2004 YAMAHA ROAD STAR Complaints

I OWN A 2004 YAMAHA ROADSTAR, 1700CC MOTORCYCLE. I HAVE HAD A PROBLEM WITH THE REAR EXHAUST VALVES STICKING FOR THE LAST 20,000 MILES. I HAVE BEEN TO DEALER AFTER DEALER AND HAVE HAD NO SUCCESS IN HAVING MY PROBLEM FIXED. I BELIEVE THERE IS A POTENTIAL SAFETY RISK WITH THIS PROBLEM, BECAUSE THE BIKE WILL SUDDENLY LOSE ALL POWER AND QUIT RUNNING. IT IS JUST A MATTER OF TIME BEFORE SOMEONE HAS THIS HAPPEN AND IS SERIOUSLY INJURED OR EVEN KILLED. *JB

THE VALVES STICK OPEN ON MY 2004 YAMAHA MOTORCYCLE. THEY STUCK OPEN IN THE MIDDLE OF A LEFT TURN IN A THREE-WAY INTERSECTION AND ALMOST RESULTED IN A HEAD-ON COLLISION. MY DEALER IS AWARE OF THIS PROBLEM AND HAS CHOSE TO IGNORE IT. *NM

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

2004 YAMAHA ROADSTAR WARRIOR "CRANK SHAFT POSITION SENSOR FAILURE" DATE OF FAILURE AUGUST, 30 2004 APPROX 3000 MILES PURCHASE DATE: JUNE 2004 1.) I WAS TRAVELING ON MY 2004 YAMAHA ROADSTAR WARRIOR AT 65 MPH IN CONGESTED HIGHWAY CONDITIONS AT NIGHT PRIOR/DURING THE DURING THE COMPONENT (CRANK SHAFT POSITION SENSOR) FAILURE. 2.) DUE TO THE "CRANK SHAFT POSITION SENSOR FAILURE" THE MOTORCYCLE'S MOTOR STOPPED RUNNING, I THEN PULLED/ACTIVATED THE MOTORCYCLE'S CLUTCH TO ALLOW THE VEHICLE TO CONTINUED IT'S FORWARD MOVEMENT/MOMENTUM, ALLOWING ME TO COAST ACROSS THREE LANES OF +65 MPH HIGHWAY TRAFFIC TO REACH THE BREAKDOWN LANE. 3.) THE MOTORCYCLE HAD TO BE TOWED TO THE YAMAHA DEALER TO REPLACE THE CRANK SHAFT POSITION SENSOR YAMAHA P/N 5PX-81670-00-00 DIAGNOSTIC CODE 12. *NM

DT: THERE IS A HUB ON THE BACK WHEEL, AND THE AXLE IS SUPPOSED TO BE TORQUED 110 LBS, BUT COULD NOT TORQUE IT DOWN BECAUSE OF THE WHEEL BINDING. THE HUB OF IS OFF CENTER OF THE WHEEL ,IT IS NOT LINED UP CORRECTLY. THE CENTER OF THE WHEEL WAS NOT CUT CORRECTLY WHEN IT WAS MANUFACTURERD. HAD DAMAGE IN THE SWING ARM, AND THIS IS WHEN IT WAS NOTICED IT, THIS WAS ON AUGUST 19, 2005. TOOK THE DAMAGED PARTS TO THE DEALER THEY DID PAID FOR HALF OF THE PARTS. THE CONSUMER IS STILL WAITING FOR THE WHEEL. *AK *NM

2004 YAMAHA ROADSTAR MIDNIGHT SILVERADO 1700 HAD A DEFECTIVE OIL PUMP SHAFT.*MR THE OIL PUMP SHAFT WHICH HOOKS TO THE TRANSMISSION BROKE RESULTING IN AN ACCIDENT. YAMAHA HAS SENT TWO GOODWILL GESTURES TO EXTEND THE WARRANTY. *NM

WHEN RIDING THE MOTORCYCLE AND PULLING OFF FROM A STAND STILL MOTORCYCLE BACKFIRED AND THEN STALLS OUT. OWNER STATED THAT THE MOTORCYCLE HAD BEEN AT THE DEALER FOR 22 DAYS, BUT THE DEFECT STILL HAD NOT BEEN RESOLVED. OWNER CONTACTED THE MANUFACTURER, BUT DID NOT GET ANY ASSISTANCE FROM THEM EITHER. *AK

MOTORCYCLE WAS LEAKING GAS FROM THE CARBURETOR. MOTORCYCLE WAS INSPECTED ON THREE DIFFERENT OCCASIONS AT THREE DEALERSHIP. A YAMAHA REPRESENTATIVE CAME FROM CALIFORNIA TO INSPECT THE MOTORCYCLE ABOUT MONTH AGO, AND HE NEVER NOTIFIED THE CONSUMER WHAT WAS WRONG WITH THE MOTORCYCLE.*AK

XV-175S ROAD STAR YAMAHA MOTORCYCLE - 2004. BIKE RAN INTO A CEMENT HIGHWAY BARRIER WHEN RIDER WAS ON WAY HOME FROM DRIVING BIKE OFF SHOWROOM FLOOR. WITNESSES SAID IT SEEMED AS IF HE COULDN'T TURN THE HANDLE BARS OR APPLY THE BRAKES.*AK

CONSUMER HAD BEEN WAITING ON PARTS FOR THE ROADSTAR FOR OVER 60 DAYS. DEALER STATED PARTS WERE STILL NOT AVAILABLE. TOUSLEY MOTOR SPORTS, 1400 E. COUNTY E. WHITELAKE , MN 55110 651-483-8296. *AK