YAMAHA Complaints

AFTER ONLY 7000 MILES THE CLUTCH BASKET CRACKED, BROKE, AND DEFECTED IN SPECTACULAR FASHION. THIS CAUSED THE GEARS TO SLIP, MORE DAMAGE TO BE DONE INTERNAL TO THE CLUTCH SYSTEM AND GREAT COST. THE PROBLEM WAS NOTED WHILE DRIVING. DURING ACCELERATION, THE MOTORCYCLE'S ENGINE WOULD REV THROUGH THE GEAR BUT NO ACCELERATION WAS EXPERIENCED. THIS CAUSED AN ALARMING CAUTION AS ATTEMPTING TO PASS VEHICLES, ACCELERATE THROUGH INTERSECTIONS, AND OTHERWISE MAINTAIN SPEEDS VERY DIFFICULT AND DIFFICULT TO DETERMINE PROPER AVOIDANCE OF SITUATIONS. TYPICALLY, A RIDER LIKE MYSELF CAN DETERMINE PROPER ACCELERATION AND TIMING TO AVOID THINGS LIKE OTHER VEHICLES, ROAD CONDITIONS, OR DANGEROUS SITUATIONS BUT ACCELERATING THROUGH, AROUND, OR AWAY FROM THEM. THIS WAS NEARLY IMPOSSIBLE DUE TO THIS BREAKAGE OF A NON-NORMAL WEARING PART.

CHARGING SYSTEM MELTS REPLACED STATOR, THE R/R, THE BATTERY AND ALL THE WIRES IN BETWEEN NO CHANGE ONE TIME IT WONT CHARGE THE NEXT TIME OVER CHARGES THE LAST ONE PUT IN MELTED IN 8 SECONDS. ALSO 2ND GEAR WHEN I SHIFT FEELS LIKE THE REAR END IS GOING TO FALL OFF

THE BIKE IS DYING WHENEVER I TRY TO COME TO A STOP OR SLOW DOWN. ANYTIME THE RPM'S DROP BELOW 1500 THE BIKE WILL JUST DIE, NOT TRY AND IDLE. THIS STARTED HAPPENING END OF MAY 2017 AND JUST WOULD HAPPEN ONCE, AND THEN AFTER I RESTARTED THE BIKE IT WOULD RUN JUST FINE ALL DAY NO PROBLEMS, AND WAS VERY ERRATIC WHEN IT WOULD HAPPEN. NOW TODAY (8.24.17) IT HAPPENS ALL THE TIME, WHENEVER RPMS GET LOW. BIKE HAS 8100 MILES ON IT, AND IS WELL CARED FOR AND MAINTAINED. BIKE IS CURRENTLY IN THE SHOP AS THEY ARE TRYING TO FIGURE OUT WHAT IS GOING ON.

2013 YAMAHA SUPER TENERE. ENGINE/IDLE SPEED VARIES AND/OR ENGINE DIES. SOMETIMES IT SPEEDS UP (TO AS MUCH AS 4000 RPM) WITHOUT ANY RIDER INPUT (DANGEROUS) AND IF THE CLUTCH IS ACTIVATED SIMULTANEOUSLY IT WON'T IDLE AND ENGINE DIES. ALSO DIFFICULTY STARTING. SEEMS TO HAPPEN MORE OFTEN IN COOLER TEMPERATURES VS WARM. TURNING OFF THE IGNITION THEN TURNING IT BACK ON SOMETIMES TEMPORALLY SEEMS TO RESET THINGS (MAY TAKE SEVERAL ATTEMPTS). IT WILL RUN AT CRUISE SPEEDS BUT ONCE SPEED IS REDUCED THE PROBLEMS OCCUR. A FAULT CODE OF 60 ONCE CAME UP ON THE DISPLAY. THE RIDER MUST BE PREPARED FOR UNCONTROLLED INCREASES OR DECREASES IN THROTTLE. RESEARCH HAS STRONGLY SUGGESTED THIS IS HAPPENING TO OTHER OWNERS AND MAY BE ASSOCIATED WITH A WIRING/ELECTRICAL CONNECTION ISSUE. IN MARCH OF 2016 I CONTACTED YAMAHA DIRECTLY AND THEY SUGGESTED I TAKE IT TO DEALER. TOOK IT TO DEALER AND THEY HAD IT 2 WEEKS AND WAS ADVISED THEY COULD NOT DUPLICATE THE PROBLEM. BUT IT IS INTERMITTENT AND GENERALLY UNPREDICTABLE EXCEPT FOR A SUBSTANTIAL INCREASE IN SYMPTOMS WHEN THE AMBIENT AIR TEMPERATURES DROP BELOW 70 DEGREES F AND ESPECIALLY BELOW 60. THIS FIRST OCCURRED IN JUNE OF 2015 AT 3050 MILES AND HAS CONTINUED OFF AND ON THROUGH THE PRESENT MILEAGE OF 35,000. IT OCCURRED CONSISTENTLY ON A RECENT TRIP NORTH (COOL TEMPS AND RAIN) AND THERE WERE NO SERVICES AVAILABLE FOR SEVERAL THOUSAND MILES. ONCE I ENCOUNTERED WARMER TEMPS ON THE RETURN TRIP SOUTH THE SYMPTOMS WENT AWAY FOR THE FINAL 2000 MILES OF A 9000 TRIP. SINCE I GENERALLY RIDE IN WARMER TEMPERATURES (SUMMER) IT HAS NOT OCCURRED CONSISTENTLY. BUT ON THIS RECENT TRIP IT HAPPENED EVERY DAY FOR OVER A WEEK AND REQUIRED EXTREME CAUTION AND WAS QUITE CHALLENGING TO CONTROL AND UNCERTAIN IF IT WOULD START OR CONTINUE RUNNING.

SPEEDOMETER IS NOT VISIBLE IN DAYLIGHT. IF AN ENGINE OR OIL PRESSURE WARNING ALARM IS ACTIVE, IT WOULD NOT ALERT THE RIDER, ME, AND CATASTROPHIC FAILURE COULD OCCUR OR EVEN DEATH, INCLUDING TO OTHER MOTORISTS, PEDESTRIANS AND PROPERTY AROUND ME.

ON SEVERAL OCCASIONS, MY 2012 YAMAHA XTZ1200 SUPER TENERE HAS FAILED TO DECELERATE WHEN I COMPLETELY SHUT THE THROTTLE. THE ENGINE CONTINUED TO REV AT OVER 3,000RPMS AND THE MOTORCYCLE MAINTAINED APPROXIMATELY 40MPH, WITHOUT THROTTLE INPUT. THIS MOTORCYCLE IS NOT EQUIPPED WITH CRUISE CONTROL. BRAKING TO STOP REQUIRED ME TO OVERCOME THE TORQUE OF THE ENGINE POWERING THE BIKE FORWARD AT OVER 3,000 RPMS IN ADDITION TO THE VELOCITY OF THE MACHINE ITSELF. WHEN I WAS ABLE TO FIND A SAFE PLACE TO STOP AND SHUT THE BIKE OFF, IT RESTARTED WITH THE SAME PROBLEM AND REQUIRED 5-7 RESTARTS UNTIL IT STARTED NORMALLY AND RAN WITHOUT ANY PROBLEM UNTIL THE NEXT TIME THE ISSUE OCCURRED WITHOUT WARNING: DURING THE SECOND INCIDENT I WAS APPROACHING AN EXIT RAMP AND LET OFF THE THROTTLE. THE BIKE DID NOT DECELERATE UNDER ENGINE BRAKING AS EXPECTED DUE TO THE FACT THAT THE ENGINE REMAINED AT THE RPMS I HAD BEEN TRAVELING. CLOSING THE THROTTLE HAD NO EFFECT ON THE SPEED OF THE ENGINE AND AS SUCH I ENTERED THE CORNER TOO FAST AND WAS FORCED TO DRAG THE BRAKES AGAINST THE POWER OF THE ENGINE. AGAIN, AFTER FINDING A SAFE PLACE TO STOP, A RESTART RESOLVED THE ISSUE EVENTUALLY. ON SEVERAL OTHER OCCASIONS, THE BIKE WOULD NOT IDLE AND DIED WHILE SITTING AT A RED LIGHT. THE ENGINE, IDLING NORMALLY, WOULD SUDDENLY DROP TO ABOUT 800 RPMS AND THEN STOP. IT HAS, ON OCCASION, REFUSED TO RESTART. DURING EACH OF THESE EPISODES, THE 'MODE SELECTOR' SWITCH THAT CONTROLS THE THROTTLE MAP FAILED TO WORK, BUT NO ENGINE OR FAULT CODE WAS SHOWN ON THE DASH.

TL* THE CONTACT OWNS A 2006 YAMAHA FZ1. WHILE DRIVING 40 MPH, THE MOTORCYCLE FELT UNSTABLE. THE CONTACT PULLED OVER AND NOTICED THAT THE FRAME OF THE MOTORCYCLE HAD FOLDED AND SUBSEQUENTLY COLLAPSED. THE CONTACT SAW THAT THE FRAME HAD FAILED AND FRACTURED IN HALF. THE MOTORCYCLE WAS NOT TAKEN TO A DEALER OR MECHANIC. THE DEALER WAS NOT CONTACTED. THE MOTORCYCLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND WAS DECIDING ON A COURSE OF ACTION. THE APPROXIMATE FAILURE MILEAGE WAS 18,000.

MISHAFT SNAPPED, CAUSING THE NUT TO POTENTIALLY LOCKUP THE DRIVE SHAFT AND REAR WHEEL, POTENTIALLY CAUSING LOSS OF CONTROL AND CRASH. THERE ARE HUNDREDS OF REPORTS ON THE MOTORCYCLE FORUMS FOR THE VSTAR 1100 SERIES. SHAFT SNAPS UNDER NORMAL DRIVING CONDITIONS AND CAN BE DISTINGUISHED BY A HIGH PITCH WHINE DURING DECELERATION AS THE BROKEN-OFF SHAFT NUT GRINDS AGAINST THE DRIVE SHAFT.

THE HEADLIGHT DESIGN FOR THE 2017 YAMAHA FZ-09 IS UNSAFE. WHEN DRIVING AT NIGHT ON A DARK ROAD THE HEADLIGHTS DO NOT ILLUMINATE TURNS. YOU CANNOT SEE THE TURN ENTRY NOR THE APEX. THE UPLOADED PICTURES SHOW THE PROBLEM WITH THE YAMAHA LED LIGHT PATTERN. VERY DANGEROUS! IN NEED OF A RECALL. PLEASE HELP!

ON THESE MODEL THE SHAFT ON THE FINAL-DRIVE GOING INTO THE REAR DIFFERENTIAL IS NOT OILED NOR HAS ENOUGH GREASE TO LAST OVER 10K MILES. I HAVE HAD THIS BIKE SERVICED AT EVERY SERVICE INTERVAL AND GREASING THE SPLINES IS NOT IN THE SERVICE. NOR CAN THEY BE GREASED WHEN THE TIRE CHANGE IS PERFORMED WITHOUT HAVING TO REMOVE THE 4 BOLTS THAT HOLD THE DRIVE SHAFT IN THE COVER OF THE DIFFERENTIAL. MY SPLINES STRIPPED OUT WHILE TRAVELING AT 70 MPH ON A HIGHWAY CAUSING ME TO BE STRANDED AND ALMOST BEING RAN OVER BY THE CARS THAT WERE BEHIND ME TRAVELING THE SAME DIRECTION DUE TO THE BIKE LOOSING SPEED AND SLOWING DOWN VERY QUICKLY. WHEN I TOOK THE BIKE IN TI BE INSPECTED THE SPLINES WERE BONE-DRY AND THE PART THAT HAD STRIPPED WAS ON THE PARTS DIAGRAM BUT DIDN'T HAVE A PART NUMBER SO I COULD NOT ORDER THE PART I HAD TO BUY THE ENTIRE REAR DIFFERENTIAL ASSEMBLY AT AROUND $1,200.00 TO $1,300.00 DOLLARS.. I'M SURE YAMAHA IS AWARE OF THIS DUE TO THE FACT THEY QUIT MAKING THIS MODEL FOR A COUPLE YEARS AND NOW THE REAR DIFFERENTIAL HAS BEEN ENGINEERED DIFFERENTLY, THE SPLINES ARE NOW KEPT OILED BY GEAR OIL IN THE REAR DIFFERENTIAL.. IF I DIDN'T MANEUVER QUICKLY I WOULD HAVE BEEN IN A TERRIBLE ACCIDENT..