT OFF AND RESTART IT TO GET IT TO STOP. IT HAPPENS WHENEVER IT WANTS, NO WARNING OR REASON. IT STALLED ONCE WHILE I WAS ON THE WAY TO WORK AND I DROPPED THE BIKE BEFORE I COULD CATCH IT. I'VE HAD FRIENDS TELL ME THAT IT IS A TPS (THROTTLE POSITION SENSOR), BUT THE MOTORCYCLE IS OUT OF WARRANTY AND I DON'T HAVE THE MONEY TO TAKE IN TO BE CHECKED. THAT WOULD BE ALMOST $100 AND THEY MAY NOT FIND IT. *NM

TROTTLE CHUNKY/DELAYED/ERRATIC, MAKING MOTORCYCLE DIFFICULT TO CONTROL IN CORNERS. STALLS AT STOPS, A DANGEROUS SITUATION IN CITY TRAFFIC. DOES NOT IDLE, I NEED TO KEEP THE THROTTLE SLIGHTLY ROLLED ON. RUNS ROUGH, SMELLS OF GAS, SEEMS TO MISS. PROBLEMS STARTED WITH THROTTLE DELAY AT 7000 MILES, STALLING STARTED AT 7400 MILES. *JB

RIDING HOME FROM WORK ON A 2004 YAMAHA FZ6, WITH JUST OVER 5K MILES ON IT. THE BIKE BEGAN TO SURGE BY ITSELF AND WOULD EITHER GO TO A FULL OPEN THROTTLE (WITHOUT ANY USER INPUT) OR WOULD HOLD A CONSTANT RPM (REGARDLESS OF USER INPUT). THE FIRST SURGE WAS VERY VIOLENT (WHEELIE STYLE THROTTLE INPUT) AND NEARLY KICKED ME OFF THE BACK. LOST GRIP WITH MY THROTTLE HAND, BUT WAS ABLE TO GRAB CLUTCH AND AVOID AN ACCIDENT. VERY INCONSISTENT THROTTLE RESPONSE THE REST OF THE RIDE HOME (~4 MILES). SOUND FROM EXHAUST HAD ALSO DIES DOWN AND WAS VERY QUIET. UPON ARRIVAL AT HOME, I PARKED THE BIKE AND FELT THE EXHAUST AND IDLE - EVERYTHING WAS NORMAL. UPON THE SLIGHTEST THROTTLE INPUT ABOVE IDLE, THERE WOULD BE NO PRESSURE FROM THE TAIL PIPE AND THE AIR AROUND THE EXHAUST WOULD BECOME INSTANTLY SUPER HEATED. I HAD THE BIKE TOWED TO A REPAIR SHOP (DEL AMO MOTORSPORTS) TO HAVE IT LOOKED AT. THEY RAN DIAGNOSTICS AND FOUND NO ERRORS. HOW CAN THERE BE NO ERRORS WHEN THE BIKE DROVE AROUND WITH A MIND OF ITS OWN? THE BIKE IS STILL AT THE DEALER, WILL UPDATE THE REPORT LATER. HAVE HAD ALL SERVICE CHECKS, BIKE HAS BEEN DOING FINE, EXCEPT FOR A ROUGH IDLE, DIAGNOSED AS A TPS PROBLEM BY TEXAS YAMAHA SOUTH OUTSIDE OF HOUSTON, TX. THIS WAS DONE AROUND THE 700 AND AGAIN AROUND THE 1200 MILE MARK. PROBLEM (ASSOCIATED WITH TPS, AS DIAG. BY TYS) STOPPED AROUND 1400 MILES THEN SHOWED UP AROUND 4700 AND HAS BEEN DOING IT EVER SINCE. *NM

1. BIKE STARTED AND WARMED UP FINE. AFTER ABOUT AN HOUR OF RIDING BIKE WAS IDLING VERY LOW AT A STOP SIGN (800-900 RPM). POWER DELIVERY WAS CHOPPY FROM A STOP ALSO. AT THE NEXT STOP LIGHT THE BIKE STALLED, AND I NEEDED TO USE THE THROTTLE TO KEEP IT IDLING . I SHUT THE BIKE OFF AT SOME POINT, TURNED IT BACK ON AND THE BIKE WAS BACK TO NORMAL. AFTER ABOUT 10 MORE MINUTES OF RIDING THE BIKE STALLED AT ANOTHER STOP LIGHT. SINCE FIRST OCCURRENCE THIS PROBLEM HAS BEEN INTERMITTENT BUT USUALLY GOES AWAY IF THE BIKE IS SHUT OFF, THEN TURNED BACK ON. . *NM

ENGINE RPM'S WOULD "STUMBLE" INCREASINGLY MORE FREQUENT, STALL AT IDLE. THROTTLE POSITION SENSOR DEFECTIVE AND NOT READILY IDENTIFIED AS DEFECTIVE BY AUTHORIZED DEALERSHIP. POOR THROTTLE RESPONSE/STALLING LED TO POOR CONTROL AT HIGHWAY SPEEDS, EXITING RAMPS, HARD CORNERING WHERE NEED FOR IMMEDIATE THROTTLE RESPONSE WAS REQUIRED. TWO OF THESE UNITS HAVE FAILED ON MY MOTORCYCLE, A 2004 YAMAHA FZ6. *JB

BIKE STALLS WHEN CLUTCH IS PULLED IN. RPM'S DROP TO ZERO. WAS ALMOST RUN OVER BY TRAFFIC BEHIND ME WHEN ENGINE STALLS. INJURED MYSELF (FOOT/ANKLE) WHEN TRYING TO PUSH THE BIKE OFF THE ROAD (SO I WOULDN'T BE RUN OVER). I'VE BEEN TOLD BY MANY FZ6 RIDERS THAT MANY OF THE FZ6 BIKES HAVE DEFECTIVE THROTTLE POSITIONING SENSORS (TPS) AND THAT YAMAHA HAS NOT RECOGNIZED THE PROBLEM. I BELIEVE IT TO BE A VERY SERIOUS SAFETY ISSUE. SOONER OR LATER, SOMEONE IS GOING TO GET RUN OVER BECAUSE OF THIS DEFECTIVE SENSOR. *NM

I HAVE A 2004 YAMAHA FZ-6 AND I BELIEVE THE THROTTLE POSITION SENSOR IS BAD. THE BIKE STALLS AND RUNS VERY ERRATICALLY AT LOW RPMS. I HAD TO PULL TO THE SIDE OF THE ROAD AND TURN THE KILL SWITCH AND KEY OFF TO RESET THE SYSTEM AND THEN IT STARTED AGAIN. IF THIS WERE TO HAPPEN IN A HIGH TRAFFIC AREA THE BIKE COULD STALL AND CAUSE AN ACCIDENT. I HAVE DONE NOTHING TO REPAIR THIS PROBLEM YET, I AM WAITING TO SEE IF THERE IS A RECALL ON THIS PART. I KNOW THAT THIS IS A VERY COMMON PROBLEM WITH THIS MODEL MOTORCYCLE. *NM

I HAVE HAD ISSUES WITH MY YAMAHA FZ6. THE MANUAL ADVISES TO USE 87 OCTANE FUEL. I HAVE BEEN USING 87 UNTIL THE BIKE STARTED TO IDLE AT VERY VERY LOW INTERVALS. CAUSING LOSS OF POWER WHEN DRIVING, OR STOPPED. NORMAL IDLE IS 1320 RPM. IDLE WILL DROP BETWEEN 600-800 RPM WHEN STOPPED CAUSING THE BIKE TO DIE (EVERY TIME) OR WHILE DRIVING THE BIKE WILL IDLE FINE THEN THE RPM'S WILL DROP WAY DOWN , THEN BACK UP THEN DOWN THEN WAY BACK UP. I TOOK THE BIKE TO THE REPAIR SHOP AND THEY SAID THEY WOULD ADJUST THE BIKES IDLE. THIS FIXED THE PROBLEM FOR A MONTH AND THEN I BEGAN HAVING THE SAME PROBLEM AS BEFORE. IDLE DROPPING AFTER FILLING WITH 87 OCTANE. I DECIDED TO TRY OTHER FUELING STATIONS 87 OCTANE. STILL NO CHANGE. I DECIDED TO TRY 89 OCTANE. WITH 89 OCTANE, SMALL IMPROVEMENT, WITH THE SAME ISSUES. I THEN DECIDED BECAUSE OF THIS PROBLEM CAUSING ME TO HAVE 4 CLOSE ACCIDENT ENCOUNTERS TO GO AHEAD AND TRY 92 (PREMIUM GRADE OCTANE). THIS SEEMED TO FIX THE PROBLEM OF THE IDLE DROPPING WAY DOWN, HOWEVER, THE IDLE STAYS HIGHER NOW THAN THE NORMAL 1320 RPM. NOW AROUND THE 1400 RPM RANGE. THE BIKE STILL HAS A ISSUE WITH POWER CUTTING IN AND OUT WITH NO IDLE CHANGE. I'M REPORTING THIS PROBLEM BECAUSE I HAVE HAD 4 ALMOST CRITICAL ENCOUNTERS WITH OTHER VEHICLES BECAUSE OF THE LOSS OF IDLE/POWER WHILE EITHER BEING STOPPED OR DRIVING. I DECIDED TO POST THIS PROBLEM UP ON WWW.SPORTBIKES.NET. I FOUND THAT 5 OTHER FZ6 RIDERS HAD THE SAME PROBLEM AND THAT THEY TOO HAD CLOSE ENCOUNTERS WITH OTHER VEHICLES. JUST FYI I MADE THE POST ON 07/29/05 AND ALREADY ON 07/30/05 THERE HAVE BEEN 5 OTHERS WITH THE SAME BIKE, HAVING THE SAME ISSUE. THIS IS A GREAT AMOUNT. SOME HAVE TRACKED THIS PROBLEM DOWN TO THE TPS - THROTTLE POSITION SENSOR. THEY REPORTED AFTER HAVING THIS REPLACED THIS FIXED THE PROBLEM COMPLETELY. SENSE I HAD THIS PROBLEM WITHIN THE 6 MONTHS OF HAVING THE BIKE, AND DUE TO OTHERS HAVING THIS ISSUE, A RECALL ON THIS BIKE SHOULD BE ISSUED. *JB

IN SEPTEMBER OF 2004 AT APPROXIMATELY 5000 MILES, THE MOTORCYCLE BEGAN IDLING POORLY AND STALLING. HAD TO TURN OFF THE KEY AND THEN BACK ON BEFORE IT WOULD START AGAIN. YAMAHA REPLACED THE THROTTLE POSITION SENSOR AFTER BRINGING IT TO THEM TWICE WHICH CORRECTED THE PROBLEM. I HAVE ALMOST 13000 MILES ON IT NOW AND IT IS DOING THE SAME THING AGAIN. IT IS A SAFETY ISSUE BECAUSE IT IS DISTRACTING AND HINDERS MY ABILITY TO WATCH TRAFFIC AND FREQUENTLY STALLS AT TRAFFIC LIGHTS.